fuel PEUGEOT RCZ 2012 Owner's Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2012, Model line: RCZ, Model: PEUGEOT RCZ 2012Pages: 336, PDF Size: 14.1 MB
Page 148 of 336
146
FUEL TANK
Fuel tank capacity: approximately 55 litres.
LOW FUEL LEVEL
FILLING
When the fuel tank minimum level is reached this warning
lamp comes on on the instrument panel, accompanied by an
audible signal and an alert message. When it fi rst comes on
there remains approximately 5 litres
of fuel in the tank.
Until suffi cient fuel is added, this warning lamp appears every time
the ignition is switched on, accompanied by an audible signal and a
message. When driving, this audible signal and display of the alert
message are repeated with increasing frequency as the fuel level drops
towards "0"
.
Refuel as soon as possible to avoid running out of fuel.
If you run out of fuel (Diesel), refer also to the "Running out of fuel
(Diesel)" section.
A label affi xed to the inside of the fl ap reminds you of the type of fuel to
be used depending on your engine.
Additions of fuel must be of at least 5 litres, in order to be registered by
the fuel gauge. To fi ll the tank in complete safety:
)
the engine must be switched off,
)
press the rear part of the fl ap, then raise it to open it,
)
turn the cap to the left,
)
remove the cap and hook it onto the clip located on the inside of
the fl ap,
)
fi ll the tank, but do not continue after the 3rd cut-off of the
pump
; this could cause malfunctions. Opening the fi ller cap may create a noise a caused by an inrush
of air. This vacuum is entirely normal, resulting from the sealing of
the fuel system.
Page 149 of 336
7/
CHECKS
QUALITY OF THE FUEL USED FOR PETROL
ENGINES
The petrol engines are perfectly compatible with E10 or E24 type petrol
biofuels (containing 10 % or 24 % ethanol), conforming to European
standards EN 228 and EN 15376.
E85 type fuels (containing up to 85 % ethanol) are reserved exclusively
for vehicles marketed for the use of this type of fuel (BioFlex vehicles).
The quality of the ethanol must comply with European
standard EN 15293.
For Brazil only, special vehicles are marketed to run on fuels containing
up to 100 % ethanol (E100 type).
For Russia only, the use of RON 92 unleaded petrol is possible.
QUALITY OF THE FUEL USED FOR DIESEL
ENGINES
The Diesel engines are perfectly compatible with biofuels which
conform to current and future European standards (Diesel fuel which
complies with standard EN 590 mixed with a biofuel which complies
with standard EN 14214) available at the pumps (containing up to
7 % Fatty Acid Methyl Ester).
The B30 biofuel can be used in certain Diesel engines; however, this
use is subject to strict application of the special servicing conditions.
Contact a PEUGEOT dealer or a qualifi ed workshop.
The use of any other type of (bio)fuel (vegetable or animal oils, pure
or diluted, domestic fuel...) is strictly prohibited (risk of damage to the
engine and fuel system).
When you have fi lled the tank:
)
put the cap back in place,
)
turn it to the right,
)
close the fl ap.
Freezing conditions
In these conditions, the fi ller fl ap may be jammed.
Opening the boot gives access to the fl ap, allowing it to be
released by hand.
Page 152 of 336
150
DIESEL ENGINE
The various caps and covers allow access for checking the levels of the various fl uids, for replacing certain components and for priming the fuel system.
1.
Power steering reservoir.
2.
Screenwash and headlamp wash reservoir.
3.
Coolant reservoir.
4.
Brake fl uid reservoir.
5.
Battery / Fuses.
6.
Fusebox.
7.
Air fi lter.
8.
Engine oil dipstick.
9.
Engine oil fi ller cap.
10.
Priming pump.
11 .
Bleed screw.
Page 153 of 336
7/
CHECKS
2 LITRE HDI ENGINE
)
Fill the fuel tank with at least fi ve litres of Diesel.
)
Open the bonnet.
)
If necessary, unclip the style cover for access to the priming pump.
)
Slacken the bleed screw.
)
Squeeze and release the priming pump repeatedly until fuel
appears in the transparent pipe.
)
Tighten the bleed screw.
)
Operate the starter until the engine starts (if the engine fails to start
at the fi rst attempt, wait around 15 seconds before trying again).
)
If the engine fails to start after a few attempts, operate the priming
pump again, then the starter.
)
Put the style cover back in position and clip it in place, ensuring that
it has clipped correctly.
)
Close the bonnet.
RUNNING OUT OF FUEL (DIESEL)
If the engine does not start fi rst time, don't keep trying.
Operate the priming pump again, then the starter motor. On vehicle fi tted with HDi engines, the fuel system must be primed
if you run out of fuel; refer to the engine compartment view on the
"Diesel engine" page.
Page 186 of 336
184
ENGINE COMPARTMENT FUSES
The fusebox is placed in the engine compartment near the battery (left-
hand side).
Access to the fuses
)
Unclip the cover.
)
Change the fuse (see corresponding paragraph).
)
When you have fi nished, close the cover carefully to assure the
sealing of the fusebox.
Fuse table
Fuse N°
Rating
Functions
F1
20 A
Engine control unit supply, injection
pump and EGR electrovalves (Diesel),
injectors (Diesel).
F2
15 A
Horn.
F3
10 A
Front wash-wipe.
F4
20 A
Daytime running lamps.
F5
15 A
Air fl ow sensor, coolant pump, oil pump,
thermostat, blow-by heater (petrol),
by-pass and EGR electrovalves (Diesel),
diesel heater (Diesel).
F6
10 A
Steering wheel angle sensor, ABS/ESC
control unit, ESC sensor.
F7
10 A
Power steering control unit, automatic
gearbox, engine coolant level detector,
dual function brake switch.
F8
25 A
Starter motor control.
F9
10 A
Diagnostic socket, directional
headlamps, particle emission fi lter pump
(Diesel).
F10
30 A
Engine control unit actuators (petrol:
ignition coils, electrovalves, injectors,
fuel pump (Diesel: electrovalves,
heaters).
F11
40 A
Air conditioning blower.
Page 194 of 336
192
MATT PAINT
If you vehicle is fi nished with a clear matt lacquer, please observe the
following recommendations to avoid damaging the paintwork by the use
of an inappropriate cleaning procedures.
These recommendations are also valid for alloy road wheels fi nished
with clear matt lacquer.
Never clean the vehicle without water.
Never wash your vehicle in an automatic roller brush car wash.
Never polish the vehicle body, nor the alloy wheels. Doing this will
make the paintwork shiny.
Do not use paint cleaners, abrasive products or paint polishing or
preserving products (such as wax, for example) on the paintwork.
These products are only suitable for bright fi nishes. Application of
these products on vehicles with a matt fi nish will seriously damage
the paint surface of the vehicle, giving rise to irreversible shiny or
stained areas.
Never use a high pressure jet wash with a lance fi tted with a
brush, this may scratch the paintwork.
Never select a wash programme that fi nishes with a hot wax
cycle. From the range of cleaning and maintenance products in the
"TECHNATURE" range recommended and approved by PEUGEOT,
use only the insect remover and car shampoo, which are the only
products to be used on the bodywork.
The insect remover can also be used to remove minor marks (for
example: fi nger marks...).
Always have paint repairs done by a PEUGEOT dealer or a qualifi ed
workshop.
We recommend the use of a high pressure jet wash, or at least a
water hose with a high output.
We recommend that the vehicle be rinsed using de-ionised water.
Use only a microfi bre cloth to dry the vehicle. It must be clean and
used without heavy pressure.
Lightly wipe off any fuel stains present on the bodywork using a
soft cloth, then leave to dry.
Page 197 of 336
9/
TECHNICAL DATA
Engines
1.6 litre THP
150 hp
1.6 litre THP 156 hp
1.6 litre THP
163 hp
1.6 litre THP
200 hp
Gearboxes
Automatic
(6-speed)
Manual
(6-speed)
Automatic
(6-speed)
Automatic
(6-speed)
Manual
(6-speed)
Model codes:
4J...
5FE-J
5FV-8
5FV-A
5FM-J
5FU-8
Cubic capacity (cc)
1 598
1 598
1 598
1 598
Bore x stroke (mm)
77 x 85.8
77 x 85.8
77 x 85.8
77 x 85.8
Max power: EU standard (kW) *
110
115
120
147
Max power engine speed (rpm)
6 050
6 000
6 000
5 500
Max torque: EU standard (Nm)
240
240
240
275
Max torque engine speed (rpm)
1 400
1 400
1 400
1 700
Fuel
Unleaded
Unleaded
Unleaded
Unleaded
Catalytic converter
Ye s
Yes
Yes
Yes
Oil capacities (in litres)
Engine (with fi lter replacement)
4.25
4.25
4.25
4.25
4.25
PETROL ENGINES AND GEARBOXES
*
The maximum power quoted is the type approved value obtained on a test bed, under the conditions defi ned in European legislation
(directive 1999/99/CE).
Page 199 of 336
9/
TECHNICAL DATA
Engine
2.0 litre HDi 163 hp
Gearbox
Manual
(6-speed)
Model codes:
4J...
RHH-8
Cubic capacity (cc)
1 997
Bore x stroke (mm)
85 x 88
Max power: EU standard (kW) *
120
Max power engine speed (rpm)
3 750
Max torque: EU standard (Nm)
340
Max torque engine speed (rpm)
2 000
Fuel
Diesel
Catalytic converter
Yes
Particle emission fi lter
Yes
OIL CAPACITIES (in litres)
Engine (with fi lter replacement)
-
DIESEL ENGINE AND GEARBOX
*
The maximum power quoted is the type approved value obtained on a test bed, under the conditions defi ned in European legislation
(directive 1999/99/CE).
Page 202 of 336
200
IDENTIFICAT ION MARKINGS
Various visible markings for the identifi cation of your vehicle.
A.
Vehicle identifi cation number (VIN) under the bonnet.
This number is engraved on the bodywork near the damper
support.
For access to it, raise the plastic cover.
C.
Manufacturer's label.
The number is indicated on a self-destroying label affi xed to the
door aperture, below the door striker, on the right-hand side.
This label also indicates the unladen weight, the gross vehicle
weight (GVW) and the gross train weight (GVW).
For information concerning the possibilities for installing snow
chains, contact a PEUGEOT dealer or a qualifi ed workshop.
The tyre pressures must be checked when the tyres are cold, at
least once a month.
If the tyre pressures are too low, this increases fuel consumption.
B.
VIN on the windscreen lower crossmember.
This number is indicated on a self-adhesive label which is visible
through the windscreen.
D.
Tyre/paint label.
This label is affi xed to the door aperture, on the driver's side.
It bears the following information:
- the tyre infl ation pressures, laden and unladen,
- the wheel rim and tyre sizes,
- the brands of tyre recommended by the manufacturer,
- the infl ation pressure of the spare wheel,
- the paint colour code.
Page 323 of 336
ALPHABETICAL INDEX
ALPHABETICAL INDEX
ABS and EBFD systems.................. 105
Accessories ..................................... 193
Accessory socket, 12V ...................... 84
Access to rear seats .......................... 73
Active bonnet ................................... 108
Adjusting headlamps ......................... 96
Adjusting the steering wheel.............. 69
Airbags .............................................114
Airbags, front ............................ 115, 118
Airbags, lateral.......................... 116, 118
Air conditioning .................................. 20
Air conditioning, digital................. 75, 76
Air fi lter ............................................ 154
Air fl ow ............................................... 74
Air vents............................................. 74
Alarm ................................................. 56
Alert / warning log .............................. 46
Alloy wheels..................................... 192
Anti-lock braking system
(ABS) ............................................ 105
Anti-pinch........................................... 59
Anti-theft .......................................... 127
Arches, aluminium ........................... 191
Armrest, front ..................................... 85
Ashtray .............................................. 84
Assistance call ......................... 103, 202
Audible warning ............................... 103
Audio/video sockets......................... 232
Audio streaming (Bluetooth) .... 288, 315
Audio systems ................................. 205
Automatic illumination
of headlamps ............................ 91, 94Automatic operation of hazard
warning lamps ............................... 102
Automatic rain sensitive
windscreen wipers .................. 98, 100
Auxiliary
sockets ........... 86, 232, 289, 310, 312A/ A/
Battery ..................................... 154, 171
Battery, charging .............................. 172
Battery, remote control ................ 54, 55
Bluetooth
(hands-free) ........... 233-235, 272, 313
Bluetooth
(telephone) ............. 233-235, 272, 313
Bodywork ......................................... 191
Bonnet ............................................. 148
Boot ................................................... 64
Boot (opening) ................................... 52
Boot lamp .......................................... 89
Brake discs ...................................... 155
Brake lamps..................................... 176
Brake pads ...................................... 155
Braking assistance system .............. 105B/
Central locking ............................. 53, 62
Changing a bulb ....................... 173-179
Changing a fuse ....................... 180-186
Changing a wheel ..................... 163-172
Changing a wiper blade ........... 101, 169
Changing the remote
control battery ................................. 54
Changing the time ........... 38, 45, 47, 49
CHECK .............................................. 37
Checking levels ....................... 152, 153
Checking
the engine oil level .................. 33, 152
Checking tyre pressures
(using the kit) ................................ 162
Checks...................................... 149-155
Children ..................... 113, 115, 119-126
Child seats ............................... 121-126
Cleaning (advice)............................. 191
Clock.................................................. 38
Closing the boot........................... 53, 64
Closing the doors......................... 53, 61
Colour screen,
retractable ........................... 46, 48, 50
Connectors,
audio ............... 86, 232, 289, 310, 312
Coolant level .............................. 33, 153
Coolant temperature
indicator .......................................... 33
Courtesy mirror .................................. 83
Cruise control .................................. 139
Cup holder ......................................... 82
Customising stickers........................ 191C/
Capacity, fuel tank ........................... 146
CD MP3 ........................... 229, 285, 309C/