tow PEUGEOT BOXER DAG 2003 Owner's Manual

17-11-2003
Only use products recom-
mended by PEUGEOT.
To ensure best perform- ance from components as
important as the power steering andthe braking system, PEUGEOTselects and offers quite specificproducts.
CHECKS Battery
At the start of winter, have your bat-
tery checked by a PEUGEOT dealer. Air filter and passenger compartment filter Have the filter elements replaced
regularly. If you drive in dusty con-
ditions, change them twice asoften. Brake pads Brake pad wear depends on the style of driving, in particular for vehi-cles which are used in town, overshort distances. It may be necessary to check the thickness of the pads, even betweenservices. Handbrake Where the handbrake travel is too great or there is a reduction in theperformance of the system, thehandbrake should be adjusted, evenbetween services. Have the system checked by a
PEUGEOT dealer. Oil filter
Change the filter regularly, in accor- dance with the servicing schedule.
Fuel supply cut-off In a serious collision, a system pre- vents fuel from reaching the engine.
To re-establish the fuel supply, press the switch on the angle of the front
left-hand suspension assembly,under the bonnet.
PRACTICAL INFORMATION 135

17-11-2003
Rear lights
1 - Brake lights (P 21 W).
2 - Reversing lights (P 21 W).
3 - Direction indicators (PY 21 W).
4 - Fog lamps/Side lights (P 21/4 W). 
Unscrew the two bolts Aand
release the unit,
 Disconnect the connector B,
 Unscrew the two bolts Cat the
rear of the unit,
 Change the faulty bulb.
PRACTICAL INFORMATION
140
Number plate lights (C 5 W) Insert a thin screwdriver into one of the external holes of the lens.
 Push it outwards to unclip it.
 Remove the lens.
 Unscrew the bolt and release theassembly towards the right to
extract the bulb holder.
 Change the faulty bulb.
Chassis cab lights (W 5 W) Unscrew the four bolts to gain access to the bulbs.
Third brake light (W 5 W) 
Unscrew the 2 fixing screws.
 Release the lamp unit by push- ing it outwards.
 Disconnect the connector.
 Squeeze the two tabs to release
the bulb holder.
 Change the faulty bulb.
 When refitting, ensure that thelamp unit seal has been put back
in place correctly.

17-11-2003
TOWING YOUR VEHICLE
Without lifting (4 wheels on the ground)
You must always use a tow bar. The towing eyes are located at the front and the rear under the vehicle's bumpers. Lifting (2 wheels only on the ground) It is preferable to raise the vehicle with a professional lifting device.Special features of the automatic gearbox When towing with four wheels on the ground, the following rules must beobeyed:
Ð lever in position
N,
Ð tow the vehicle at less than 30 mph (50 km/h) over a maximum dis- tance of 30 miles (50 km).
PRACTICAL INFORMATION
148
When towing with the engine switched off, thereis no braking or steeringassistance.

17-11-2003
TOWING A TRAILER,
CARAVAN, BOAT etc.
Only use original PEUGEOT tow bars that have been tested andapproved from the design stage ofyour vehicle. The tow bar must be fitted by a
PEUGEOT dealer.
Your vehicle is primarily designed for transporting people and luggage butit may also be used for towing a
trailer. Driving with a trailer subjects the towing vehicle to more significantstress and its driver must be particu-larly careful. Air density decreases with altitude, thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by 10 %
and so on for every 1 000 metres ofaltitude.Driving advice Distribution of loads:
Distribute the
load in the trailer so that the heaviest items are as close as possible to theaxle and the nose weight approachesthe maximum permitted withoutexceeding it. Cooling: Towing a trailer on a slope
increases the temperature of the coolant. As the fan is electrically controlled, its cooling capacity is not dependenton the engine speed.
On the contrary, use a high gear to lower the engine speed and reduceyour speed. The maximum towing load on a long slope depends on the gradient andthe outside temperature. In all cases, pay attention to the coolant temperature. If the warning light comes on, stop
the vehicle and switch off the engineas soon as possible. Tyres:
Check the tyre pressures
of the towing vehicle and of the
trailer, observing the recommendedpressures. Braking: Towing increases the
braking distance. Lights: Check the electrical signal-
ling on the trailer.Side wind: Take into acount the
increased sensitivity to side wind.
PRACTICAL INFORMATION 149

17-11-2003
PRACTICAL INFORMATION
150
ACCESSORIES FOR YOUR BOXER
For your PEUGEOT only use accessories and original parts approved by the manufacturer.
These accessories and parts are all adapted to your PEUGEOT, after being tested and approved for reliability and safety,
which PEUGEOT cannot guarantee for other products.
A wide choice of original accessories, approved by PEUGEOT, is available through the dealer network. They all carry
the PEUGEOT guarantee.
Ð Safety :
Fog lamps, driver/rear door separation grilles, anti-theft alarms, window engraving, wheel locks, window protection film, first aid kit, warning triangle, parking assistance, safety jacket, ...
Ð Comfort : Covers with and without air bags, mats, door deflectors, side windows, thermoformed protectors, wood or metal fittings, mud flaps, ...
Ð Communication : Audio systems, audio/telephone, hands-free kit, speakers, CD changer, navigation systems, ...
Ð Customising : Alloy wheels.
Ð Leisure : Tow bars, snow chains, roof bars with sill plate, ladder, loading roller, ...
Ð Maintenance products : Screenwash, interior and exterior maintenance and cleaning products, ...
Before installing any electrical accessory on your vehicle, contact a PEUGEOT dealer.

17-11-2003
2 LITRE INJECTIONVAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1 695 1 730 1 735 1 745 1 780 1 695 1 730 1 735 1 745 1 780
¥ Gross vehicle weight (GVW) 2 900 2 900 2 900 2 900 2 900 3 300 3 300 3 300 3 300 3 300
¥ Payload 1 205 1 170 1 165 1 155 1 120 1 605 1 570 1 565 1 555 1 520
¥ Gross train weight (GTW)* 4 900 4 900 4 900 4 900 4 900 5 300 5 300 5 300 5 300 5 300
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000
TECHNICAL DATA
154
Weights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2 LITRE INJECTION VAN
Model codes:
330LH 330LHS 350C 350CS 350M 350MH 350MHS 350LH 350LHS
¥ Kerb weight 1 815 1 865 1 765 1 800 1 785 1 795 1 830 1 865 1 915
¥ Gross vehicle weight (GVW) 3 300 3 300 3 500 3 500 3 500 3 500 3 500 3 500 3 500
¥ Payload 1 485 1 435 1 735 1 700 1 715 1 705 1 670 1 635 1 585
¥ Gross train weight (GTW)* 5 300 5 300 5 500 5 500 5 500 5 500 5 500 5 500 5 500
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000
Recommended nose weight: 80 kg

TECHNICAL DATA155
2 LITRE INJECTION
CHASSIS CHASSIS DOUBLE PLATFORM PLATFORM DOUBLE CAB CAB CAB CAB
Model codes: 330L 350L 350L 330L 350L 350L ¥ Kerb weight 1 565 1 615 1 770 1 795 1 845 1 950
¥ Gross vehicle weight (GVW) 3 300 3 500 3 500 3 300 3 500 3 500
¥ Payload 1 735 1 885 1 730 1 505 1 655 1 550
¥ Gross train weight (GTW)* 5 300 5 500 5 500 5 300 5 500 5 500
¥ Unbraked trailer 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2 000 2 000 2 000 2 000 2 000 2 000
Weights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2 LITRE INJECTIONFLAT FLOOR COMBI MINIBUS CAB
Model codes: 330L 350L 290C 330M 330MH 290C 330MH ¥ Kerb weight 1 530 1 580 1 805 1 845 1 945 1 925 2 065
¥ Gross vehicle weight (GVW) 3 300 3 500 2 900 3 300 3 300 2 900 3 300
¥ Payload 1 770 1 920 1 095 1 455 1 355 975 1 235
¥ Gross train weight (GTW)* 5 300 5 500 4 900 5 300 5 300 4 900 5 300
¥ Unbraked trailer 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2 000 2 000 2 000 2 000 2 000 2 000 2 000
Recommended nose weight: 80 kg
17-11-2003

TECHNICAL DATA
156
2 LITRE TURBO HDI
VAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1 755 1 790 1 795 1 805 1 840 1 755 1 790 1 795 1 805 1 840
¥ Gross vehicle weight (GVW) 2 900 2 900 2 900 2 900 2 900 3 300 3 300 3 300 3 300 3 300
¥ Payload 1 145 1 110 1 105 1 095 1 060 1 545 1 510 1 505 1 495 1 460
¥ Gross train weight (GTW)* 4 500 4 500 4 500 4 500 4 500 4 900 4 900 4 900 4 900 4 900
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1 600 1 600 1 600 1 600 1 600 1 600 1 600 1 600 1 600 1 600
Weights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h). 2 LITRE TURBO HDI
CHASSIS CAB
Model codes: 290C 290M 330C 330M 330L ¥ Kerb weight 1 600 1 610 1 600 1 610 1 625
¥ Gross vehicle weight (GVW) 2 900 2 900 3 300 3 300 3 300
¥ Payload 1 300 1 290 1 700 1 690 1 675
¥ Gross train weight (GTW)* 4 500 4 500 4 900 4 900 4 900
¥ Unbraked trailer 750 750 750 750 750
¥ Braked trailer (within GTW) 1 600 1 600 1 600 1 600 1 600
Recommended nose weight: 80 kg
17-11-2003

17-11-2003
TECHNICAL DATA157
Weights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h). 2 LITRE TURBO HDI
BARE CHASSIS COMBI MINIBUS
Model codes: 290C 330C 330M 330L 290C 330M 290C ¥ Kerb
weight 1 310 1 310 1 320 1 335 1 865 1 905 1 985
¥ Gross vehicle weight (GVW) 2 900 3 300 3 300 3 300 2 900 3 300 2 900
¥ Payload 1 590 1 990 1 980 1 965 1 035 1 395 915
¥ Gross train weight (GTW)* 4 500 4 900 4 900 4 900 4 500 4 900 4 500
¥ Unbraked trailer 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1 600 1 600 1 600 1 600 1 600 1 600 1 600
2 LITRE TURBO HDIPLATFROM CAB FLAT FLOOR CAB
Model codes: 290C 290M 330C 330M 330L 290C 290M 330C 330M 330L
¥ Kerb weight 1 780 1 815 1 780 1 815 1 855 1 555 1 570 1 555 1 570 1 590
¥ Gross vehicle weight (GVW) 2 900 2 900 3 300 3 300 3 300 2 900 2 900 3 300 3 300 3 300
¥ Payload 1 120 1 085 1 520 1 485 1 445 1 345 1 330 1 745 1 730 1 710
¥ Gross train weight (GTW)* 4 500 4 500 4 900 4 900 4 900 4 500 4 500 4 900 4 900 4 900
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 1 600 1 600 1 600 1 600 1 600 1 600 1 600 1 600 1 600 1 600
Recommended nose weight: 80 kg

TECHNICAL DATA
158
2.2 LITRE TURBO HDI
VAN
Model codes:
290C 290CS 290M 290MH 290MHS 330C 330CS 330M 330MH 330MHS
¥ Kerb weight 1 825 1 860 1 865 1 875 1 910 1 825 1 860 1 865 1 875 1 910
¥ Gross vehicle weight (GVW) 2 900 2 900 2 900 2 900 2 900 3 300 3 300 3 300 3 300 3 300
¥ Payload 1 075 1 040 1 035 1 025 990 1 475 1 440 1 435 1 425 1 390
¥ Gross train weight (GTW)* 4 900 4 900 4 900 4 900 4 900 5 300 5 300 5 300 5 300 5 300
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000
Weights and towing loads (in kg)
* The speed of a towing vehicle is limited to 60 mph (100 km/h).
2.2 LITRE TURBO HDI VAN
Model codes:
330LH 330LHS 350C 350CS 350M 350MH 350MHS 350LH 350LHS
¥ Kerb weight 1 945 1 995 1 895 1 930 1 915 1 925 1 960 1 995 2 045
¥ Gross vehicle weight (GVW) 3 300 3 300 3 500 3 500 3 500 3 500 3 500 3 500 3 500
¥ Payload 1 355 1 305 1 605 1 570 1 585 1 575 1 540 1 505 1 455
¥ Gross train weight (GTW)* 5 300 5 300 5 500 5 500 5 500 5 500 5 500 5 500 5 500
¥ Unbraked trailer 750 750 750 750 750 750 750 750 750
¥ Braked trailer (within GTW) 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000 2 000
Recommended nose weight: 80 kg
17-11-2003