engine PONTIAC FIREBIRD 1995 Owners Manual

Fuses
1. ABS BAT Electronic Brake Control Module
2. FOG LTS: Fog Lamps
3. R HDLP DR: Headlamp Doors Module
4. L HDLP DR: Headlamp Doors Module
5. ABS IGN: Anti-Lock Brake System
6. FANS/ACTR: Coolant Fan Relays; EVAP Canister
Purge So1enoid;Exhaust Gas Recirculation; Reverse
Lockout So1enoid;Skip
Shift Solenoid; Heated
Oxygen Sensors
(V8 Engine)
7. AIR PUMP: Air Pump Relay
8. PCM: Powertrain Control Module
9. INJECTOR: Fuel Injectors
10. INJECTOR: Fuel Injectors
11. IGNITION: VIN Engine Code S: Camshaft Position
Sensor;Crankshaft Position Sensor; Ignition Control
Modu1e;Automatic Transmission; Ignition Coil (V-8 Engine); Ignition Coil Module (V-8 Engine)
12. A/C-CRUISE: Air Conditioning Compressor Relay;
Cruise Control Switches and Module
ProCarManuals.com

Capacities and Specifications
Engine
Type
VIN Engine Code S and K .............. 7 16 -
VIN Engine Code P .................... V8
Fuel Delivery .................. Fuel Injection
Valve Arrangement .................. In-Head
VIN Engine Code S .......... 207 CID (3.4L)
VIN Engine Code K ......... 231 CID (3.8L)
VIN Engine Cade P .......... 350 CID (5.7L)
Piston Displacement
Compression Ratio
VIN Engine Code S and K ............ 9.0: 1
VIN Engine Code P ................. 10.5: 1
VIN Engine Code P ......... 1-8-4-3-6-5-7-2
Firing Order
VIN Engine Code S and K ...... 1-2-3-4-5-6
Wheel Nuts
Wheel Nut Torque ......... 100 lb. ft. (140 N*m)
6-72
ProCarManuals.com

Capacities (Approximate)
The following approximate capacities are given in U.S.
and metric conversions.
Air Conditioning? See the refrigerant information label
under the hood.
Automatic Transmission
Drain and Refill .................. 10 pt. (4.7 L)*
VIN Engine Code S and K ....... 17.6 pt. (8.3 L)*
VIN Engine Code P ............ 21.6 pt. (10.2 L)*
VIN
Engine Code S
Overhaul
Cooling System
With Manual Transmission . . , . . 12.5 qt. (11.8 L)
With Automatic Transmission ... 12.3 qt. (11.6 L)
VIN Engine Code K
With Manual Transmission ..... 12.5 qt. (1 1.8 L)
With Automatic Transmission ... 12.3 qt. (11.6 L)
With Manual Transmission ..... 15.3 qt. (14.5 L)
With Automatic Transmission ... 15.1 qt. (14.3 L)
VIN Engine Code P
Crankcase
Without Filter Change ........... 4.0 qt. 1 (3.8 L)**
With Filter Change ............. 5.0 qt. (4.7 L)**
Fuel Tank ...................... 15,5 gal. (58.7 L)
Manual Transmission
Five-Speed
.................... 5.9 pt. (2.8 L)*
Six-Speed ..................... 8.0 pt. (3.8 L)*
Rear Axle Lubricant ................. 3.5 pt. (1.7L)
? Not all air conditioning refrigerants are the same. If the
air conditioning system in your vehicle needs refrigerant,
be sure the proper refrigerant is used.
If you’re not sure,
ask your Pontiac dealer.
* Recheck fluid level after filling. See “Automatic
Transmission Fluid” or “Manual Transmission Fluid”
in the Index.
** Recheck the oil level after filling. See “Engine Oil” in
the Index.
6-73
ProCarManuals.com

Vehicle Dimensions
Wheelbase . . . . . . . . . . . . . . . . 101.1 in. (2 566 mm)
Front Tread . . . . . . . . . . . . . . . . . . 60.7 in. (1542 mm)
Rear Tread . . . . . . . . . . . . . . . , . . 60.7 in. (1540 mm)
Length
Firebird / Formula . . . . . . . . . . . 195.6 in. (4 968 mm)
Trans Am . . . . . . . . . . . . . . . . . . . 197 in. (5005 mm)
Width . . . . . . . . . . . . . . . . . . . . . . 74.5 in. (1893 mm)
Height
Firebird / Formula . , . . . . . . . . . . . 52 in. (1321 mm)
Trans Am. . . . . . . . . . . . . . . . . . . . 51.7 in. (1312 mm)
Height Convertible
Formula . . . . . . . . . . . . . . . . . . . . 52.7 in. (1340 mm)
Trans Am . . . . . . . . . . . . . . . . . . . 52.4 in. (1331 111171)
Replacement Parts
Air Cleaner Filter . , . , . . . . . . , . . . . . . . . . . . . . . A1163C
Battery
. . . . . . . . . . . . . . . . . . . . . , . . . . . . . . . . . .75-60
Engine Oil Filter
VIN Engine Code S and K . . . . . . . . . . . . . . . . . . PF47
VINEngineCodeP
........................ PF25
Fuel Filter
. . . . . . . . , , . . . . . . . . . . . . . . . . . . . . . . GF578
PCV valve
VIN Engine Code
S . . . . . . . . . . . . . . . . . . , , CV789C
VIN Engine Code K . . . . . . . . . . , . . . . . . . . CV892C
VIN Engine Code: P
. . . . . . . . . . . . . . . . . . . . CV895C
Radiator Cap
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RC24
Spark Plug
VIN Engine Code
S . . . . . . . . . sR43TSK (0.045' Gap)
VIN Engihe Code K , . . . . . . . . -41-601 (0.060' Gap)
VIN Engine Code P . . . . . . , . sR45LTSP (0.050' Gap)
Thermostat Temperature Specification
. . . . 18OoF(82"C)
6-74 d. .. '
ProCarManuals.com

Maintenance Schedule
IMPORTANT:
KEEP ENGINE OIL
AT THE PROPER
LEVEL AND CHANGE AS
RECOMMENDED
This section covers the maintenance required for your Pontiac. Your vehicle needs these services to retain its
safety, dependability and emission control performance.
11 motec
I
Have you purchased the GM Protection Plan? The Plan
supplements your new vehicle warranties. See your
Pontiac dealer for details.
Introduction
Your Vehicle and the Environment
Proper vehicle maintenance not only helps to keep your
vehicle in good working condition, but also helps the
environment. All recommended maintenance procedures
are important. Improper vehicle maintenance or the
removal of important components can significantly
affect the quality of the air we breathe. Improper fluid
levels or even the wrong tire inflation can increase the
level of emissions from your vehicle.
To help protect our
environment, and to help keep your vehicle in good
condition, please maintain your vehicle properly.
7-1
ProCarManuals.com

Maintenance Schedule
Schedule I Definition
Follow Maintenance Schedule I if any one of these is
true for your vehicle:
0 Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
Most trips include extensive idling (such as frequent
driving in stop-and-go traffic).
Most trips are through dusty areas.
0 You frequently tow a trailer or use a carrier on top of
Schedule I should also be followed if the vehicle is used
for delivery service, police, taxi, or other commercial
application.
your car.
Schedule I Intervals
Every 3,000 Miles (5 000 km) or 3 Months
Engine Oil and Filter Change
Every 6,000 Miles (10 000 km) or 6 months
Chassis Lubrication
At 6,000 Miles (10 000 km) - Then Every
12,000 Miles
(25 000 km)
Every 7,500 Miles (12 500 km)
At 7,500 Miles (12 500 km)
Every 15,000 Miles (25
000 km)
Tire Rotation
Rear Axle Fluid Change (Vehicles Towing Trailers)
Rear Axle Fluid Change (Limited Slip Differential)
Air Cleaner Filter Inspection, if driving in dusty conditions
Automatic Transmission Service (severe conditions)
Every 30,000 Miles (50 000 km)
Air Cleaner Filter Replacement
Spark Plug Replacement (Except 5.7L Code
P engine)
Spark Plug Wire Inspection
Fuel Tank, Cap and Lines Inspection
Engine Accessory Drive Belt Inspection (or every
Cooling System Service (or every 24 months)
Spark Plug Replacement
(5.7L Code P engine only)
Automatic Transmission Service (normal conditions)
24 months)
Every 100,000 Miles (166 000 km)
7-4
ProCarManuals.com

Maintenance Schedule
I Schedule I1 Definition
Follow Schedule I1 only if none of the conditions from
Schedule I is true.
1 Schedule I1 Intervals I
Every 7,500 Miles (12 500 km)
Engine Oil and Filter Change (or every 12 months)
Chassis Lubrication (or every
12 months)
Rear Axle Fluid Change (Limited-Slip Differential)
At 7,500 Miles (12 500 km)
At 7,500 Miles (12 500 km) - Then Every
15,000 Miles (25 000 km)
Tire Rotation
Automatic Transmission Service (severe conditions)
Engine Accessory Drive Belt Inspection
(or every
Cooling System Service (or every
24 months)
Spark Plug Replacement (Except 5.7L Code P engine)
Spark Plug Wire Inspection
Air Cleaner Filter Replacement
Fuel
Tank, Cap and Lines Inspection
Every 100,000 Miles (166 000 km)
Spark Plug Replacement (5.7L Code P engine only)
Automatic Transmission Service (normal conditions)
@very 30,000 Miles (50 000 km)
24 months)
ProCarManuals.com

I Maintenance Schedule I 1
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals.
Footnotes
3- The U.S. Environmental Protection Agency or the
California
Air Resources Board has determined that the
failure to perfom this maintenance item will not nullify
the emission warranty or' limit recall liability prior to the
completion of vehicle useful life. We, however, urge that
all recommepded maintenance services be performed at
the indicated intervals
and the maintenance be recorded.
3,000 Miles (5 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
DATE ACTUAL MILEAGE SERVICED BY:
ProCarManuals.com

I Maintenance Schedule I I
6,000 Miles (10 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage. Lubricate the
transmission shift linkage (or every
6 months, whichever occurs first).
Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
DATE ACTUAL MILEAGE ISERVICED BY:
7,500 Miles (12 500 km)
Change the reat axle gear lubricant if
vehicle is used
fi, pull a trailer or has
limited-slip differential.
..
DATE SERVICED BY: ACTUAL MILEAGE
7-7
ProCarManuals.com

I I Maintenance Schedule I I
I I I ~
9,000 Miles (15 000 km)
0 Change
engine oil and filter (or every
3 months, whicliever occurs first).
An Emission Control Service.
12,000 Miles (20 000 km)
[I] Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Sewice.
0 Lubricate the steering linkage. Lubricate the
transmission shift linkage (or every
6 months, whichever occurs first).
DATE DATE ACTUAL MILEAGE SERVICED BY:
7-8
ACTUAL MILEAGE SERVICED BY:
I ProCarManuals.com