automatic transmission PONTIAC FIREBIRD 1997 Owner's Guide

Underhood Electrical Center
Fuse
ABS IGN (SA)
ACTUATORS (15A)
R HDLP DR (154
L HDLP DR (1 5A)
ABS VLV (20A)
Usage
Anti-Lock Brake System
Daytime Running
Lamp
Module, Headlamp
Switch, Cooling Fan
Relay, Exhaust,
Gas
Recirculation, EVAP
Canister Purge Solenoid
Headlamp Door Module
Headlamp
Door Module
Brake Pressure Valve
Fuse
ABS BAT (5A)
HORN (20A)
INJECTOR (15A)
ENG SEN (20A)
IGNITION
(1OA)
Usage
Electronic Brake Control
Module
AIR PUMPFAN
(25A) AIR Pump (V8) Relay,
Pump, Bleed Valve
and Cooling Fan
Horn Relay
Fuel Injectors
Mass Airflow, Heated
Oxygen
Sensor, Reverse
Lockout Solenoid, Skip
Shift Solenoid, Automatic
Transmission, Brake Switch
V6 VIN K: Electronic
Ignition Module
VS
VIN P: Ignition Coil
Module, Crankshaft
Position
Sensor.
A/C-CRUISE (15A) Air Conditioning
Compressor Relay;
Cruise Control Switches
and Module
6-72

Capacities (Approximate)
The following approximate capacities are given in
English. and metric conversions. Please refer to
“Recommended Fluids and Lubricants” in the Index
for more information.
Air Conditioning?
, ... See the refrigerant
information label
under the hood.
Automatic Transmission Drain and Refill
............... 10 pints (4.7 L)*
Overhaul
VIN Engine Code K ........ 17.6 pints (8.3 L)*
VIN Engine Code P ....... 2 1.6 pints (10.2 L)*
Cooling System
VIN Engine Code K
With Manual Transmission . . 12.5 quarts (11.8 L)
With Automatic Transmission 12.3 quarts (1 1.6 L)
VIN Engine Code P
With Manual Transmission . 15.3 quarts (14.5 L)
With Automatic Transmission 15.1 quarts (14.3 L)
Crankcase
Oil and Filter Change
3800 (VIN K) ........... 4.5 quarts (4.3 L)**
5.7L (VIN P ) ............ 5.0 quarts (4.7 L)**
Fuel Tank
.................. 15.5 gallons (58.7 L)
Manual Transmission
Five-Speed
........... , . 6.8 pints (3.2 L)*
Six-Speed .......... ..... 8.0 pints (3.8L)*
Rear Axle Lubricant ............ 3.5 pints (1.7L)
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your Pontiac dealer,
* Recheck fluid level after filling. See “Automatic
Transmission Fluid”
or “Manual Transmission Fluid”
in the Index.
** Recheck the oil level after filling. See “Engine Oil”
in
the Index.
6-74

Maintenance Schedule
I Short TriplCity Definition I
Follow the Short Trip/City Maintenance Schedule if any
one
of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
driving in stop-and-go traffic).
0 Most trips include extensive idling (such as frequent
Most trips are through dusty areas.
You frequently tow a trailer or use a carrier on top of
your vehicle.
or other commercial application.
If the vehicle is used for delivery service, police, taxi
One of the reasons you should follow this schedule if
you operate your vehicle under any of these conditions
is that these conditions cause engine oil to break
down soonex
Short Trip/City Intervals
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Chassis Lubrication
(or
6 months, whichever occurs first). Tire Rotation.
Every 6,000 Miles (10 000 km) of Trailering: Rear
Axle Fluid Change (Vehicles Towing Trailers).
At the First 6,000 Miles (10 000 km): Rear Axle Fluid
Change (Limited-Slip Differential).
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection, if driving in dusty conditions. Automatic
Transmission
Service (severe conditions only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Spark Plug Wire
Inspection. Spark Plug Replacement. Automatic
Transmission Service (normal conditions).
Every 150,000 Miles (240 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be sure to follow the complete muintenance schedule on
the following pages.
I- 7-5

Maintenance Schedule
n
Follow this maintenance schedule only if none of the
conditions from the Short Trip/City Maintenance
Schedule is true.
Do not use this schedule if the vehicle
is used for trailer towing, driven in
a dusty area or used
off paved roads. Use the Short Trip/City schedule for
these conditions.
Driving a vehicle with n fully warmed engine under
highway conditions causes engine oil to break
down sluwm
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change
(or every 12 months, whichever occurs first),
Chassis Lubrication (or every 12 months, whichever
occurs first). Tire Rotation,
At the First 7,500 Miles (12 500 km): Rear Axle Fluid
Change (Limited-Slip Differential),
Every 15,000 Miles (25 000 km): Automatic
Transmission Service (severe conditions only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 109,000 Miles (166 000 km): Spark Plug Wire
Inspection. Spark Plug Replacement. Automatic
Transmission Service (normal conditions).
Every 150,000 Miles (240 000 km): Cooling System
Service
(or every 60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be
sure to follow the cornnlete maintenance schedule on
the following pages,
7-6

I Short Trip/City Maintenance Schedule I
I!T9000 Miles (25 000. km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An,Emission Control Service.
0 Inspect air cleaner filter if you are driving
in dusty conditions. Replace filter if
necessary.
An Emission Control Servic'e. (See
footnote"f.)
0 Change 'automatic transmission fluid and
filter
if the vehicle is mainly driven I.-- ler
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, poli'ce or
delivery service.
lf you do not use your vehicle under any of
these conditions, change the fluid and filter at
~00,000 miles (166 000 km).
Manual transmission fluid doesn't
require chanqe.
- -
DATE
SERVICED BY: ACTUAL MILEAGE -
i

Short Trip/City Maintenance Schedule
30,000 Miles (50 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
6 months, whichever occurs first).
(See footnote
#.)
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
Replace air cleaner filter.
Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. (See footnote?.)
An Emission Control Service.
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one
or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90" F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
If you do not use your vehicle under any of
these conditions, change the fluid and-filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn't
require change.
delivery service.
(Continued)

Short Trip/City Maintenance Schedule ~~~
42,000 Miles (70 000 km)
CI Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
6 months, whichever occurs first).
(See footnote #.>
Q Rotate tires. See “Tire Inspection and
Rotation’’
in the Index for proper rotation
pattern and additional information. (See footnote
+.)
Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
DATE SERVICED BY: ~ ~~~ ACTUAL MILEAGE
45,000 Miles (75 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90°F
(32” C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the$uid andfilter at
100,000 miles (1 66 000 km).
7-16

Short Trip/City Maintenance Schedule
57,000 Miles (95 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
DATE
SERVICED BY: ACTUAL MILEAGE
60,000 Miles (100 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components (or every
6 months, whichever occurs first).
(See footnote
#.)
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32 O C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
(Continued)
7-19

1 Short Trip/City Maintenance Schedule 1
75,000 Miles (125 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter ut
100,000 miles (1 66 000 km).
Manual transmission fluid doesn’t
require change.
in dusty conditions. Replace filter if
necessary. An Emission Control Service.
(See footnote?.)
Inspect air cleaner filter if you are driving
DATE
SERVICED BY: ACTUAL MILEAGE
7-23

90,000 Miles (150 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Sewice.
0 Lubricate chassis components (or every
6 months, whichever occurs first).
(See footnote #.)
0 Change the rear axle gear lubricant if
vehicle is used to pull a trailer.
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 F
(32 C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
vyou do not use your vehicle under any oj
these conditions, change the fluid and filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn’t
require change.
Replace air cleaner filter.
An Emission Contrul Service.
Inspect fuel tank, cap and lines fur damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. (See fOOtnOte-f..)
delivery
service.
Short TripKity Maintenance Schedule
7-26