maintenance PONTIAC FIREBIRD 1996 Service Manual

I Sh'ort Trip/City Maintenance Schedu
96,000 Miles (MQ 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
6 months, whichever occurs first).
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
_. .c. ..
I I
7
ACTUAL MILEAGE
7-:
1
SERVICED BY:
99,000 Miles (165 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
I DATE I ACTUALMILEAGE ISERVICED BXI
ProCarManuals.com

1 Short TripKity Maintenance Schedule I
100,000 Miles (166 000 km)
Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
El Inspect spark plug wires.
An Emission Control Service.
Replace spark plugs.
An Emission Control Service. .
0 If you haven’t used your vehicle under
severe service conditions listed previously
and, therefore, haven’t changed your
automatic transmission fluid, change
both
the fluid and filter.
DATE ACTUAL MILEAGE SERVICED BY:
ProCarManuals.com

Long Tripmighway Maintenance Schedule I
The services snown in this schedule up to 100,000 nqles
(166 000 km) should be performed after 100,000 miles
( 166 000 km) at the same intervals.
Footnotes
The US. Environmental Protection Agency or the
California Air Resources
Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or
limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services
be
performed at the indicated intervals and the maintenance
be recorded.
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Change the rear axle gear lubricant if the
vehicle has limited-slip differential.
I7 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for freedom
of movement: Refer
to the appropriate
GM service mmud for proper caliper
service procedures.
An Emission Control Service.
7-28
ProCarManuals.com

Long Trip/Highway Maintenance Schedule
15,000 Miles (25 000 km)
Cl Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 "F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (1 66 000 km).
Manual transmission fluid doesn't require change.
I DATE I ACTUALMILEAGE
3
SERVICED BY:
ProCarManuals.com

1 Long Trip/Highwag Maintenance Schedule 1
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (1 66 000 km).
Manual transmission fluid doesd t.require change.
0 Replace air cleaner filter. -8 .. z
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. ?
An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
’ 0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
During
tire rotation, check brake calipers for freedom
of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
7-31
ProCarManuals.com

Long Trip/Highway Maintenance Schedule
d~~*5.45,000 Miles (75 000 km)
0 Change engine oil and filter (or every
12 months, whichever
occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs
first).
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90°F
(32°C) or higher.
An Emission Control Service.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (1 66 000 km).
Manual transmission fluid doesn't require change.
II I 1
1 DATE i ACTUALMILEAGE A SERVICED B/I
ProCarManuals.com

Long Trip/Highway Maintenance Schedule
60,000 Miles (100 000 km) (Continued)
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn’t require change.
0 Inspect engine accessory drive belt.
0 Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines for damage
or
leaks. Inspect fuel cap gasket for any
damage. Replace
parts as needed.
An Emission Control Service. ?
I 67,500 Miles (112 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information,. During
tire rotation, check brake calipers for fieedom
of movement. Refer
to the appropriate
GM service manual for proper caliper
An Emission Control Service.
I service procedures.
DATE SERVICED BY: ACTUAL MILEAGE DATE SERVICED BY: ACTUAL MILEAGE
-
7-34
ProCarManuals.com

Long Trip/Hip;hway Maintenance Schedule 1
' 75,000 Miles (125 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90°F
(32°C) or higher. .- .. . i :.. P
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (1 66 000 km).
Manual transmission fluid doesn't require change.
I DATE I ACTUAL MILEAGE ISERVICED BYI
7-35
ProCarManuals.com

Long Trip/Highwav Maintenance Schedule
s2,500 Miles (137 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern
and additional information. During
tire rotation, check brake calipers for freedom
of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
RATE SERVICED BE ACTUAL MILEAGE
i
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Change automatic transmission fluid and
filter
if the vehcle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 * F
(32 O C) or higher.
An Emission Control Service.
- In hilly or mountainous terrain.
- When doing fkquent trailer towing.
7-36 I
ProCarManuals.com

I Long Trip/Highway Maintenance Schedule
- Uses such as found in taxi, police or
If you do not use your vehicle under any of these
conditions, change the fluid and filter at
100,000
miles (1 66 000 km).
Manual transmission fluid doesn’t require change.
delivery service.
Replace air cleaner filter.
17 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Em,ission Control Service.
An Emission Control Service.
97,500 Miles (162 500 km)
IJ Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
During
tire rotation, check brake calipers for freedom of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
DATE SERVICED BY: ACTUAL MILEAGE
DATE
SERVICED BY: ACTUAL MILEAGE
7-37
ProCarManuals.com