air suspension PONTIAC BONNEVILLE 1993 Owners Manual
[x] Cancel search | Manufacturer: PONTIAC, Model Year: 1993, Model line: BONNEVILLE, Model: PONTIAC BONNEVILLE 1993Pages: 322, PDF Size: 16.31 MB
Page 285 of 322
Maintenance Schedule
Section A: Scheduled Maintenance Services [cant.]
Explanation of Scheduled Maintenance Services
Below are explanations of the services listed in Schedule I
and Schedule II.
ITEM
NO. SERVICE
1
2
Engine Oil and Filter Change-Always use SG
Energy Conserving II oils of proper viscosity. The
“SG” designation may be shown alone or in
combination with others, such as “SG/CC,”
“SG/CD” or
“SF, SG, CC,” etc. To determine the
preferred viscosity for your vehicle’s engine (e.g.,
SAE
5W-30 or SAE 10W-30), see the Index under
Engine Oil.
Chassis Lubrication-Lubricate the transaxle shift
linkage, parking brake cable guides, underbody
contact points and linkage. Lubricate the front and
rear suspension and steering linkage. The
proper fluids and lubricants to use are listed in
Section D. Make sure whoever services your vehicle uses
these. All parts should be replaced and all necessary repairs
done before you or anyone else drives
the vehicle.
ITEM
NO. SERVICE
3
4
Throttle Body Mounting Bolt Torque-Check
the torque
of the mounting bolts and/or nuts.
Tire and Wheel Rotation and Inspection-For
proper wear and maximum tire life, rotate your
tires following the instructions in this manual. See
the
Index under fires, Inspection & Rotation.
Check the tires for uneven wear or damage. If you
see irregular or premature wear, check the wheel
alignment. Check for damaged wheels also.
*An Emission Control Service.
a The US. Environmental Protection Agency has determined that the failure to pe$orm this maintenance item will not nullifL the emission warranty or
limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance sewices be
pe$ormed at the indicated intervals and the maintenance be recorded in Section
E: Maintenance Record.
m.. 284
ProCarManuals.com
Page 291 of 322
Maintenance Schedule
Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at least twice a year (for instance\
, each spring and fall).
You should let your GM dealer’s service department
or other qualified service center do these jobs. Make sure any necessary
repairs are completed at once.
INSPECTION
OR SERVICE
Steering, Suspension
and Front-Wheel-Drive
Axle Boot and Seal
Inspection
Exhaust System Inspection
Throttle Linkage
Inspection
Brake System
Inspection
I
-
WHAT SHOULD BE DONE
Inspect the front and rear suspension and steering system for damaged, loose or missing pa\
rts,
signs of wear,
or lack of lubrication. Inspect the power steering lines and hoses for proper
hookup, binding, leaks, cracks, chafing, etc. Clean and then inspect the drive axle boot seals for
damage, tears or leakage. Replace seals
if necessary.
Inspect the complete exhaust system. Inspect the body near the exhaust system.
Look for broken,
damaged, missing or out-of-position parts as well as open seams, holes, loose connections, or
other conditions which could cause a heat build-up
in the floor pan or could let exhaust fumes
into the vehicle. See
the Index under Engine Exhaust.
Inspect the throttle linkage for interference or binding, and for damaged or missing parts.
Replace parts as needed.
Inspect the complete system. Inspect brake lines and hoses for proper hooku\
p, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also
inspect drum brake linings for wear and cracks. Inspect other brake parts, \
including drums,
wheel cylinders, calipers, parking brake, etc. Check parking brake adjustment.
You may need to
have your brakes inspected more often if your driving habits or conditions result
in frequent braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be
serviced. Also, if the brake system warning light
stays on or comes on, something may be wrong
with the brake system. See the
Index under Brake System Warning Light. If your anti-lock brake
system warning light stays
on or comes on, something may be wrong with the anti-lock brake
system. See the
Index under Anti-Lock Brake System Warning Light.
ProCarManuals.com
Page 308 of 322
1993 PONTIAC SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out the Service Publications Order Form
in this book and mailing it with your check, money order or credit card information to H8h, Incorporated (address listed below).
CURRENT PUBLICATIONS FOR 1993 PONTIAC BONNEVILLE
PRODUCT SERVICE PUBLICATIONS
Product Service Publications (PSP’s), are bulletins, letters \
and articles
published for trained dealer service personnel. See Service Publ\
ica-
tions listed previously in this section.
A cumulative index is published quarterly during the current model\
year. The indexes list all PSP’s published by Pontiac in the model year.
PSP Index
Year Form Number Price
1993 PSPI-93-P . .............. Free
1992 PSPI-92-P.
........................ Free
1991
PSPI-91-P .. ............................ Free
1990 PSPI-90-P.
............................. Free
NOTE: Form Numbers for individual Product Service Publications may
be found in the PSP Index. Prices are $4.00 for the first PSP and
$2.00
for each additional PSP on the same order.
PSP Bound Bulletin Book (Complete Year Bulletins)
Year Description Form Number Price
1991 All PSP’S .................... S-91-PSP-4 15.00
1990
All PSP’S .................... S-90-PSP-4 15.00
For subscription information call Helm, Incorporated. SERVICE MANUALS
Service Manuals
have the diagnosis, repair and overhaul information
on engines, transmission, axle, suspension, brakes, electrical, s\
teer-
ing, body, etc.
Model Form Number Price
1993 Pontiac Bonneville
............. S-9310-H $43.00
*Please specify special body or engine types on order form. Write
information in the Form Number column. For example: Turbo,
Convertible.
OWNER’S INFORMATION
Owner publications are written directly for Owners and intended \
to pro-
vide basic operational information about the vehicle. The Owner’\
s
Manual includes the Maintenance Schedule for all models.
1993 Pontiac Bonneville Owner’s Manual
In Portfolio:
lnClUd8S htffolio, Owner‘s Manualand Warranty Booklet.
1993 Pontiac Bonneville
SE In-Portfolio . . ,10202134 $15.00
1993 Pontiac Bonneville
SSEl In-Portfolio .lo215984 $15.00
Without Portfolio: lncludes Owner’s Manual.
1993 Pontiac Bonneville Without Portfolio .lo202135 $11.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past model P\
ontiac
vehicles.
To request an order form, please specify year and model
name
of vehicle.
Address all inquiries to: HELM, INCORPORATED
PO. Box 07130
Detroit,
MI 48207
Credit Card Orders ONLV: 1-800-782-4356
For information and inqulries call: (313) 883-1430
c
307 ’ ’
ProCarManuals.com