heating PONTIAC GRAND-AM 1994 User Guide

Problems on the Road
1 Cooling System (CONK)
If the coolant inside the coolant surge
tank is boiling, don’t do anything else
until it cools down. The coolant level should be at or above
FULL COLD. If it isn’t, you may have a
leak in the radiator hoses, heater hoses,
radiator, water pump or somewhere else
in the cooling system. ~~~
NOTICE:
Engine
damage from running your
engine without coolant isn’t covered
by your warranty.
If there seems to be no leak, check to see
if the electric engine fan is running. If the
engine is overheating, the fan should be
running. If it isn’t, your vehicle needs
service.
e e e 158
ProCarManuals.com

Service & Appearance Care
How to Check:
The proper fluid should be added if the
level is at or below the STEP mark on the
reservoir cap. See the instructions on the
reservoir cap.
Engine Coolant
The following explains your cooling
system and how to add coolant when
it is
low.
If you have a problem with engine
overheating, see “Engine Overheating”
in
the Index,
The proper coolant for your Pontiac will:
Give freezing protection down to
-34°F (-37°C).
Give boiling protection up to 262°F
( 128 “C).
Protect against rust and corrosion.
Help keep the proper engine
temperature.
Let the warning lights work as they
should.
What to Use
Use a mixture of one-half clean water
(preferably distilled) and one-half
antifreeze that meets “GM Specification
1825-M,” which won’t damage aluminum
parts.
You can also use a recycled coolant
conforming to GM Specification 1825-M
with a complete coolant flush and refill. If
you use this mixture, you don’t need to
add anything else. NOTICE:
If you use an improper coolant mix,
your engine could overheat and be
badly damaged. The repair cost
wouldn’t be covered by your
warranty. Too much water
in the
mix can freeze and crack the engine,
radiator, heater core and other parts.
... 188
ProCarManuals.com

Service & Appearance Care
V
P
I
E
b
S’
C
C.
P
A
I Surge Tank Pressure
Cap
NOTICE:
Your pressure cap is an 18 psi
( 124 kPa) pressure-type cap and
must be tightly installed to prevent
coolant
loss and possible engine
damage from overheating.
irhen you replace your surge tank
ressure cap, a GM cap is recommended.
I Thermostat
lngine coolant temperature is controlled
y a thermostat in the engine coolant
ystem. The thermostat stops the flow
of
oolant through the radiator until the
oolant reaches a preset temperature.
Jhen you replace your thermostat, an
.C@ thermostat is recommended.
Power Steering Fluid
How To Check Power
Steering Fluid
Unscrew the cap and wipe the dipstick
with a clean rag. Replace the cap and
completely tighten
it. Then remove the
cap again and
look at the fluid level on
the dipstick.
0
0
When the engine compartment is hot,
the level should be at the HOT
(H)
mark.
When the engine compartment is cool,
the level should be at the
COLD (C)
mark.
1
I
1
What to Add
Refer to the Maintenance Schedule to
jetermine what kind
of fluid to use. See
“Recommended Fluids and Lubricants”
in
the Index.
NOTICE:
When adding power steering fluid
or making a complete fluid change,
always use the proper fluid. Failure
to use the proper fluid can cause
leaks and damage hoses and seals.
... 190
ProCarManuals.com

Highway Hypnosis ........... 134
.Hill and Mountain ............ 134
In a Foreign Country
.......... 172
In the Rain
.................. 13C
Logg Distance ............... 132
Loss of Control
.............. 128
On Curves
.................. 125
Passing
.................... 127
Skidding
................... 128
Through Deep Standing Water
... 58
Winter Driving .............. 136
With a Trailer
............... 144
Driving.on Snow or Ice .......... 136
Drunken Driving
............... 120
Easy-Entry Seat ................ 11
Electrical Equipment. Adding
. 107. 2 1 1
Emergencies. Braking .. .. ........ 125
Emergencies on the Road
......... 147
Emergencies. Steering
in ......... 126
Emergency Starting
.. i .......... 148
Emergency Towing
............. 152
Engine Coolant Heater (Engine Block Heater)
....... : ..... 58. 182
Engine Coolant Temperature
Warning Light ................. 94
Engine Identification
............ 2 11
Engine Oil
.................... 179
Additives ................... 182
Checking
& Adding .......... 179
Disposing of Used Oil
........ 182
Engine Coolant (see “Coolant”) .... 188
Energy Conserving ........... 18 I
Filter .................. 182. 22C
Kind of Oil to Use
............ 18C
Pressure- Gage ................ 9f
Warning Light
................ 95
When to Change ............. 182
Engine Overheating ............. 156
Engine Specifications
............ 2 19
Engine. Starting
................. 56
Automatic Transaxle ........... 56
Manual Transaxle ............. 56
2.3L Quad 4 Engine
........... 56
3.lL V6 Engine ............... 57
Ethanol in Gasoline ......... 17 1. 172
Exhaust
Dangerous Gas in
......... 70. 138
Pirking with the Engine
Running ................ 67. 69
Expectant Mothers. Use of Safety
Belts ......................... 26
Expressway Driving
............. 132
Extender. Safety Belt
............. 42
Exterior Appearance (see “Appearance
Care”) ....................... 204
Fabric Cleaning (see “Appearance
Care”) ...................... 204
Filling the Fuel Tank
........ 174. 2 16
Filter. Oil
................ 182. 220
Finish Damage
................. 209
Flashers. Hazard Warning
........ 148
Flat Tire
...................... 161
Flooded Engine ................. 57
Flow-Through Ventilation System . . 105
Fluid
‘Brake ...................... 192
Capacities
.................. 215
Hydraulic Clutch
............. 187
Power Steering
.......... 190. 216
Transaxle
Automatic ........... 184. 215
Manual
.............. 186. 215
Windshield Washer
........... 191
Fluids
& Lubricants ............. 238
Fog Lights
................. 79. 196
Freeway Driving
............... 132
French Language Manual
.......... 2
Fuel
......................... 171
Alcohol
in Fuel .......... 17 1. 172
Capacity
................... 216
Exhaust Warnings
......... ..70. 138
Filling Your Tank
......... 1 .. 174
Fuels
with Alcohol ....... !7 1. 172
Gage
........................ 93
In Foreign Countries .......... 173
Remote Fuel Filler Door
........ 53
Requirements
............... 171
Fuse Usage Chart ............... 213
Fuses
& Circuit Breakers ......... 212
Gages
Coolant Temperature .......... 94
Fuel ........................ 93
Oil Pressure .................. 96
265
E
ProCarManuals.com

Lights on Reminder .............. 77
Loading Your Vehicle
........... 197
Locks. Door
.................... 47
Automatic Door Lock .......... 48
Rear Door Security Locks
...... 49
Low Battery
................... 149
Low Oil Pressure Warning
...... 95. 96
Lubricants and Fluids
............ 238
Lumbar Support
.................. 9
Maintenance Record ........... 240
Maintenance Schedule
........... 223
Maintenance Services. Scheduled
. . 225
Malfunction Indicator Lamp
...... 100
Manual 4-Way Adjustable Seat ...... 8
Manual Front Seat ................ 8
Manual Lumbar Support
........... 9
Manual Transaxle
Adding Fluid ............ 187. 215
Checking Fluid
.............. 186
Parking
..................... 69
Shifting
..................... 64
Starting Your Engine
........... 56
Upshift Indicator Light
......... 67
Master Cylinder. Brake .......... 191
Methanol in Gasoline ........ 171. 172
Mileage Indicator (see “Odometer
Mirrors
& Speedometer”)
Convex Outside .............. 83
Inside Manual Daymight
....... 82
Manual Remote Control
........ 83
I
I
I
I
I
I
1
Power Remote Control ......... 84
Mountain Driving
............... 134
New Vehicle “Break-In”
Requirements .................. 54
Night Driving
.................. 129
Night Vision
................... 129
Octane Requirements (see “Fuel
Requirements”) ............... 17 1
Odometer
& Speedometer ......... 92
Off Road Recovery
............. 127
Oil. Engine
.................... 179
Pressure Gage ................ 96
Quality
.................... 180
Thickness .................. 180
Used Oil
................... 182
When to Change
.............. 182
Operation of Lights .............. 77
Outside Rearview Mirrors
......... 83
Overheated Engine
.............. 156
Overheated Engine Coolant Warning
Light ......................... 94
Owner Checks
& Services ........ 232
Oil Warning Light ............... 95
Parking
On Hills .................... 145
With the Engine Running
.... 68. 70
Parking Brake
................... 66
Over Things That Burn ......... 69
Park . Shifting Into ............ 60. 67
Passenger Belts (see “Safety Belts”)
Passenger Side Cup
Holder/Storage Area ............ 85
Passing
....................... 127
Polishing and Waxing (see
Power Door Locks ............... 48
Power Mirrors
.................. 84
Power Seat Controls
............... 9
Power Steering Fluid ............ 190
Power Window Lock-Out Switch ... 72
Power Windows
................. 72
Pregnancy. Use of Safety Belts
During ....................... 26
Problems on the Road
........... 147
Publications (see “Service
Publications”) ................ 250
Radiator Overheating
(see “Overheated Engine”) ....... 156
Radio (see “Audio Systems”)
..... 106
Reading Lights
.................. 79
Rear Door Security Locks
......... 49
Rear Safety Belt Comfort Guides
... 30
Rear Seat. Split Fold-Down ........ 11
Rear Window Defogger
.......... 105
Rearview Mirrors ................ 82
Reclining Seatbacks
............... 9
Recommended Fluids
& Lubricants 238
Remote Fuel Filler Door
......... 174
Remote Trunk Release
............ 53
Replacement Brakes
............. 193
“Appearance Care”)
267 . .
ProCarManuals.com