suspension PONTIAC FIREBIRD 1994 Owners Manual

Problems on the Road
When your vehicle is being towed, have
the ignition key off. The steering wheel
should be clamped in a straight-ahead
position, with a clamping device designed
for towing service. Do not use the
vehicle’s steering column lock for this.
The transmission should be in “Neutral”
and the parking brake released.
Don’t have your vehicle towed on the rear
wheels, unless you must. If the vehicle
must be towed on the rear wheels, don’t
go more than 35 mph (55 km/h) or farther
than
50 miles (80 km) or your
transmission will be damaged. If these
limits must be exceeded, then the rear
wheels have to be supported on a dolly. Front Towing Hook-Ups
Attach T-hook chains to slots in frame
rearward
of front wheels on both sides.
NOTICE:
Do not attach winch cables or “J”
hooks to suspension components
when using car carrier equipment.
Always use T-hooks inserted in the
T-hook slots.
1
. . .158
ProCarManuals.com

Problems on the Road
c
Rear Towing Hook-Ups
Attach T-hook chains in front of rear
wheels in bottom of frame
rail on both
sides.
NOTICE:
Do not attach winch cables or “J”
hooks to suspension components
when using car carrier equipment.
Always use T-hooks inserted in the
T-hook slgts.
b
NOTICE:
Do not tow with sling-type equip-
ment or rear bumper valance will be
damaged.
Use wheel lift or car carrier equip-
ment. Additional ramping may be
required for car carrier equipment.
Use safety chains and wheel straps. Attach a separate safety chain around
outboard end of the rear axle.
I NOTICE:
I
Take care not to damage the brake
pipes and cables.
c
1
. . .160
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Explanation of Scheduled
Maintenance Services
Following are explanations of the services
listed in Schedule I and Schedule
II.
The proper fluids and lubricants to use are
listed in Section
D. Make sure whoever
services your vehicle uses these. All parts
should be replaced and all necessary
repairs done before you or anyone else
drives the vehicle.
NOTE: To determine your engine’s
displacement and code, see
“Engine Identification” in the
Index.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change* -
Always use SH or SG Energy
Conserving
I1 oils of proper
viscosity. The “SH” or “SG”
designation may be shown alone
or in combination with others,
such as “SH/CD,”
“SH, SG,
CD,” “SG/CD,” etc. To deter-
mine the preferred viscosity for
your vehicle’s engine (e.g., SAE
ITEM
NO.
2
3
4
SERVICE
5W-30 or SAE 10W-30), see
“Engine Oil” in the Index.
Chassis Lubrication
- Lubricate
the suspension and steering
linkage. Lubricate the
transmission
shift linkage.
Tire and Wheel Rotation and
InsDection
- For proper wear
and maximum tire life, rotate
your tires following the
instructions in this manual. See
“Tires, Inspection and Rotation”
in the Index. Check the tires for
uneven wear or damage. If you
see irregular or premature wear,
check the wheel alignment.
Check for damaged wheels also.
Engine Accessorv Drive Belt!s)
InsDection
- Inspect the belt(s)
for cracks, fraying, wear and
proper tension. Replace as
needed. (Belts can have many small cracks in individual ribs
without affecting performance.)
ITEM
NO. SERVICE
5 Cooling: System Service* -
Drain, flush and refill the system
with new or approved recycled
coolant conforming to GM
Specification 1825M. Keep
coolant at the proper mixture as specified. See “Coolant”
in the
Index. This provides proper
freeze and boil protection, corrosion inhibitor level and
maintains proper engine operating temperature.
Inspect hoses and replace if they
are cracked, swollen or deterior-
ated. Tighten screw-type hose
clamps. Clean the outside of the
radiator and air conditioning
condenser. Wash the pressure cap and neck.
To help ensure proper operation,
we recommend a pressure test of
both the cooling system and the
pressure cap.
* An Emission Control Service.
. . .246
ProCarManuals.com

Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at least twi\
ce a year (for instance, each spring and fall).
You should let your
GM dealer’s service department or other qualified service center do these jobs. Make sure any necessary
repairs are completed at once.
INSPECTION
I OR SERVICE
Restraint Systems
~ ~~~~
Steering and
Suspension Inspection
Exhaust System
Inspection
Inspection
WHAT SHOULD BE DONE
Now and then, make sure all your belts, buckles, latch plates, retractors, anchorages and
reminder systems are working properly. Look for any loose parts or damage. If you see anything
that might keep a restraint system from doing its job, have it repaired.
Inspect the front and rear suspension and steering system for damaged, loose or missing parts,
signs of wear, or lack of lubrication. Inspect the power steering lines and hoses for proper
hookup, binding, leaks, cracks, chafing, etc.
Inspect the complete exhaust system. Inspect the body near the \
exhaust system. Look for broken,
damaged, missing
or out-of-position parts as well as open seams, holes, loose connections or , ’;;
other conditions which could cause a heat build-up in the floor pan or could let exhaust fumes :~
into the vehicle. See “Engine Exhaust’’ in the Index.
Inspect the throttle linkage for interference or binding, and for damaged or missing parts.
Replace parts as needed.
251 . . .
ProCarManuals.com

1994 PONTIAC SERVICE PUBLtCATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out the Service Publications Order Form
in this book and mailing it with your check, money order or credit card information to Helm, Incorporated (address listed below).
CURRENT PUBLICATIONS FOR 1994 PONTIAC FIREBIRD
PRODUCT SERVICE PUBLICATIONS SERVICE MANUALS
Product Service Publications(PSP’s), are bulletins, letters and articles Service Manuals have the diagnosis, repair and overhaul information
published for trained dealer service personnel. See Service Publica- on engines, transmission, axle, suspension, brakes, electrical, steer-
tions listed previously in this section.
ing, body, etc.
A cumulative index is published quarterly during the current model Model
year. The indexes list all PSP’s published by Pontiac in the model year.
1994 Pontiac Firebird .........
Form Number Price
S-9410-F
TBA*
PSP Index NOTE:
Please specify special body or engine types on order form.
Year Form Number Price Write information in the Form Number column. For example: Turbo,
1994 PSPI-94-P
................ Free Convertible.
1993 PSPI-93-P
..... Free ‘Price to be announced at a later date. Call 1-800-782-4356 for further info\
rmation.
1992 PSPI-92-P .......
1991 PSPI-91-P .......
... ...
............
............
. Free OWNER’S INFORMATION
. Free Owner publications are written directly for owners and intended to pro:
vide basic operational information about the vehicle. The Ownerk
PSP Bound Bulletin Book (Complete Year Bulletins) Manual includes the Maintenance Schedule for all models.
Year Description Form Number Price
1992 All PSP’S .................... S-92-PSP-4 15.00 1994 Pontiac Firebird Owner’s Manual I,
15.00 In Portfolio: Includes Portfolio, Owner’s Manualand Warranty Booklet
1991 All PSP’S .................... S-91-PSP-4
For subscription information call Helm, Incorporated. 1994 Pontiac Firebird ln-Portfolio .lo260930 $15.00
Without Portfolio: Includes Owner’s Manual.
1994 Pontiac Firebird Without Portfolio
..... .lo260939 $10.00
,; .
..........
CURRENT 81 PAST MODEL ORDER FORMS
Service Publications are available for current and past model Pontiac Detroit, MI 48207
vehicles.
To request an order form, please specify year and model
name of vehicle.
Address all inquiries to: HELM, INCORPORATED
PO. Box 07130
For information and inquiries call: 1-800-782-4356
267. ..
ProCarManuals.com