engine PONTIAC FIREBIRD 1997 Owners Manual

5.7L Engine
How To Check Power Steering Fluid
When the engine compartment is cool, wipe the cap and
the top
of the reservoir clean, then unscrew the cap and
wipe the dipstick with a clean rag. Replace the cap and
completely tighten it. Then remove the cap again and
look at the fluid level on the dipstick.
The level should be at the FULL COLD mark. If
necessary, add only enough fluid to bring the level up
to the mark.
When the engine compartment is hot, the level
When the engine compartment is cool, the level
should
be at the
H or HOT mark.
should
be at C or FULL COLD m’ark.
What to Use
Refer to the Maintenance Schedule to determine what
kind
of fluid to use. See “Recommended Fluids and
Lubricants”
in the Index. Always use the proper fluid.
Failure to
use the proper fluid can cause leaks and
damage hoses and seals,
6-34

Brakes
Brake Fluid
of the brake system. If it is, you should have your brake
system fixed, since
a leak means that sooner or later your
brakes won’t work well, or won’t work at all.
So, it isn’t a good idea to “top off’ your brake fluid.
Adding brake fluid won’t correct a leak. If you add fluid
when your linings are worn, then you’ll have too
much
fluid when you get new brake linings. You should add
(or remove) brake fluid, as necessary, only when work is
done on the brake hydrwlic system.
Your brake master cylinder reservoir is here.
It is filled
with
DOT-3 brake fluid.
There are only two reasons why
the brake fluid level in the
reservoir might go down. The first is that the brake fluid
goes down to
an acceptable level during normal brake
lining wear, When new linings are put in, the fluid level
goes back up. The other reason is that fluid is leaking out
If you have too much brake fluid, it can spill
on the engine. The fluid will burn if the engine
is hot enough. You ‘or others could be burned,
and your vehicle could be damaged. Add brake
fluid only
when work is done on the brake
hydraulic system.
Refer to the Maintenance Schedule to determine when to
check your brake fluid.
See “Periodic Maintenance
Inspections” in the
Index.
6-36

NOTICE:
Using the wrong fluid can badly damage
brake system parts. For example, just a few
drops
of mineral-based oil, such as engine
oil, in your brake system can damage brake
system parts
so badly that they’ll have to be
replaced.
Don’t let someone put in the
wrong
kind of fluid.
0 If you spill brake fluid on your vehicle’s
painted surfaces, the paint finish can
be
damaged. Be careful not to spill brake
fluid
on your vehicle. If you do, wash it
off immediately. See “Appearance Care’’
in the Index.
Brake Wear
Unless you have the four-wheel disc brake option, your
Pontiac has front disc brakes and rear
drum brakes.
Disc brake pads have built-in wear indicators that
make a high-pitched warning sound
when the brake
pads are worn and new pads are needed.
The sound
may come
and go or be heard all the time your vehicle
is moving (except when you are pushing
on the brake
pedal firmly).
I
The brake wear warning sound means that soon
your brakes won’t work well. That could lead to
an accident. When
you hear the brake wear
warning sound, have
your vehicle serviced.
6-38

Vehicle Identification Number (VIN)
I
ENGINE/1997 T ASSEMBLY
CODE MODEL YEAR PLANT
This is the legal identifier for your Pontiac. It appears on
a plate in the front corner
of the instrument panel, on the
driver’s side.
You can see it if you look through the
windshield
from outside your vehicle. The VIN also
appears
on the Vehicle Certification and Service Parts
labels and the certificates
of title and registration.
Engine Identification
The 8th character in your VIN is the engine code. This
code will help you identify your engine, specifications
and replacement
parts.
Service Parts Identification Label
You’ll find this label located on the driver’s door side.
It’s very helpful if you ever need
to order parts. On this
label is:
your VIN,
the model designation,
paint information and
a list of all producti’on options and special
Be sure that this label
is not removed from the vehicle.
equipment.
Electrical System
Add-on Electrical Equipment
NOTICE:
Don’t add anything electrical to your Pontiac
unless you check with your dealer first. Some
electrical equipment can damage your vehicle and
the damage wouldn’t be covered by your warranty.
Some add-on electrical equipment can keep other
components from working as they should.
Your
vehicle has an air bag system. Before attempting to
add anything electrical to your Pontiac, see “Servicing
Your Air Bag-Equipped Pontiac” in the Index.
6-68

Main Fuse Block
The other is in the engine compartment. Open the cover
on either of the boxes to expose the €uses.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse.
Be sure you
replace a bad fuse with a new one of the correct size.
If
you ever have a problem on the road and don’t have a
spare €use, you can “borrow”
one. Just pick some
feature
of your car that you can get along without -- like
the radio or cigarette lighter -- and use its fuse, if it is
the size you need. Replace it as soon as you
can.
FUSE USAGE CHART
In 211 3~ 4~3
511 6~ 7n en
9m 100 1111 12)l
STOP/#AZARD TURN 6-U PCM BATT RADIO ACCY
TAIL LTS
HVAC PWR ACCY COURTESY
GAGES AIR BAG ClGARiACCY DEFOG/SEATS
Q IGN 13n 14)) PGM IGN WlPERiWASH BATT WINDOWS
160 I7 170 IP DIMMER ACCY RADIO
SEE OWNER’S MANUAL FOR MORE INFORMATION PRINTED IN U.S.A 10281550
Fuse Usage
STOP/HAZARB Hazard,Flasher, Brake
Switch Assembly
PCM BATT
RADIO ACCY
TURN B-U Traction ControlJ2nd Gear Start
Switch, Back-up Lamp Switch,
Turn Flasher, Daytime Running
Lamps (DRL) Module
Powertrain Control Module
(PCM), Fuel Pump Relay
Delco Audyssey
Radio Amplifier,
Power Antenna, Remote CD
Player (trunk)
6-70

Relay
B
C
D
E
F
G
H
J
Usage
Air Conditioning Compressor Anti-Lock Brake SystedTraction Control
System
(TCS)
Cooling Fan 1
AIR Pump
Cooling Fan 2
Not Used
Fog
Lamps
Cooling Fan 3
Replacement Bulbs
Back-up . . . . . . . . . . . . . . . . . . .
Center High-Mounted Stoplamp . .
Front Parking and Turn Signal . .
Headlamp . . . . . . . . . . . . . . . .
Sidemarker . .
Tail Only . . . . .
Tail/Stop/Turn . . .
. . . . . . . . 1156
e.* . . 921
. . . . . . . . . 3157K
. . . . . . H-6545
, . . . . . . . . . . 194
.., .. . . . . . . . . . 194
.................. . 2057
Capacities and Specifications
Engine
Type
VIN Engine Code
K . . .
VIN Engine Code P .
Fuel Delivery . . . . . . . .
...... V6
. * . , . e. . V8
. . . . . . . . Fuel Injection
Valve Arrangement
. . . . .
Piston Displacement
VIN Engine Code K . . .
VIN Engine Code P . . . . .
Firing Order
VIN Engine Code K . . .
VIN Engine Code P .
.., . . . . In-Head
, . ,231 CID (3800)
, , . 350 CID (5.7L)
, . . 1-6-5-4-3-2
.... 1-8-4-3-6-5-7-2
Wheel Nut Torque
. . . . . . . . . . . 100 lb-ft (140 N-m)
Windshield Wiper Blade Replacement
Type
. . . . . ........................ hook
Length
. . . ..... . 24 inches (610 mm)

Capacities (Approximate)
The following approximate capacities are given in
English. and metric conversions. Please refer to
“Recommended Fluids and Lubricants” in the Index
for more information.
Air Conditioning?
, ... See the refrigerant
information label
under the hood.
Automatic Transmission Drain and Refill
............... 10 pints (4.7 L)*
Overhaul
VIN Engine Code K ........ 17.6 pints (8.3 L)*
VIN Engine Code P ....... 2 1.6 pints (10.2 L)*
Cooling System
VIN Engine Code K
With Manual Transmission . . 12.5 quarts (11.8 L)
With Automatic Transmission 12.3 quarts (1 1.6 L)
VIN Engine Code P
With Manual Transmission . 15.3 quarts (14.5 L)
With Automatic Transmission 15.1 quarts (14.3 L)
Crankcase
Oil and Filter Change
3800 (VIN K) ........... 4.5 quarts (4.3 L)**
5.7L (VIN P ) ............ 5.0 quarts (4.7 L)**
Fuel Tank
.................. 15.5 gallons (58.7 L)
Manual Transmission
Five-Speed
........... , . 6.8 pints (3.2 L)*
Six-Speed .......... ..... 8.0 pints (3.8L)*
Rear Axle Lubricant ............ 3.5 pints (1.7L)
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your Pontiac dealer,
* Recheck fluid level after filling. See “Automatic
Transmission Fluid”
or “Manual Transmission Fluid”
in the Index.
** Recheck the oil level after filling. See “Engine Oil”
in
the Index.
6-74

Wheelbase
Front Tread
Rear Tread
Length Firebirdmormula
Length Trans Am
Width
Height
Vehicle Dimensions
101.1 inches (257 cm)
60.7 inches (154 cm)
60.7 inches (154 cm)
195.6 inches (497 cm)
197 inches
(501 cm)
74.5 inches (190 cm)
52.0 inches (132 cm)
Replacement Parts
Air Cleaner Filter
VIN Engine Code
K . ........ A1163C
VIN Engine Code
P .................. A1163C
VIN Engine Code
P (with WS6 Option) ... A1097C
Battery ............................... .75-60
Engine Oil Filter
VIN Engine Code K ................. PF47
VIN Engine Code P
................... PF25

IVPORTANT. I
. .LEP ENGINE ai
AT THE PROPER
LEVEL AND CHANGE AS
RECOMMENDED
I
Have you purchased the GM Protection Plan? The Plan
supplements your new vehicle warranties. See your
Warranty and Owner Assistance
booklet, or yaur
Pontim dealer for details.
Ir * roduction
- ---r Vehicle and the Environment
Proper vehicle maintenance not only helps to keep your
vehicle in
good working condition, but also helps the
environment.
All recommended maintenance procedures
are important. Improper vehicle maintenance can even
affect
the quality of the air we breathe. Improper fluid
levels or the wrong tire inflation can increase the level
of emissions from your vehicle. TO help protect our
environment, and
to keep your vekicl'e in good
condition, please maintain your vehicle properly.
7-2

Maintenance Schedule
I Short TriplCity Definition I
Follow the Short Trip/City Maintenance Schedule if any
one
of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
driving in stop-and-go traffic).
0 Most trips include extensive idling (such as frequent
Most trips are through dusty areas.
You frequently tow a trailer or use a carrier on top of
your vehicle.
or other commercial application.
If the vehicle is used for delivery service, police, taxi
One of the reasons you should follow this schedule if
you operate your vehicle under any of these conditions
is that these conditions cause engine oil to break
down soonex
Short Trip/City Intervals
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Chassis Lubrication
(or
6 months, whichever occurs first). Tire Rotation.
Every 6,000 Miles (10 000 km) of Trailering: Rear
Axle Fluid Change (Vehicles Towing Trailers).
At the First 6,000 Miles (10 000 km): Rear Axle Fluid
Change (Limited-Slip Differential).
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection, if driving in dusty conditions. Automatic
Transmission
Service (severe conditions only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Spark Plug Wire
Inspection. Spark Plug Replacement. Automatic
Transmission Service (normal conditions).
Every 150,000 Miles (240 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be sure to follow the complete muintenance schedule on
the following pages.
I- 7-5