engine PONTIAC FIREBIRD 1998 Owners Manual

The level should be at the full cold mark. If necessary,
add only enough fluid to bring the level up to the
mark.
When the engine compartment is hot, the level
should be at the
H or hot mark.
0 When the engine compartment is cool, the level
should be at the
C or full cold mark.
What to Use
To determine what kind of fluid to use, see
“Recommended Fluids and Lubricants” in the Index.
Always use the proper fluid. Failure to use
the proper
fluid can cause leaks and darnage hoses and
seals.
1
Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer’s instructions before
use. If you will be
operating your vehicle in
an area where the temperature
may fall below freezing, use a fluid that has sufficient
protection against freezing.
Adding Washer Fluid
Open the cap labeled WASHER FLUID ONLY. Add
washer fluid until the tank
is full.
6-32

NOTICE:
When using concentrated washer fluid,
follow the manufacturer’s instructions
for
adding water.
Don’t mix water with ready-to-use washer
fluid. Water can cause the solution to freeze
and damage your washer fluid tank and
other parts of the washer system. Also,
water doesn’t clean as well as washer fluid.
three-quarters full when it’s
very cold.
This allows for expansion if freezing occurs,
which could damage the tank if
it is
completely full.
Don’t use engine coolant (antifreeze) in
your windshield washer.
It can damage
your washer system and paint.
0 Fill your washer fluid tank only
Brakes
Brake Fluid
Your brake master cylinder reservoir is on the driver’s
side of the engine compartment. It is filled with DOT-3
brake fluid.
6-33

There are only two reasons why the brake fluid level in the
reservoir might
go down. The first is that the brake fluid
goes down
to an acceptable level during normal brake
lining wear. When new linings are put in, the fluid level
goes back up. The other reason is that fluid is leaking out
of the brake system.
If it is, you should have your brake
system
fixed, since a leak means that sooner or later your
brakes won’t work well, or won’t work at
all.
So, it isn’t a good idea to “top off’ your brake fluid.
Adding brake fluid won’t correct a leak. If you add fluid
when your linings are worn, then you’ll have too much
fluid when
you get new brake linings. You should add
(or remove) brake fluid, as necessary, only when work
is
done on the brake hydraulic system.
A CAUTION:
If you have too much brake fluid, it can spill on the
engine. The
fluid will burn if the engine is hot
enough. You or others could be burned, and your
vehicle could be damaged. Add brake fluid only
when work is done on the brake hydraulic system.
Refer to the Maintenance Schedule to determine when to
check your brake fluid. See “Periodic Maintenance
Inspections”
in the Index.
Checking Brake Fluid
You can check the brake fluid without taking off the cap.
Just look
at the brake fluid reservoir. The fluid level
should be above the plastic
seam in the reservoir. If it
isn’t, have your brake system checked
to see if there
is
a leak.
After work is done on the brake hydraulic system,
make
sure the level is above the plastic seam, near the base of
the filler neck.

What to Add
When you do need brake fluid, use only DOT-3 brake
fluid. Use new brake fluid from a sealed container only.
Refer
to “Recommended Fluids and Lubricants” in the
Maintenance Schedule.
Always clean the brake fluid reservoir cap and the area
around the cap before removing it. This will help keep
dirt from entering the reservoir.
With the wrong kind
of fluid in your brake
system, your brakes may not work well, or they
may not even work
at all. This could cause a
crash. Always use the proper brake fluid.
NOTICE:
Using the wrong fluid can badly damage
brake system parts. For example, just
a few
drops of mineral-based oil, such
as engine
oil, in your brake system can damage brake
system parts
so badly that they’ll have to
be replaced. Don’t let someone put in the
wrong kind of fluid.
If you spill brake fluid on your vehicle’s
painted surfaces, the paint
finish can be
damaged. Be careful not to spill brake fluid
on your vehicle.
If you do, wash it off
immediately. See “Appearance Care” in
the Index.
Brake Wear
Your vehicle has four-wheel disc brakes.
Disc brake pads have built-in wear indicators that make a high-pitched warning sound when the brake pads are
worn and new pads are needed. The sound may come and
go or be heard
all the time your vehicle is moving (except
when you are pushing on the brake pedal firmly).
6-35

Vehicle Identification Number (VIN)
0, -111 11111111 1111 111 111111 111 11111111 111111111111 111111111 11- 0
SAMPLE4UXWM072675 t
ENGINE A98 f 1 ASSEMBLY
CODE- MODEL YEAR PLANT
-
This is the legal identifier for your vehicle. It appears on
a plate in the front corner of the instrument panel, on the
driver’s side. You can see it if you look through the
windshield from outside your vehicle. The
VIN also
appears on the Vehicle Certification and Service Parts
labels and the certificates of title and registration.
Engine Identification
The 8th character in your VIN is the engine code. This
code will help you identify your engine, specifications
and replacement
parts.
Service Parts Identification Label
You’ll find this label located on the driver’s side door.
It’s
very helpful if you ever need to order parts. On this
label is:
yourvm,
the model designation,
paint information and
0 a list of all production options and special
Be sure that this label is not removed from the vehicle.
equipment.
Electrical System
Add-on
Electrical Equipment
I NOTICE:
Don’t add anything electrical to your vehicle
unless you check with your dealer first. Some
electrical equipment can damage your vehicle
and the damage wouldn’t be covered by your
warranty.
Some add-on electrical equipment
can keep other components from
working as
they should.
Your vehicle has an air bag system. Before attempting to
add anything electrical to your vehicle, see “Servicing
Your Air Bag-Equipped Pontiac” in the Index.
6-62

The other two are in the engine compartment. Open the
cover on either
of the boxes to expose the fuses.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace
the fuse. Be sure you
replace a bad fuse with a new one of the correct size.
If you ever have a problem on the road and don't have a
spare fuse, you can borrow one. Just pick some feature
of your car that you
can get along without -- like the
radio or cigarette lighter
-- and use its fuse, if it is the
size
you need. Replace it as soon as you can.
Main Fuse Block
III 20 30 40
FUSE USAGE CHART
STOPIHAZARD TURN BIU STG WHL CNTRL RADIO ACCY
--
5u 4--l 7u 8U TAIL LPS HVAC PWR ACCY COURTESY
9-1 lin 121-1
GAUGES AIR BAG CIGIACCY DEFOGISEATS
IP DIMMER ACCY RADIO
SEE OWNER'S MANUAL FOR MORE INFORMATION PRINTED IN U.S.A
Fuse Usage
STOP/HAZARD Hazard Flasher, Brake
Switch Assembly
TURN B/U Traction ControVSecond Gear
Start Switch, Back/Up Lamp
Switch, Turn Flasher, Daytime
Running Lamps
(DRL) Module
Steering Wheel Controls
STG WHEEL
CNTFU
6-64

000
INJ INJ ENG SEN
STRTR ABS IGN PCM ION
000 ENG CTRL NC CRUISE
j 1:
15305530 A
Fuse
INJ
INJ
Fuse and Relay Center 2
Usage
Fuel Injectors (Not used for V6) (LH
injectors for V8 Ignition Module)
Fuel Injectors (All for
V6) (RH
injectors for V8 and Ignition Module)
ENG SEN Mass Air Flow, Heated Oxygen
Sensor,
Skip Shift Solenoid (V8
Only), Reverse Lockout Solenoid,
Brake Switch
STRTR
Powertrain Control Module and
Clutch Pedal Switch
Fuse
ABS IGN
PCM IGN
ENG CTRL
NC CRUISE
ENG CTRL
I/P- 1
IGN
m-2
Relay
AIR SOL
AIR PUMP
AIC COMP
FUELPUMP STARTER
IGN
Usage
Anti-Lock Brake System Module
Powertrain Control Module
Ignition Module
(V6 Only),
Automatic Transmission and
Charcoal
Canister Purge Solenoid
Air Conditioning Compressor Relay, Cruise Control Switches and Module
Engine Controls, Fuel
Pump, PCM,
A.I.R. and Cooling
Fans
HVAC Blower Control and Relay
Ignition Switch, Relay and Starter
Enable Relay
Instrument Panel
Fuse Center
6-67

Replacement Bulbs
Center High-Mounted Stoplamp ............. 921
Front Parking and Turn Signal
.......... 3 157NAK
Headlamp
(Low Beam) ................... 4703
Back-up
............................... 3155
Headlamp (High Beam)
................... 4701
Sidemarker .............................. 194
Tail Only
............................. 194
Tail/Stop/Turn ........................ 3057
Capacities and Specifications
Engine
Type VIN Engine Code
K ............. . . 3800 V6
VIN Engine Code
G .................. 5.7L V8
Fuel Delivery
.................... Fuel Injection
Valve Arrangement
.................... In-Head
VIN Engine Code
K ......... 231 CID (3791 cc)
VIN Engine Code
G ......... 350 CID (5735 cc)
VIN Engine Code
K .............. 1-6-5-4-3-2
Piston Displacement
Firing Order VIN Engine Code
G ........... 1-8-7-2-6-5-4-3
Wheel Nut Torque
........... 100 lb-ft (140 N-m)
Windshield Wiper Blade Replacement Type
................................. hook
Length .................... 24 inches (603 cm)
6-68

Capacities (Approximate)
Air Conditioning? ............. See the refrigerant
Automatic Transmission information label under the hood.
Drain and
Refill ......
Overhaul
VIN Engine Code K .
VIN Engine Code G .
Cooling System
VIN Engine Code K
....... 5 quarts (4.7 L)*
... 8.8 quarts (8.3 L)*
. 10.8 quarts (10.2 L)*
With Manual
With Automatic
VIN Engine Code G
Transmission ............ 12.5 quarts (1 1.8 L)
Transmission ............ 12.3 quarts (1 1.6 L)
With Manual
Transmission
...
With Automatic Transmission
.....
. . 15.3 quarts (14.5 L)
. . 15.1 quarts (14.3 L)
Crankcase
Oil and Filter Change
3800 V6 (VIN K) ......... 4.5 quarts (4.3 L)**
5.7L V8 (VIN G) ......... 5.5 quarts (5.2 L)**
Fuel Tank ................ 15.5 gallons (58.7 L)
Manual Transmission
Five-Speed
................ 3.4 quarts (3.2 L)*
Six-Speed ................... 4 quarts (3.8L)*
Rear Axle Lubricant ............ 1.75 quarts (1.7L)
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used. If
you’re not sure, ask your Pontiac dealer.
* Recheck fluid level after filling. See “Automatic
Transmission
Fluid” or “Manual Transmission Fluid”
in the Index.
** Recheck the oil level after filling. See “Engine Oil”
in the Index.
6-69

Vehicle Dimensions
Wheelbase ............ 101.1 inches (256.6 cm)
Front Tread
............. 60.7 inches (154.1 cm)
RearTread
............. 60.7inches(154.1 cm)
Length Firebird
/ Formula . . 193.5 inches (491.5 cm)
Length Trans Am ....... 193.9 inches (492.1 cm)
Width
............... 74.5 inches (1 89.3 cm)
Height.
.................. 52 inches (132.1cm)
Normal Maintenance Replacement Parts
Air Cleaner Filter VIN Engine Code
K .................. A1163C
VIN Engine Code G .................. A1163C
VIN Engine Code G
(with WS6 Option) .................. A1097C
Battery
................................ 75-60 Engine
Oil Filter
VIN Engine
Code K .................... PF47
VIN Engine Code
G .................... PF44
Fuel Filter
............................. GF578
PCV Valve
VIN Engine Code
K ............... CV892C
VIN Engine Code G ................. CV895C
Radiator Cap ......................... RC24
Spark Plug
VIN Engine Code
K .... 41-921 (0.060 inch Gap)
VIN Engine Code G .... 41-931 (0.060 inch Gap)
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same. If the
air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant
is used. If
you’re not sure
ask your dealer.
6-70