tow PEUGEOT BOXER 2002 Owner's Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2002, Model line: BOXER, Model: PEUGEOT BOXER 2002Pages: 182, PDF Size: 1.93 MB
Page 134 of 182
16-09-2002
YOUR BOXER IN DETAIL135
REAR PARKING ASSISTANCE This system consists of proximity
sensors, located in the rear bumper,and a special speaker fitted in thefascia. This detects any obstacle (person, vehicle, tree, gate, pavement etc.)behind the vehicle. Note:
this function will be disarmed
automatically when the vehicle is
towing a trailer.
In wintry weather, ensure that the sensors are not covered with frost or
snow.
Activation The system is activated as soon as reverse gear is engaged; an audiblebleep shows that it is active. The proximity information is given by an audible signal, which becomesmore rapid as the vehicle approachesthe obstacle. When the distance between the rear of the vehicle and the obstacle is lessthan approximately twenty centi-metres, the audible signal becomescontinuous.Deactivation ☞
Change to neutral, the system is again inactive.
Detection zone
If there is an operating fault, the audible signalwill be a short bleep follo-wed by a long bleep when
changing to reverse gear.
Page 145 of 182
16-09-2002
Only use products
approved by Automobiles
PEUGEOT.
To ensure best perfor-
mance from components
as important as the power steering and the braking system,PEUGEOT selects and offersquite specific products.
CHECKS Battery
At the start of winter, have your bat-
tery checked by a PEUGEOT dealer. Air filter and pollen filter Have the filter elements replaced
regularly. If you drive in dusty
conditions, change them twice asoften. Brake pads Brake pad wear depends on the style of driving, in particular forvehicles which are used in town,over short distances. It may benecessary to check the thickness ofthe pads, even between services. Handbrake Where the handbrake travel is too great or there is a reduction in theperformance of the system, thehandbrake should be adjusted, evenbetween services. Have the system checked by a
PEUGEOT dealer. Manual gearbox This does not need an oil change. Check the level, according to themanufacturer's servicing schedule. Automatic gearbox This does not need an oil change. Have the level checked by a
PEUGEOT dealer, according to themanufacturer's servicing schedule. Oil filter
Change the filter regularly, in accor- dance with the servicing schedule.
Fuel supply cut-off In a serious collision, a system pre- vents fuel from reaching the engine.
To
re-establish the fuel supply, press
the switch on the angle of the front
left-hand suspension assembly,under the bonnet.
PRACTICAL INFORMATION
144
Page 150 of 182
16-09-2002
Rear lights
1 - Brake lights (P 21 W).
2 - Reversing lights (P 21 W).
3 - Direction indicators (PY 21 W).
4 - Fog lamps / Side lights
(P 21/4 W). ☞
Unscrew the two bolts Aand
release the unit,
☞ Disconnect the connector B,
☞ Unscrew the two bolts Cat the
rear of the unit,
☞ Change the faulty bulb.
PRACTICAL INFORMATION 149
Number plate lights (C 5 W) ☞ Insert a thin screwdriver into one of the external holes of the lens.
☞ Push it outwards to unclip it.
☞ Remove the lens.
☞ Unscrew the bolt and release theassembly towards the right to
extract the bulb holder.
☞ Change the faulty bulb.
Chassis cab lights (W 5 W) ☞Unscrew the four bolts to gain access to the bulbs.
Third brake light (W 5 W) ☞
Unscrew the 2 fixing screws.
☞ Release the lamp unit by pushing it outwards.
☞ Disconnect the connector.
☞ Squeeze the two tabs to release
the bulb holder.
☞ Change the faulty bulb.
☞ When refitting, ensure that thelamp unit seal has been put back
in place correctly.
Page 159 of 182
16-09-2002
TOWING YOUR VEHICLE
W ithout lifting (4 wheels on the ground)
Y ou must always use a tow bar.
The towing eyes are located at the front and the rear under the vehicle's bumpers. Lifting (2 wheels only on the ground) It is preferable to raise the vehicle with a professional lifting device. Special features of the automatic gearbox When towing with four wheels on the ground, the following rules must beobeyed: -
lever in position N,
- tow the vehicle at less than
50 km/h over a maximum distanceof 50 km,
- do not add oil to the gearbox.
PRACTICAL INFORMATION 157
When towing with the engine switched off, thereis no braking or steeringassistance.
Page 160 of 182
16-09-2002
TOWING A TRAILER,
CARAVAN, BOAT ETC.
Only use original PEUGEOT tow bars that have been tested andapproved from the design stage ofyour vehicle. The tow bar must be fitted by a
PEUGEOT dealer. Y our vehicle is basically designed
for transporting people and luggage but it may also be used for towing a
trailer. Driving with a trailer subjects the towing vehicle to more significantstress and its driver must be particu-larly careful. Air density decreases with altitude, thus reducing engine performance.Above 1000 metres, the maximumtowing load must be reduced by 10%and so on for every 1000 metres ofaltitude. Driving advice Distribution of loads:
Distribute the
load in the trailer so that the heaviest items are as close as possible to theaxle and the nose weight approachesthe maximum permitted without excee-ding it. Cooling: towing a trailer on a slope
increases the temperature of the coolant. As the fan is electrically controlled, its cooling capacity is not dependenton the engine speed.
On the contrary, use a high gear to lower the engine speed, and reduceyour speed. The maximum towing load on a long slope depends on the gradient andthe outside temperature. In all cases, pay attention to the coolant temperature. If the warning light comes on, stop
the vehicle and switch off the engineas soon as possible. T
yres: check the tyre pressures of
the towing vehicle and of the trailer,observing the recommended pres-sures. Braking: towing increases the braking
distance.Lights: check the electrical signalling
on the trailer.Side wind: take into acount the
increased sensitivity to side wind.
PRACTICAL INFORMATION
158
Page 161 of 182
16-09-2002
PRACTICAL INFORMATION159
ACCESSORIES FOR YOUR BOXER
For your PEUGEOT only use accessories and original parts approved by the manufacturer.
These accessories and parts are all adapted to your PEUGEOT, after being tested and approved for reliability and safe-
ty, which PEUGEOT cannot guarantee for other products. A
wide choice of original accessories, approved by PEUGEOT, is available through the dealer network. They all carry
the PEUGEOT guarantee: – Safety : Fog lamps, driver/rear doors separation grilles, anti-theft alarms, window engraving, wheel locks, window protection film, first aid kit, warning triangle, ...
– Comfort : Covers with and without air bags, mats, luggage net, door deflectors, CD storage, sidewindows, thermoformed protectors, wood or metal fittings, mud flaps, ...
– Communication : Audio systems, telephone, hands-free kit, speakers, CD changer, navigation sys-tems,...
– Leisure : Tow bars, snow chains, roof bars with sill plate, ladder, loading roller, ...
– Maintenance products : Screenwash, interior and exterior maintenance and cleaning products, ...
Before installing any electrical accessory on your vehicle, contact a PEUGEOT dealer.
Page 167 of 182
16-09-2002
2 LITRE INJECTIONVAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1695 1730 1735 1745 1780 1695 1730 1735 1745 1780
¥ Gross vehicle weight (GVW) 2900 2900 2900 2900 2900 3300 3300 3300 3300 3300
¥ Payload 1205 1170 1165 1155 1120 1605 1570 1565 1555 1520
¥ Gross train weight (GTW)* Ð ÐÐÐÐ ÐÐ ÐÐ Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000 2000 2000
TECHNICAL DATA 165
W eights and towing loads (in kg)
* Dans le cas dÕun vŽhicule tracteur, la vitesse est limitŽe ˆ 100 km/h.
2 LITRE INJECTION VAN
Model codes:
330LH 330LHS 350C 350CS 350M 350MH 350MHS 350LH 350LHS
¥ Kerb weight 1815 1865 1765 1800 1785 1795 1830 1865 1915
¥ Gross vehicle weight (GVW) 3300 3300 3500 3500 3500 3500 3500 3500 3500
¥ Payload 1485 1435 1735 1700 1715 1705 1670 1635 1585
¥ Gross train weight (GTW)* ÐÐÐÐÐ ÐÐÐÐ
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000 2000 2000
Page 168 of 182
16-09-2002
TECHNICAL DATA
166
2 LITRE INJECTION
CHASSIS CHASSIS DOUBLE PLATFORM PLATFORM DOUBLECAB CAB CAB CAB
Model codes: 330L 350L 350L 330L 350L 350L
¥ Kerb weight 1565 1615 1770 1795 1845 1950
¥ Gross vehicle weight (GVW) 3300 3500 3500 3300 3500 3500
¥ Payload 1735 1885 1730 1505 1655 1550
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000
Weights and towing loads (in kg)
* Dans le cas dÕun vŽhicule tracteur, la vitesse est limitŽe ˆ 100 km/h.
2 LITRE INJECTIONFLAT FLOOR COMBI MINIBUS CAB
Model codes: 330L 350L 290C 330M 330MH 290C 330MH
¥ Kerb weight 1530 1580 1805 1845 1945 1925 2065
¥ Gross vehicle weight (GVW) 3300 3500 2900 3300 3300 2900 3300
¥ Payload 1770 1920 1095 1455 1355 975 1235
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2000 2000 2000 2000 2000 2000 2000
Page 169 of 182
16-09-2002
TECHNICAL DATA167
2 LITRE TURBO HDI
VAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1755 1790 1795 1805 1840 1755 1790 1795 1805 1840
¥ Gross vehicle weight (GVW) 2900 2900 2900 2900 2900 3300 3300 3300 3300 3300
¥ Payload 1145 1110 1105 1095 1060 1545 1510 1505 1495 1460
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600 1600 1600 1600 1600 1600
W eights and towing loads (in kg)
* Dans le cas dÕun vŽhicule tracteur, la vitesse est limitŽe ˆ 100 km/h. 2 LITRE TURBO HDI
CHASSIS CAB
Model codes: 290C 290M 330C 330M 330L
¥ Kerb weight 1600 1610 1600 1610 1625
¥ Gross vehicle weight (GVW) 2900 2900 3300 3300 3300
¥ Payload 1300 1290 1700 1690 1675
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð
¥ Unbrakd trailer 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600
Page 170 of 182
16-09-2002
TECHNICAL DATA
168
Weights and towing loads (in kg)
* Dans le cas dÕun vŽhicule tracteur, la vitesse est limitŽe ˆ 100 km/h. 2 LITRE TURBO HDI BARE CHASSIS COMBI MINIBUS
Model codes: 290C 330C 330M 330L 290C 330M 290C
¥ Kerb weight 1310 1310 1320 1335 1865 1905 1985
¥ Gross vehicle weight (GVW) 2900 3300 3300 3300 2900 3300 2900
¥ Payload 1590 1990 1980 1965 1035 1395 915
¥ Gross train weight (GTW)* Ð Ð Ð Ð Ð Ð Ð
¥ Unbraked trailer 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600 1600 1600
2 LITRE TURBO HDI PLATFROM CAB FLAT FLOOR CAB
Model codes:
290C 290M 330C 330M 330L 290C 290M 330C 330M 330L
¥ Kerb weight 1780 1815 1780 1815 1855 1555 1570 1555 1570 1590
¥ Gross vehicle weight (GVW) 2900 2900 3300 3300 3300 2900 2900 3300 3300 3300
¥ Payload 1120 1085 1520 1485 1445 1345 1330 1745 1730 1710
¥ Gross train weight (GTW)* Ð ÐÐÐÐ ÐÐ ÐÐ Ð
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1600 1600 1600 1600 1600 1600 1600 1600 1600 1600