battery Peugeot iOn 2011 Owner's Guide

8
!
i
Practical information
89
Do not charge the battery without firstdisconnecting the terminals. Do not disconnect the terminals whenthe "Ready" lamp is on, nor when thevehicle is being charged.
Before disconnecting
You must wait 2 minutes after switchingoff the ignition before disconnecting the battery.


Batteries contain harmful substancessuch as sulphuric acid and lead. Theymust be disposed of in line with legal requirements and never put out withhousehold waste. Ta k e used batteries to an authorisedcollection point.
)Disconnect the negative (-) terminal.)Lift the protective cover on the (+)terminal 2.)Slacken nut 3.)Disconnect the positive (+) terminal. )Remove the battery.)Charge the battery following the
instructions given by the manufacturer of
the battery charger. )Reconnect the battery starting with the (+) cable.

After reconnecting

After reconnecting the battery, switchon the ignition and wait 1 minute
before star ting, to allow initialisation of the electronic systems. However, if minor problems persist after doingthis, contact a PEUGEOT dealer or a qualified workshop.Remember to enter the radio code yourself, referring to the relevant section.

Ensure that the battery posts and cable terminals are clean. If they are coveredwith sulphates (whitish or greenish deposit), disconnect and clean them.

i
Practical information
108
Fuse N°RatingFunctions


1


-


Not used.


2


30 A
Int
ernal fuse.


3
40 A

Electric motor.
440 A

Radiator fan.


5
40 A

El
ectric windows.


6


30 A
Vacuum pump.


7


15 A
Main battery E
CU.


8


15 A
Third brake lamp.


9


15 A
Front fo
glamps.
10

15 A
Water pump.
Front compartment fuses
The fusebox is placed in the front compar tment
under the heating system reservoir. Only these
fuses can be replaced.

The replacement of fuses for other units (vacuum pump and battery accessories) requires the involvement of a PEUGEOT dealer or a qualifiedworkshop.

8
i !
!
!
Practical information
111





Accessories

A wide range of accessories and genuine par ts is available from the PEUGEOT dealer network.
These accessories and par ts have been tested and approved for reliability and safety.
They are all adapted to your vehicle and benefit from PEUGEOT's recommendation and warranty.
Conversion kits
You can obtain an "Enterprise" kit to conver t a trade vehicle to a private car and vice-versa.
"Comfort":
black armrest, reading lamp, insulated
modules, rear parking sensors, cigarette lighter,ashtray with base...


"Transport solutions":

boot carpet, boot liner, rear parcel shelf, boot dividers...


"Security and safety":

alarm, wheel security bolts, child seats,
breathalyzer, warning triangle, high visibility
vest, first aid kit, snow chains, non-slip covers...
Precautions for
washing
To avoid damaging the electrical components, the use of a high pressure jet wash is strictly prohibited:


- in the front compar tment (under the bonnet),

- under the body.

For washing the body, do not use a pressure greater than 80 bars.
Check - before washing the vehicle -that the charging flaps and the charging socket covers (normal and fast charge) are properly closed.


Do not wash the vehicle while the
battery is being recharged.

!
i
Checks
114











Bonnet Protects the components in the front compartment and provides access for checking levels, recharging the 12 V ancillaries battery, changing fuses, ...
)Push the exterior safety catch Bto the left and raise the bonnet.
)
Open the bonnet fully and on the right,unclip the stay Cfrom its holder.)
Fit the stay Cin one of the two notches to
hold the bonnet open.
)Open the front right door.)Pull the interior release lever A , located at
the bottom of the door aper ture.
Opening
Closing
)Take the stay out of the support notch.)Clip the stay in its housing. )Lower the bonnet and release it at the end of its travel. )Pull on the bonnet to check that it is fully latched.


Do not press down on the middle of the bonnet if it does not fully close, as there is a risk of deforming it. Open the bonnet fully and close it again.
The location of the interior release lever prevents opening of the bonnet while the front right door is closed.

9
!
Checks
115
Screenwash fluid reservoir. 2.Heater fluid reservoir.3.Brake fluid reservoir.4.
Ancillaries battery.
5. Fusebox.












Front compartment

To avoid damaging electricalcomponents, the use of a high pressure jet washer in the front compartment is strictly prohibited.

!
i
Checks
118
The coolant level should be between
the MIN "L" and MA X "F" marks.
Coolant level
Avoid prolonged contact of used fluids with the skin.
Most of these fluids are harmful tohealth and some are very corrosive.

Do not discard used fluids into sewers or onto the ground.
Ta k e u s e d fluids to a PEUGEOT dealer or a qualified workshop (France) or toan authorised waste disposal site.
Used products

Rear compartment


Changing the coolant

The coolant does not have to be changed.


Coolant specifi cation

The coolant must conform to the
manufacturer's recommendations.
As the coolin
g system is pressurised, wait at least one hour after switching off the motor and/
or the end of the charge cycle before carryingout any work.
To a v o i d a ny risk of scalding, unscrew the cap by two turns to allow the pressure to drop.
When the pressure has dropped, remove the cap and top up the level.
Ancillaries battery
electrolyte level
Remove the battery protective cover to check
this level
(see § "ancillaries battery").The electrolyte level should be between theMIN "LOWER LEVEL" and MA X "UPPER LEVEL".
If necessary, top up using distilled water byremoving the individual battery caps.

Check the electrolyte level at least onceper month.

Technical data
120
MODEL:MOTOR AND MAIN BATTERY
Model type code:1 N ZK Z Z
Electric motorY4F1
Technology Synchronous with neodymium permanent magnets
Max. power: EU standard
(kW)

49

Max. power speed
(rpm)

2 500 to 8 000

Max. torque: EU standard (Nm)
18 0

Max. torque speed (rpm)

0 to 2 500
Main batteryLithium-Ion
Ener
gy capacity (kWh)

16
Normal charge

Volt age (V)
220

Charging time (*)(**):


- 16 A

- 13 A

- 1
0 A
6 hours
7 hours
9 hours
Fast char
ge
Volt age (V) 330


Charging time (80 % charge) ** 30 minutes

*
Dependin
g on the power supply in the country.
**
Time measured for ambient temperatures between 20 and 25 °C. Range varies according to the exterior climatic conditions, the driver's style o
f driving, the use of electrical equipment, the frequency of normal or fast charges and ageing of the main battery.

10
!
Technical data
121
WEIGHTS (in kg)
Electric motorY4 F1
Main batteryLithium-Ion
Model type code:1 N ZK Z Z
Unladen weight

1 120

Kerb weight 1 195

Gross vehicle weight (GV W) 1 450

Gross train wei
ght (GTW)1 450

Maximum load on the roo
f (including the roof bars)43

Your vehicle cannot be fitted with a towbar. It cannot tow a trailer.

126
EMERGENCY OR ASSISTANCE CALL
In an emergency, press this button for more than2 seconds. Flashing of the green LED and a voice
message confi rm that the call has been made to the
PEUGEOT Emergency team * .
Pressin
g this button again immediately cancels the request. The green LED goes off.
A press
(at any time) of more than 8 seconds on this button, cancels the
request.

When the i
gnition is switched on, the green
LED comes on for 3 seconds indicating that
the system is operating correctly.

If the oran
ge LED fl ashes: there is asystem fault.
If the oran
ge LED is on continuously: thebackup battery must be replaced.
In either case, contact a PEU
GEOT. Pressin
g this button again immediately cancels the request.
The cancellation is confi rmed b
y a voice message.
Press this button
for more than 2 seconds to requestassistance if the vehicle breaks down.
A voice message confi rms that the call has been made *
.


OPERATION OF THE SYSTEM The green LED remains on (without fl ashing) when communication is established. It goes off at the end of communication.
This call is dealt with b
y the PEUGEOT Emergency team which receiveslocating information from the vehicle and can send a detailed alert to theappropriate emergency services. In countries in which the team is not
operational, or when the locating service has been expressly declined,
the call is dealt with directly by the emergency services (11 2) without the
vehicle location.

I
f an impact is detected by the airbag ECU, and independentlyof the deployment of any airbags, an emergency call is made
automatically.


*
These services are subject to conditions and availability.
Consult a PEUGEOT dealer.If
you purchased your vehicle outside the PEUGEOT dealer network,
we invite you to have a dealer check the confi guration of these servicesand, if desired, modifi ed to suit your wishes. In a multi-lingual country, confi guration is possible in the offi cial national language of your choice.
For technical reasons, particularl
y to improve the quality of PEUGEOT CONNECT services services to customers, the manufacturer reserves the
right to carry out updates to the vehicle's on-board telematic system.
I
f you benefi t from the PEUGEOT Electric offer, you have other services
available to you in your MyPeugeot personal space via the PEUGEOT
website in your country, accessible on www.peugeot.co.uk.

127
The system is coded in such a way that it will only
operate in your vehicle. If it is to be installed in another
vehicle, contact your PEUGEOT dealer for confi guration
of the system.

AUDIO SYSTEM/BLUETOOTH

01 First steps


For safety reasons, the driver must only carry out
operations which require prolonged attention while the
vehicle is stationary.
When the motor is switched off and to
prevent
discharging of the battery, the audio system may switch off after a few minutes.



CONTENTS

02 Radio

03 Audio

04 Using the telephone

05 Audio settings

06 Configuration

07 Screen menu map

Frequently asked questions p.
p.
p.
p.
p.
p.
p.
p. 128
129
132
138
144
145
146
147
After a battery disconnection, a code has to be enteredfor operation of the radio.

A maximum of fi ve attempts are possible. For the last
two attempts, a 15 minutes wait is imposed between each attempt.
R
efer to the end of this document to fi nd the label indicating this code: