steering PONTIAC G5 2007 Service Manual

Fuses Usage
COOL FAN2 Engine Cooling Fan High Speed
CRNK Starter
COOL FAN 1 Engine Cooling Fan Low Speed
BCM3 Body Control Module 3
BCM2 Body Control Module 2
FOG LAMP Fog Lamps
HORN Horn
RT HI BEAM Passenger’s Side High Beam
LT HI BEAM Driver’s Side High Beam
RT LO BEAM Passenger’s Side Low Beam
LT LO BEAM Driver’s Side Low Beam
DRL Daytime Running Lamps
FUEL PUMP Fuel Pump
EXH Exhaust Emissions
Blank Not Used
INJ Injectors
Blank Not UsedFuses Usage
ABS Anti-lock Brake System
PCM/ECMPowertrain Control Module/Engine
Control Module
EPS Electric Power Steering
AIR PUMP AIR Pump
PRK LAMP Park Lamps
WPR Windshield Wiper
IP IGN Ignition
A/C CLTCH Air Conditioning Clutch
AIR SOL/
AFTERCOOLAIR Solenoid (L61, LE5),
Aftercooler (L4)
ABS2 Anti-lock Brake System 2
PRK/NEUT Park, Neutral
ECM/TRANS Engine Control Module, Transaxle
BCK UP Back-Up Lamps
TRUNK/OUTLET Trunk, Accessory Power Outlet
Blank Not Used
Blank Not Used
367

Scheduled Maintenance
Service MaintenanceIMaintenanceII
Change engine oil and lter. SeeEngine Oil on page 279. Reset oil life system.
SeeEngine Oil Life System on page 282.An Emission Control Service.••
Visually check for any leaks or damage.See footnote (j).••
Inspect engine air cleaner lter. If necessary, replace lter. SeeEngine Air
Cleaner/Filter on page 284.See footnote (k).•
Rotate tires and check ination pressures and wear. SeeTire Inspection and
Rotation on page 328and “Tire Wear Inspection” inAt Least Once a Month
on page 381.••
Inspect brake system.See footnote (a).••
Check engine coolant and windshield washer uid levels and add uid as
needed.••
Perform any needed additional services. See “Additional Required Services”
in this section.••
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Replace passenger compartment air lter.See footnote (l).•
Inspect throttle system.See footnote (g).•
377

Maintenance Footnotes
(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang,
etc. Inspect disc brake pads for wear and rotors for
surface condition. Inspect drum brake
linings/shoes for wear or cracks. Inspect other
brake parts, including drums, wheel cylinders,
calipers, parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing
parts or signs of wear. Inspect power steering
cables for proper hook-up, binding, cracks,
chang, etc.
(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated.
Inspect all pipes, ttings and clamps; replace with
genuine GM parts as needed. To help ensure
proper operation, a pressure test of the cooling
system and pressure cap and cleaning the outside
of the radiator and air conditioning condenser is
recommended at least once a year.
(d)Visually inspect wiper blades for wear or
cracking. Replace wiper blades that appear worn
or damaged or that streak or miss areas of
the windshield.(e)Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced. Also
look for any opened or broken airbag coverings,
and have them repaired or replaced. The
airbag system does not need regular maintenance.
(f)Lubricate all key lock cylinders, door hinges
and latches, hood hinges and latches and trunk lid
hinges and latches. More frequent lubrication
may be required when exposed to a corrosive
environment. Applying silicone grease on
weatherstrips with a clean cloth will make them
last longer, seal better, and not stick or squeak.
(g)Check system for interference or binding
and for damaged or missing parts. Replace parts
as needed. Replace any components that
have high effort or excessive wear. Do not
lubricate accelerator or cruise control cables.
379

Automatic Transaxle Shift Lock Control
System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough
room around the vehicle. It should be parked
on a level surface.
2. Firmly apply the parking brake. SeeParking
Brake on page 118.
Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the ignition to RUN,
but do not start the engine. Without applying
the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the
shift lever moves out of PARK (P), contact
your GM Goodwrench
®dealer for service.
Ignition Transaxle Lock Check
While parked, and with the parking brake set, try
to turn the ignition to LOCK in each shift lever
position.
With an automatic transaxle, the ignition
should turn to LOCK only when the shift lever
is in PARK (P). The ignition key should
come out only in LOCK.
With a manual transaxle, the ignition key
should come out only in LOCK.
Turn the steering wheel to the left and to the right.
It should only lock when turned to the right.
Contact your GM Goodwrench
®dealer if service is
required.
383

Canadian Vehicles:For warranty repairs during
the Complete Vehicle Coverage period of the
General Motors of Canada New Vehicle Limited
Warranty, alternative transportation may be
available under the Courtesy Transportation
Program. Please consult your dealer for details.
General Motors reserves the right to unilaterally
modify, change or discontinue Courtesy
Transportation at any time and to resolve all
questions of claim eligibility pursuant to the terms
and conditions described herein at its sole
discretion.
Vehicle Data Collection and
Event Data Recorders
Your vehicle, like other modern motor vehicles,
has a number of sophisticated computer systems
that monitor and control several aspects of the
vehicle’s performance. Your vehicle uses on-board
vehicle computers to monitor emission control
components to optimize fuel economy, to monitor
conditions for airbag deployment and, if so
equipped, to provide anti-lock braking and to help
the driver control the vehicle in difficult driving
situations.Some information may be stored during regular
operations to facilitate repair of
detected malfunctions; other information is
stored only in a crash event by computer systems,
such as those commonly called Event Data
Recorders (EDR).
In a crash event, computer systems, such as the
airbag Sensing and Diagnostic Module (SDM)
in your vehicle may record information about the
condition of the vehicle and how it was operated,
such as data related to engine speed, brake
application, throttle position, vehicle speed, safety
belt usage, airbag readiness, airbag performance,
and the severity of a collision. If your vehicle is
equipped with StabiliTrak
®, steering performance,
including yaw rate, steering wheel angle, and
lateral acceleration, is also recorded. This
information has been used to improve vehicle
crash performance and may be used to improve
crash performance of future vehicles and
driving safety. Unlike the data recorders on many
airplanes, these on-board systems do not
record sounds, such as conversation of vehicle
occupants.
403

In Canada, please call us at 1-800-263-3777
(English) or 1-800-263-7854 (French). Or, write:
General Motors of Canada Limited
Customer Communication Centre, CA1-163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle
suspension, brakes, electrical, steering, body, etc.
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit repair
service procedures, adjustments, and
specications for GM transmissions, transaxles,
and transfer cases.
Service Bulletins
Service Bulletins give technical service information
needed to knowledgeably service General
Motors cars and trucks. Each bulletin contains
instructions to assist in the diagnosis and service
of your vehicle.
In Canada, information pertaining to Product
Service Bulletins can be obtained by contacting
your General Motors dealer or by calling
1-800-GM-DRIVE (1-800-463-7483).
410

Audio System(s).......................................... 185
Audio Steering Wheel Controls................. 214
Care of Your CD Player........................... 216
Care of Your CDs.................................... 216
Fixed Mast Antenna................................. 216
Radio with CD................................189, 194
Setting the Time..............................186, 187
Theft-Deterrent Feature............................ 214
Understanding Radio Reception............... 215
XM™ Satellite Radio Antenna System...... 216
Automatic Door Lock..................................... 96
Automatic Transaxle
Fluid........................................................ 286
Operation................................................. 113
B
Battery........................................................ 303
Electric Power Management..................... 149
Run-Down Protection............................... 150
Before Leaving on a Long Trip.................... 240Brake
Anti-Lock Brake System (ABS)................. 223
Emergencies............................................ 225
Parking.................................................... 118
System Warning Light.............................. 165
Brakes........................................................ 298
Braking....................................................... 222
Braking in Emergencies............................... 225
Break-In, New Vehicle................................. 106
Bulb Replacement....................................... 312
Back-Up Lamps....................................... 317
Center High-Mounted
Stoplamp (CHMSL)............................... 315
Halogen Bulbs......................................... 312
Headlamp Aiming..................................... 309
Headlamps, Front Turn Signal,
Sidemarker, and Parking Lamps........... 313
License Plate Lamps................................ 318
Replacement Bulbs.................................. 318
Taillamps and Turn Signal Lamps............. 316
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps..................................... 316
Buying New Tires........................................ 330
414

Servicing Your Airbag-Equipped Vehicle......... 78
Setting the Time.................................186, 187
Sheet Metal Damage................................... 359
Shifting Into Park (P)................................... 119
Shifting Out of Park (P)............................... 121
Shoulder Belt Height Adjuster........................ 30
Signals, Turn and Lane-Change.................. 140
Spare Tire
Compact.................................................. 352
Installing.................................................. 344
Removing................................................ 339
Storing..................................................... 349
Specications, Capacities............................ 369
Speedometer............................................... 159
Starting Your Engine................................... 110
Steering...................................................... 227
Steering Wheel Controls, Audio................... 214
Steering Wheel, Tilt Wheel.......................... 139
Storage Areas
Center Console Storage Area................... 131
Convenience Net..................................... 131
Cupholder(s)............................................ 131
Driver’s Storage Compartment................. 131
Glove Box................................................ 131
Stuck in Sand, Mud, Ice, or Snow............... 248
Sun Visors.................................................. 102
Snroof......................................................... 132T
Tachometer................................................. 159
Taillamps
Turn Signal Lamps................................... 316
Turn Signal, Stoplamps and
Back-up Lamps..................................... 316
Theft-Deterrent, Radio................................. 214
Theft-Deterrent Systems .............................. 102
Content Theft-Deterrent............................ 102
PASS-Key
®III+........................................ 104
PASS-Key®III+ Operation........................ 104
Tilt Wheel.................................................... 139
Tires........................................................... 320
Aluminum or Chrome-Plated Wheels,
Cleaning............................................... 358
Buying New Tires..................................... 330
Chains..................................................... 336
Changing a Flat Tire................................ 338
Cleaning.................................................. 359
Compact Spare Tire................................. 352
Different Size........................................... 332
If a Tire Goes Flat................................... 337
Ination - Tire Pressure............................ 327
Inspection and Rotation............................ 328
Installing the Spare Tire........................... 344
425