brake PONTIAC FIREBIRD 1996 Manual PDF

Long Tripmighway Maintenance Schedule I
The services snown in this schedule up to 100,000 nqles
(166 000 km) should be performed after 100,000 miles
( 166 000 km) at the same intervals.
Footnotes
The US. Environmental Protection Agency or the
California Air Resources
Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or
limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services
be
performed at the indicated intervals and the maintenance
be recorded.
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Change the rear axle gear lubricant if the
vehicle has limited-slip differential.
I7 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for freedom
of movement: Refer
to the appropriate
GM service mmud for proper caliper
service procedures.
An Emission Control Service.
7-28
ProCarManuals.com

22,500 Miles (37 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern
and additional information. During
tire rotation, check brake calipers for freedom
of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
DATE SERVICED BY: ACTUAL MILEAGE
30,000 Miles (50 1000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one
or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32 O C) or higher. F
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
ProCarManuals.com

1 Long Trip/Highwag Maintenance Schedule 1
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (1 66 000 km).
Manual transmission fluid doesd t.require change.
0 Replace air cleaner filter. -8 .. z
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. ?
An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
’ 0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
During
tire rotation, check brake calipers for freedom
of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE
7-31
ProCarManuals.com

52,500 Miles (87 500 krrt)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
I7 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for fieedom
of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
An Emission Control Sewice.
I DATE I ACTUAL MILEAGE ISERVICED BY I
60,000 Miles (100 000 km)
0 Change engine oil and filter (or every
12 months,, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32 O C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or
delivery service.
(Coniinued)
7-33
ProCarManuals.com

Long Trip/Highway Maintenance Schedule
60,000 Miles (100 000 km) (Continued)
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn’t require change.
0 Inspect engine accessory drive belt.
0 Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines for damage
or
leaks. Inspect fuel cap gasket for any
damage. Replace
parts as needed.
An Emission Control Service. ?
I 67,500 Miles (112 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information,. During
tire rotation, check brake calipers for fieedom
of movement. Refer
to the appropriate
GM service manual for proper caliper
An Emission Control Service.
I service procedures.
DATE SERVICED BY: ACTUAL MILEAGE DATE SERVICED BY: ACTUAL MILEAGE
-
7-34
ProCarManuals.com

Long Trip/Highwav Maintenance Schedule
s2,500 Miles (137 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern
and additional information. During
tire rotation, check brake calipers for freedom
of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
RATE SERVICED BE ACTUAL MILEAGE
i
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Change automatic transmission fluid and
filter
if the vehcle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 * F
(32 O C) or higher.
An Emission Control Service.
- In hilly or mountainous terrain.
- When doing fkquent trailer towing.
7-36 I
ProCarManuals.com

I Long Trip/Highway Maintenance Schedule
- Uses such as found in taxi, police or
If you do not use your vehicle under any of these
conditions, change the fluid and filter at
100,000
miles (1 66 000 km).
Manual transmission fluid doesn’t require change.
delivery service.
Replace air cleaner filter.
17 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Em,ission Control Service.
An Emission Control Service.
97,500 Miles (162 500 km)
IJ Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the steering linkage (or every
12 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information.
During
tire rotation, check brake calipers for freedom of movement. Refer to the appropriate
GM service manual for proper caliper
service procedures.
DATE SERVICED BY: ACTUAL MILEAGE
DATE
SERVICED BY: ACTUAL MILEAGE
7-37
ProCarManuals.com

Starter Switch Check When
you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
2. Firmly apply both the parking brake (see “Parking
Brake’’ in
the Index if necessary) and the regular brake.
NOTE: Do not use the accelerator pedal, and be
ready to turn
off the engine immediately if it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only in
PARK
(P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
around
the vehicle.
On manual transmission vehicles, put the shift lever
in NEUTRAL
(N), push the clutch down halfway
and
try to start the engine. The starter should work
only when
the clutch is pushed down all the way to
the floor. If the starter works when the clutch isn’t
pushed all the way down, your vehicle needs service.
Brake-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
When you are doing this check, the vehicle could move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
arouqd the vehicle. It should be parked on
a
level surface.
2. Firmly apply the parking brake (see “Parking Brake”
in the Index
if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the key to the RUN
position,
but don’t start the engine. Without applying
the regular brake,
try to move the shift lever out of
PARK (P) with normal effort. If the shift lever
moves out
of PARK (P). vour vehicle’s BTSI
needs service.
ProCarManuals.com

Steering Column Lock Check
While parked, and with the parking brake set, try to turn
the key to LOCK 11 each shift lever position.
With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
With a manual transmission, the key should
turn
to LOCK only when the shift lever is in
REVERSE (R).
On vehicles with a key release button, try to turn the key
to
LOCK without pressing the button. The key should
turn to LOCK only when you press the key button.
On all vehicles, the key should come out only in
LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
A CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in case
it begins to roll.
Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your
foot on the regular brake, set the
parking brake.
To check the parking brake: With the engine running
and transmission
in NEUTRAL (N), slowly remove
foot pressure from the regular brake pedal.
Do this
until the vehicle
is held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to
PARK (P). Then
release all brakes.
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
I -4L
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a Pontiac Service Manual. See “Service and
Owner Publications’’ in the Index.
Steering and Suspension Inspection
inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect
the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
0~t~€-pii60n parts as well as open seams, holes, loose
connections or other conditions which could cause a heat
build-up in
the floor pan or could let exhaust fumes into
the vehicle. See “Engine Exhaust” in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding, and
for damage or missing parts. Replace parts as needed.
Replace any cables that have high effort
or excessive wear.
Do not lubricate accelerator and cruise control cables.
Rear Axle Service
Check the gear lubricabt level in the rear axle and add if I
needed. See “Rear Axle” in the Index. A fluid loss may
indicate a problem. Check
the axle and repair it if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition.
Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc. The
parking brake is self-adjusting and no manual
adjustment
is required. You may need to have your
‘brakes inspected more often
if your driving habits or
conditions result in frequent braking.
7-43
ProCarManuals.com