fuel cap Peugeot Partner VU Dag 2004 Owner's Manual

4THE KEYS The keys allow you to switch on the ignition and operate the pas-senger air bag disarming switch,as well as to independently operatethe locks on the doors and thefuel filler cap. Central locking From the front doors, the keys allow you to lock and unlock thedoors and tailgate. If one of the doors or the tailgate is open, it is impossible to oper-ate the central locking. The remote control performs the same functions at a distance. The remote control key Locking Press button
Ato lock the vehicle.
This is confirmed by fixed lighting of the direction indicators forapproximately two seconds. Unlocking Press button Bto unlock the
vehicle. This is confirmed by rapid flash- ing of the direction indicators. Locating the vehicle
To locate your vehicle, previous- ly locked, in a car park:  press button A, the courtesy
lights come on and the direc- tion indicators flash for a fewseconds. STARTING
STOP position (S):
The ignition is off. Accessories position (A):
The
ignition is off but the accessories can be used. On position (M): The ignition is on. Starting position (D):
Operates the starter.
61
YOUR PARTNER AT A GLANCE
22-12-2003

14YOUR PARTNER AT A GLANCE
OPENING THE BONNET Inside the vehicle:Pull the con-
trol on the left-hand side, under the fascia panel. Outside the vehicle: Lift the control, raise thebonnet and secure thestrut to keep the bonnetopen.
FILLING WITH FUEL This operation must be carried out with
the engine switched off.
 Insert the key then turn it to the left.
 Remove the cap.
An indication shows which type of fuel to use.
When you fill your tank, do not continue after the third cut-off of the pump. This could cause a malfunction. The capacity of the tank is approximately 55 litres for petrol engines and 60 litres for Diesel engines. Note: the right-hand sliding side door cannot be opened while the fuel
tank cap is removed.
Low fuel level warning light From the time this light comes on, you have enough fuel left to cover approximately 30 miles (50 km) .
7069
22-12-2003

PEUGEOT SERVICING25
22-12-2003
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st service
A C Intermediate
DRAIN/REFILLÐ Engine oilÐ Bleed fuel filter (diesel)Ð Oil filterÐ Petrol filter (according to engine)REPLACEÐ Diesel filter or element (according to engine)Ð Air filter elementÐ Spark plugs (petrol)Ð Engine oil (check + top-up) Ð Manual gearbox oil (check + top-up) Ð Battery (check + top-up) if cap is removableLEVELÐ Screen wash (check + top-up)Ð Coolant (check + top-up)Ð Brake fluid (check + top-up)Ð Power steering fluid (check + top up according to specification)Ð Operation of lights and indicatorsÐ Condition of glass, headlamp and light lenses and mirrorsÐ HornÐ Windscreen washer jetsÐ Condition of wiper bladesÐ Condition and tension of the ancillary drive beltsÐ HandbrakeÐ Condition of hydraulic circuits (hoses and covers)CHECKÐ Condition of rubber boots and gaitersÐ Brake pads Ð Play in hubs, link rods, ball joints, flexible mountingsÐ Shock absorbersÐ Rear drum brake lining wearÐ Condition and pressure of tyres (including spare wheel)Ð Emission control check as per current legislation (petrol)Ð Smoke opacity (diesel)Ð Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions. : Arduous conditions. * According to destination.

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

YOUR PARTNER IN DETAIL61
THE KEYS The keys allow you to switch on the ignition and operate the passengerair bag disarming switch as well as toindependently operate the locks onthe doors and the fuel filler cap. Central locking From the front doors, the keys allow you to lock and unlock the doors andtailgate. If one of the doors or the tailgate is open, the central locking does notwork. The remote control performs the same functions at a distance.
Locating your vehicle
To locate your vehicle, if you have locked it, in a car park: press button A, the courtesy
lights come on and the direction indicators flash for a few seconds.
The remote control Locking Press button
Ato lock the vehicle.
This is confirmed by fixed lighting of the direction indicators for approxi-mately two seconds. Unlocking Press button B to unlock the vehicle.
This is confirmed by rapid flashing of the direction indicators. Note: if the vehicle is locked and
unlocking is activated inadvertently, unless the doors are opened within30 seconds, the vehicle will lock
automatically.
Changing the battery of the remote control The "battery flat" information is pro-
vided by an audible signal accompa-
nied by the message "Remote con-
trol battery flat" on the screen.
To change the battery, unclip thecasing using a coin at the ring
(CR 2016/3 volt battery). If the remote control does not work after the battery has been changed,re-programme the remote control. Programming the remote control  Switch off the ignition.
 Switch the ignition on again.
 Press button Aimmediately for a
few seconds.
 Switch off the ignition and remove the remote control key from the
ignition lock. The remote control isnow working again.
22-12-2003

22-12-2003
YOUR PARTNER IN DETAIL
64
FRONT DOORS AND SLIDING SIDE DOORS Front doors Side doors Opening the doors from outside Locking/Unlocking from the inside Front doors
To lock, lower button
A.
The closing control of one of the front doors permits complete locking ofthe vehicle.
To unlock and open, lift button Aand
pull the handle towards you. The driver's door opening control permits complete unlocking of thevehicle. Sliding side doors The side door opening/closing control only controls the door concerned.
To close, push the control Bforwards
and slide the door.
To open, pull the control B rearwards
and slide the door. Note: if the fuel tank cap is removed,
the right-hand side door cannot be opened.
Side doors Opening the doors from inside The driver's door opening control permits complete unlocking of thevehicle.
Front doors

YOUR PARTNER IN DETAIL
70
22-12-2003
FILLING WITH FUEL Low fuel level
When the minimum fuel level in the tank isreached, this warninglight comes on.
You have enough fuel remaining todrive for approximately 30 miles(50 km). The engine must be switched off when filling with fuel.  Insert the key then turn it to the left.
 Remove the cap.
An indication reminds you which type of fuel to use. When you fill your tank, do not con-
tinue after the third cut-off of the
pump. This could cause your vehicleto malfunction. The capacity of the tank is approximately 55 litres for petrolengines and 60 litres for Dieselengines. After filling the tank, lock the cap.
When the cap is removed, the right-hand sliding sidedoor cannot be opened.
The key cannot be removed fromthe lock until the cap has beenreplaced on the fuel tank.

TECHNICAL DATA105
PETROL
Model codes GBHFXB GBKFWB
GCKFWB
ENGINES 1.1 litre 1.4 litre
Cubic capacity (cm 3
) 1 124 1 360
Bore x stroke (mm) 72 x 69 75 x 77
EU standard maximum power (kW)44.1 55
Maximum power at engine speed (rpm) 5 500 5 500
EU standard maximum torque (Nm) 94 120
Maximum torque at engine speed (rpm) 2 700 2 800
Fuel Unleaded Unleaded Catalytic converter YesYes
Gearbox Manual Manual
(5 speed) (5 speed)
Oil capacity (in litres)Engine (with cartridge replacement) 3.2 (1) - 3.4 (2) 3 (1) - 3.25 (2)
Gearbox-Final drive 22
ENGINES AND GEARBOXES (1) Draining by gravity - (2) Draining by suction
22-12-2003

TECHNICAL DATA
106
DIESEL
Model codes GBWJYB/K GBRHYB
GCWJYB PLC GCRHYB
ENGINES 1.9 litre 2 litre Turbo HDI
Cubic capacity (cm 3
) 1 867 1 997
Bore x stroke (mm) 82.2 x 88 85 x 88
EU standard maximum power (kW)51 66
Maximum power at engine speed (rpm) 4 600 4 000
EU standard maximum torque (Nm) 125 205
Maximum torque at engine speed (rpm) 2 500 1 900
Fuel Diesel Diesel
Catalytic Converter YesYes
Gearbox Manual Manual
(5 speed) (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 4.8 4.5
Gearbox-Final drive 1.9 1.9
ENGINES AND GEARBOXES
22-12-2003