oil temperature PONTIAC GRAND-AM 1996 Owners Manual

To use the coolant heater:
1. Turn off the engine.
2. Open the hood and unwrap the electrical cord.
3. Plug it into a normal, grounded 110-volt AC outlet.
1 A CAUTION:
Plugging the cord into an ungrounded outlet
could cause an electrical ,shock. Also, the wrong
kind
of extension cord could overheat and cause
a fire. You could be seriously injured. Plug the
cord into
a properly grounded three-prong
110-volt
AC outlet. If the cord won't reach, use a
heavy-duty three-prong extension cord rated for
at least 15 amps.
,-.. . . . 4.8 ..
4. After you've used the coolant heater, be sure to store
the cord as it was before
to keep it away from
moving engine parts. If you don't, it could be
damaged.
How long should you keep$he coolarit heater plugged
in? The answer depends on the outside temperature,
the
kind of oil you have, and some other things. Instead of
trying to list everything here, we
ask that you contact
yo" Pontiac dealer in the area where you'll be parking
your vehicle. The dealer can give you the best advice for
that particular area.
.. . i
ProCarManuals.com

' RECOMMENDED SAE VISCOSITY GRADE gNOINE OILS
FOR BEST FUEL ECONOMY AND COLD STARTING, SELECT THE LOWEST
SAL llscosnrr GRADE OIL FOR THE EXPECTED TEMPERATURE RAW6E.
HOT
WEATHER
/
SAE iw-# PREFERRED
LOOK
FOR THIS
SYMBOL
GOLD
WEATHER
DO NOT USE SAE 2OW-50 OR ANY OTHER GRADE OIL NOT RECOMMENDED
As shown in the chart, SAE 5W-30 is best for your
vehicle. However, you 'can use SAE 1OW-30 if it's going
to be 0' F (- 18 C) or above. These numbers on an ~il
container show its viscosity, or thickness. Do not use
other viscosity oils, such as SAE 2OW-50.
T
t
NOTICE:
Use only engine oil with the American Petroleum
Institute Certified For Gasoline
Engines
"Starburst" symbol. Failure to use the
recommended oil can result in engine damage not
covered by your warranty.
GM Goodwrench@ oil meets all the requirements for
your vehicle.
Engine Oil Additives
Don't add anything to your oil. Your Pontiac dealer is
ready to advise if you tW ssmethin~ should be added.
6-14
ProCarManuals.com

When to Change Engine Oil
See if any one of these is true for you:
0 Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures
are below freezing.
0 Most trips include extensive idling (such as frequent
driving in stop-and-go traffic).
Most trips are through dusty areas.
0 You frequently tQw a trailer or use a carrier on top of
your vehicle.
or other commercial application.
The vehicle is used for delivery service, police, taxi
Driving under these conditions causes engine oil to
break down sooner. If any one of these is true for your
vehicle, then you need to change your oil and filter
every
3,000 miles (5 000 km) or 3 months -- whichever
occurs first.
If none
of them is true, change the oil and filter every
7,500 miles (12 500 km) or 12 months -- whichever
occurs first. Driving a vehicle with a fully warmed
engine under highway conditions causes engine
oil to
break down slower.
What to Do with Used Oil
Did you know that used engine oil contains certain
elements that may be unhealthy for your skin and could
even cause cancer? Don’t
let used oil stay on your skin
for very long. Clean your skin and nails with soap and
water,
or a good hand cleaner. Wash or properly throw ‘
away clothing or rags containing used engine oil. (See
the manufacturer’s warnings about the use and disposal
of
oil products.)
Used oil can be a real threat to the environment.
If you
change your own oil, be sure to drain all free-flowing oil
from the filter before disposal. Don’t ever dispose of oil
by putting it in the trash, pouring it on the ground, into
sewers, or into streams or bodies
of water. Instead,
recycle
it by taking it to a place that collects used oil. If
you have a problem properly disposing of your used oil,
ask your dealer, a service station or a local recycling
center for help.
6-15
ProCarManuals.com

Automatic Transaxle Fluid
When to Check and Change
A good time to check your automatic transaxle fluid
level is when the engine oil is changed.
Change both the fluid and filter every
50,000 miles
(83 000 km) if the vehicle is mainly driven under one or
more of these conditions:
0 In heavy ,city traffic where the outside, temperature
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such zp found in taxi, police or delivery service.
If you do not use your vehicle under any of these
conditions, the fluid and
filter do not require changing.
See “Scheduled Maintenance Services”
in the Index.
How to Check
Because this operation can be a little difficult, you may choose to have this done at your Pontiac dealership Service Department.
If you do it yourself, be sure to follow all the instructions
here, or
you could get a false reading on the dipstick.
regularly reaches
90°F (32°C)
or higher.
NOTICE:
Too much or too little fluid can damage your
transaxle.
Too much can mean that some of the
fluid could come out and fall on hot engine parts
or exhaust system parts, starting a fire. Be sure to
get an accurate reading if you check your
transaxle fluid.
Wait at least 30 minutes before checking the transaxle
fluid level
if you have been driving:
0 When outside temperatures are above 90°F (32°C).
0 At high speed for quite a while.
0 In heavy traffic -- especially in hot weather.
0 While pulling a trailer.
To get the right reading, the fluid should be at normal
operating temperature, which
is 180°F to 200°F
(82°C to 93°C).
Get the vehicle warmed up by driving about 15 miles
(24 krn) when outside temperatures are above 50°F
(10°C). If it’s colder than 50°F (lO°C), you may have
to drive longer.
ProCarManuals.com

When to Check and What to Use
Refer to the Maintenance
Schedule
to determine how
often you should check the
fluid level
in your clutch
master cylinder reservoir and for
the proper fluid.
See “Owner Checks
and Services” and
“Recommended Fluids
and Lubricants” in the
How tu Check
The proper fluid should be added if the level is at or
below the
STEP mark on the reservoir cap. See the
instructions
on the reservoir cap.
Engine Coolant
The cooling system in your vehicle is filled with new
DEX-COOL TM (orange-colored, silicate-free) engine
coolant.
This coolant is designed to remain in your
vehicle
for 5 years or 100,000 miles (166 000 h),
whichever occurs first. The
following explains
your cooling system and how to
add coolant when it is low. If you have a problem with
engine overheating, see “Engine Overheating”
in the
Index.
A Sol50 mixture of water and the proper coolant for
your Pontiac will:
Give freezing protection down to -34°F (-37°C).
Give boiling protection up to 265 9 F ( 129 O C).
Protect against rust and corrosion.
0 Help keep the proper engine temperature.
Let the warning lights and gages work as they
should.
6-22
ProCarManuals.com

Maintenance Schedule
~~~~ .
Short Ikip/Cit"""'
Follow the Short Trip/City Maintenance Schedule if any
one of these. conditions is true for your vehicle:
Most trips are less than 5'to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
Most trips include extensive idling (such as frequent
driving in stop-and-go traffic).
Most trips are through dusty areas.
You frequently tow a trailer or use a carrier on top of
your vehicle. (With some models, you should never
tow a trailer. See
"Towing a Trailer" in the Index.)
taxi, or other commercial application.
If the vehicle is used for delivery service, police,
One of the reasons you should follow this schedule if
you operate your vehicle under any of these conditions
is that these conditions cause engine oil to break down
sooner.
I,
t
~~
Short Trip/City Intervals r
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change
(or 3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Chassis Lubrication
(or
6 months, whichever occurs first).
At 6,000 Miles (10 00'0 km), - Then Every
12,000 Miles (20 000 km): Tire Rotation.
Every 15,000 Miks (25 000 km): Air Cleaner Filter
Inspection,
if driving in dusty conditions.
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel
Tank, Cap and.Lines Inspection.
Every 50,000 Miles (83 000 km): Automatic Transaxle
Service (severe conditions only).
Every 60,000 Miles (I00 000 b): Engine Accessory
D'rive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occws first).
Spark Plyg Wire Inspection. Spark Plug Replacement.
These intewals only summarize maintenance services.
Be sure to
follow the complete maintenance schedule on
the following pages. . L . . .:-
ProCarManuals.com

45,000 Miles (75.000 km) +
Cl Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the suspension, steering linkage
and transaxle shift linkage (or
every
12 months, whichever occurs first).
50,000 .I Miles (83.000 km)
Change automatic transaxle fluid and filter
if the vehicle is mainly driven under one or
more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches 90 F
(3 2 * C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
7-30
ProCarManuals.com

Engine .................................... 6-8. 6.9
Coolant ..................................... 6-22
Coolant Heater ................................ 2-16
Codant Level Check ........................... 7-37
Exhaust ..................................... 2-28
Fuse Block .................................. 6-58
Identification ................................. 6-53
Oil Level Check .............................. 7-37
Overheating .................................. 5-12
Ruining While Parked ......................... 2-29
Specifications
................................ 6-61
Starting
..................................... 2-13
Engineoil
.................................... 6-10
Adding ..................................... 6-12
Additives ................................... 6-14
Checking .................................... 6-11
Used ....................................... 6-15
WhatToUse ................................. 6-13
When to Change
.............................. 6-15
Enhanced Traction System Active Light
........ : 2-59. 4-8
. Coolant Temperature Gage ..................... 2-59
Enhanced Traction System Warning Light ........ 2-58. 4-9
Ethanol ........................................ 6-3
Exhaust. Engine ................................. 2-28
'Fabric
Cleaning ............................... 6-46
Fifth Gear. Manual Transaxle ..................... 2-21
Filling Your Tank ................................. 6-4
Filter, Air ..................................... 6-16
FinishDamage
................................. 6- 51
First Gear. Automatic Transaxle ................... 2-20.
FinishC .. .................................... 6-49 First
Gear. Manual Transaxle ....................... 2-21
Flashers. Hazard Warning
......................... 5-1
Flat Tire. Changing ............................. 5-21
Fluids and Lubricants .......................... 7-42
Fog Lamp Bulb Replacement ..................... 6-35
FogLamps ..................................... 2-41
Foreign Countries. Fulel ........................... 6-3
Fourth Gear. Manual Transaxle .................... 2-21
FrenchLanguageManual
11
FrontTowing ................................... 5-9
Fuel .......................................... 6-2
FillingYourTank .............................. 6-4
In Foreign Countries ........................... 6-3
Fuses and Circuit Breakers ....................... 6-55
.. ...........................
Gage ....................................... 2-65
Gages Engine Coolant Temperature
.................... 2-59
Fuel ........................................ 2-65
Speedometer .................................. 2-53
Tachometer .................................. 2-54
Garment
Hook ................................. 2-48 .....
GAWR ....................................... 4-32 ~ . >T ..
Gear Positions, Aut'omatic Transaxle ................ 2- 1.8
Gear Positions, Manual Transaxle .................. 2-21
GloveBox
.................................... 2-46
Graphic Equalizer .............................. 3-14
Gross Axle Weight Rating ........................ 4-32
Gross Vehicle Weight Rating ...................... 4-32
Guide en Fraqais ................................. ii
GW ....................................... 4-32
9-4
ProCarManuals.com