gearbox PEUGEOT 5008 2011 Owner's Guide

PRACTICAL INFORMATION
210
TOWING A TRAILER, A CARAVAN, ETC.
Your vehicle is primarily designed for
transporting people and luggage, but it
may also be used for towing a trailer.

Driving advice


Side wind


)
Take into account the increased
sensitivity to side wind.


Cooling
Towing a trailer on a slope increases
the temperature of the coolant.
As the fan is electrically controlled, its
cooling capacity is not dependent on
the engine speed.


)
To lower the engine speed, reduce
your speed.
Towbar suitable for the attachment of a
trailer or caravan with additional lighting
and signalling.

Distribution of loads


)
Distribute the load in the trailer so
that the heaviest items are as close
as possible to the axle and the nose
weight approaches the maximum
permitted without exceeding it.
Air density decreases with altitude, thus
reducing engine performance. Above
1 000 metres, the maximum towed load
must be reduced by 10 % for every
1 000 metres of altitude.
Refer to the "Technical Data" section for
details of the weights and towed loads
which apply to your vehicle. Driving with a trailer places greater de-
mands on the towing vehicle and the
driver must take particular care.
We recommend the use of
genuine PEUGEOT towbars
and their harnesses that have
been tested and approved from the
design stage of your vehicle, and that
the fi tting of the towbar is entrusted
to a PEUGEOT dealer or a qualifi ed
workshop.
If the towbar is not fi tted by a
PEUGEOT dealer, it is imperative
that it is fi tted in accordance with the
vehicle manufacturer's instructions.

General
recommendations
Observe the legislation in force in
your country.
Ensure that the weight of the tow-
ing vehicle is higher than that of the
towed vehicle.
The driver must stay at the wheel of
the towed vehicle.
Driving on motorways and fast roads
is prohibited when towing.
When towing a vehicle with all four
wheels on the ground, always use an
approved towing bar; rope and straps
are prohibited.
When towing a vehicle with the en-
gine off, there is no longer any power
assistance for braking or steering.
In the following cases, you must al-
ways call on a professional recovery
service:


- vehicle broken down on a motor-
way or fast road,

- when it is not possible to put the
gearbox into neutral, unlock the
steering, or release the parking
brake,

- towing with only two wheels on
the ground,

- where there is no approved towing
bar available...

TECHNICAL DATA
214


ENGINES AND GEARBOXES



Petrol engine


1.6 litre VTi

120 hp



1.6 litre THP
156 hp



Gearbox

Manual
(5-speed)
Manual
(6-speed)
Automatic
(6-speed)
Cubic capacity (cc)
1 598
1 598
Bore x stroke (mm)
77 x 85.8
77 x 85.8
Max power: EU standard (kW)
88
11 5
Max power engine speed (rpm)
6 000
6 000
Max torque: EU standard (Nm)
160
240
Max torque engine speed (rpm)
4 250
1 400
Fuel
Unleaded
Unleaded
Catalytic converter
yes
yes

OIL CAPACITIES (in litres)






Engine (with fi lter replacement)
4.25
4.25
Gearbox - Final drive
-
-

TECHNICAL DATA
*
The kerb weight is equal to the unladen weight + driver (75 kg).

**
The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

WEIGHTS AND TOWED LOADS (in kg)



Petrol engine


1.6 litre VTi
120 hp



1.6 litre THP
156 hp



Gearbox

Manual
(5-speed)



Manual (6-speed)/
Automatic (6 speed)

Seats

5
7
5
7


- Unladen weight
1 427
1 454
1 460
1 490


- Kerb weight *

1 502
1 532
1 535
1 565


- Payload
573
736
590
735


- Gross vehicle weight (GVW)
2 000
2 190
2 050
2 225


- Gross train weight (GTW)
on a 12% gradient
3 200
3 290
3 400
3 425


- Braked trailer (within GTW limit)
on a 10% or 12% gradient
1 200
1 100
1 350
1 200


- Braked trailer ** (with load transfer
within the GTW limit)
1 400
1 550
1 500


- Unbraked trailer
750
750


- Recommended nose weight
70
70
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10% for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.

TECHNICAL DATA


ENGINES AND GEARBOXES



Diesel engine


1.6 litre Turbo e-HDi

110 hp



2 litre Turbo HDi
150 hp



2 litre Turbo HDi
163 hp



Gearbox

Manual
(6-speed)


Electronic gear control
(6-speed)
Manual
(6-speed)
Automatic
(6-speed)
Cubic capacity (cc)
1 560
1 997
Bore x stroke (mm)
75 x 88.3
85 x 88
Max power: EU standard (kW)
82
110/120
Max power engine speed (rpm)
4 000
3 750
Max torque: EU standard (Nm)
270
320/340
Max torque engine speed (rpm)
1 750
2 000
Fuel
Diesel
Diesel
Catalytic converter
yes
yes
Particle emission fi lter
yes
yes

OIL CAPACITIES (in litres)






Engine (with fi lter replacement)
3.75
-

TECHNICAL DATA
217


WEIGHTS AND TOWED LOADS (in kg)



Diesel engine


1.6 litre Turbo e-HDi
110 hp



Gearbox

Manual
(6-speed)
Electronic gear control
(6-speed)

Seats

5
7
5
7


- Unladen weight
1 475
1 502
1 475
1 502


- Kerb weight *

1 550
1 578
1 550
1 578


- Payload
595
748
595
748


- Gross vehicle weight (GVW)
2 070
2 250
2 070
2 250


- Gross train weight (GTW)
on a 12% gradient
3 170
3 250
3 170
3 150


- Braked trailer (within GTW limit)
on a 10% or 12% gradient
1 100
1 000
1 100
900


- Braked trailer ** (with load transfer
within the GTW limit)
1 300
1 300
1 300
1 100


- Unbraked trailer
745
750
745
750


- Recommended nose weight
70
70

* The kerb weight is equal to the unladen weight + driver (75 kg).

**
The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding. The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.

TECHNICAL DATA
218


WEIGHTS AND TOWED LOADS (in kg)



Diesel engine


1.6 litre Turbo e-HDi
110 hp



Gearbox

Manual
(6-speed) Score
Electronic gear control
(6-speed) Score

Seats

5
7
5
7


- Unladen weight
1 475
1 502
1 475
1 502


- Kerb weight *

1 550
1 578
1 550
1 578


- Payload
595
748
595
748


- Gross vehicle weight (GVW)
2 070
2 250
2 070
2 250


- Gross vehicle weight (MTRA)
on a 12% gradient
2 950
2 950
2 920
2 950


- Braked trailer (within GTW limit)
on a10% or 12% gradient
880
700
850
700


- Braked trailer ** (with load transfer
within the GTW limit)
1 080
900
1 050
900


- Unbraked trailer
745
750
745
700


- Recommended nose weight
70
70

* The kerb weight is equal to the unladen weight + driver (75 kg).

**
The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding. The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.

TECHNICAL DATA
219


WEIGHTS AND TOWED LOADS (in kg)



Diesel engine


2 litre Turbo HDi
150 hp



2 litre Turbo HDi
163 hp



Gearbox

Manual
(6-speed)
Automatic
(6-speed)

Seats

5
7
5
7


- Unladen weight
1 563
1 593
1 589
1 619


- Kerb weight *

1 638
1 668
1 664
1 694


- Payload
562
717
536
711


- Gross vehicle weight (GVW)
2 125
2 310
2 125
2 330


- Gross train weight (GTW)
on a 12% gradient
3 475
3 510
3 525
3 530


- Braked trailer (within GTW limit)
on a 10% or 12% gradient
1 350
1 200
1 400
1 200


- Braked trailer ** (with load transfer
within the GTW limit)
1 550
1 500
1 600
1 500


- Unbraked trailer
750
750


- Recommended nose weight
70
70

* The kerb weight is equal to the unladen weight + driver (75 kg).

**
The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding. The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.

TECHNICAL DATA
220


WEIGHTS AND TOWED LOADS - 5008 5-seat LCV (in kg)



Engine


1.6 litre Turbo e-HDi
110 hp



2 litre Turbo HDi
150 hp



Gearbox

Manual
(6-speed)


Electronic gear control
(6-speed)
Manual
(6-speed)


Manual
(6-speed)

Model codes

9HZ
9HZ
9HR
RHE


- Unladen weight
1 481
1 482
1 481
1 572


- Kerb weight *

1 556
1 557
1 556
1 647


- Gross vehicle weight (GVW) **

2 225
2 230
2 200
2 310


- Gross train weight (GTW)
on a 12% gradient ***

3 120
3 170
3 475


- Braked trailer (within GTW limit)
on a 10% or 12% gradient ****

895
890
970
1 165


- Braked trailer (with load transfer
within the GTW limit)
X
X
X
X


- Unbraked trailer

750
750


- Recommended nose weight
70
70

* The kerb weight is equal to the unladen weight + driver (75 kg).

**
Exceeding the maximum rear axle weight involves limiting the speed to 50 mph (80 km/h) as defi ned in point 2.7 of
the Directive.

***
Exceeding the gross vehicle weight when the vehicle is towing involves limiting the speed to 50 mph (80 km/h) as defi ned
in point 2.7 of the Directive.

****
Maximum braked trailer weight within the GTW limit; warning, towing using a lightly loaded towing vehicle may have an
adverse effect on its road holding.

The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10% for each additional 1 000 metres of altitude.
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.

ALPHABETICAL INDEX
326
Eco-driving ..............................25
Economical driving .................25
Economy mode......................208
Electric window
controls .................................83
Electronic engine
immobiliser ......................78, 80
Electronic stability control
(ESC) ..................................130
Emergency boot
release ..................................88
Emergency call ..............224, 225
Emergency warning
lamps ..................................128
Energy economy
mode ...................................208
Engine, Diesel ........90, 173, 175,
214, 215, 216, 217, 220
Engine, petrol ..................90, 174
Engine compartment .....174, 175
Engine compartment
fusebox ...............................199
Engine oil level
indicator ........................40, 176
Engines..........................214, 216
Environment ......................25, 80
ESC/ASR ...............................130
ESP/ASR ...............................131
E
Halogen headlamps...............194
Hands-free kit ........291, 292, 313
Hazard warning lamps ...........128
Head-up display.....148, 152, 154
Headlamp adjustment........94, 95
Headlamps, directional ....95, 194
Headlamp wash .......................97
Headlamp wash reservoir ......176
Head restraints, front ...............67
Head restraints, rear ................69
Heated seats ...........................67
Heating ........................25, 59, 60
Height and reach adjustment,
steering wheel .......................75
High load retaining net........... 112
Hill start assist .......................145
Hooks ............................ 110, 114
Horn .......................................128
H
Filling with fuel ...................89, 90
Fitting a wheel .......................192
Fitting roof bars...................... 211
Fittings, boot .................. 109, 110
Flashing indicators.................128
Foglamps, rear ........................92
Folding the rear seats ...69, 71, 72
Front foglamps.........92, 194, 196
Front seats...................65, 66, 68
Fuel..............................25, 89, 90
Fuel consumption ....................25
Fuel fi ller cap ...........................89
Fuel fi ller fl ap .....................89, 90
Fuel gauge...............................89
Fuel tank ............................89, 90
Fusebox, dashboard ..............199
Fuses .....................................199
FDirectional lighting ...................95
Direction
indicators ............128, 194, 197
Distance alert.........................150
Doors .......................................85
Doors emergency
control ...................................87
Door trays ..............................102
Dynamic emergency
braking ................................143
G.P.S. ............................238, 277
Gearbox, automatic .......161, 178
Gearbox, electronic
gear control .........157, 164, 178
Gearbox,
manual ................156, 164, 178
Gear effi ciency
indicator ..............................156
Gear lever ................................25
Gear lever,
automatic gearbox ..............161
Gear lever, electronic gear
control gearbox ...................157
Gear lever,
manual gearbox ..................156
Glove box ......................102, 103
Grab handles .........................102
Guidance .......................238, 277
Guide-me-home.......................94
G
Identifi cation plates ................222
Indicator lamps, status.............30
Indicators, direction ...............128
Infl ating accessories
(using the kit) ......................179
Infl ating tyres ...........................25
Inputs for audio
system ........254, 290, 310, 312
Instrument panel lighting .........41
Instrument panels ..............27, 28
Instrument panel
screen ...........................27, 156
Intelligent Traction
Control ................................130
Interior fi ttings ........................102
Interior mood lighting .............100
ISOFIX child seats ......... 123-125
ISOFIX mountings .................123
I

VISUAL SEARCH
332
INSTRUMENTS AND CONTROLS


Courtesy lamps..................... 99, 100
Seat belt/passenger's front airbag
warning lamps display ...... 133, 137
Rear view mirror ........................... 75

Dashboard fuses ................. 199-202

6-speed manual gearbox ............ 156
Gear effi ciency indicator ............. 156
Electronic gear control
gearbox ............................. 157-160
Automatic
gearbox ............................. 161-163
Stop & Start ......................... 164-166
Hill start assist ............................ 145
Eco-driving............................... 25-26
Ventilation ................................ 58-59
Rear ventilation............................. 59
Manual air conditioning............ 60-61
Digital air conditioning ............. 62-64
Demist/defrost .............................. 61

Centre console ........................... 104
Peugeot Connect USB .... 112, 288, 310
Peugeot Connect Media
navigation (RT6) ..... 227-270
Setting the date/time ...... 260

Sun visor..................................... 103

Opening the bonnet .................... 172

Electric parking
brake ..................140-144, 146-147
Interior
fi ttings ........................ 102-103, 105


- sun visor

- driver's storage compartments

- glove box

- mat


12 V accessory socket................ 104




Peugeot Connect Navigation (RNEG) ............... 271-302
Setting the date/time ...294

Peugeot Connect
Sound (RD5) ....... 303-324
Setting the date/time .... 316, 317