transmission PONTIAC SOLSTICE 2009 Service Manual

Parking Brake and Automatic
Transmission P (Park) Mechanism
Check
{CAUTION:
When you are doing this check, the vehicle could
begin to move. You or others could be injured and
property could be damaged. Make sure there is
room in front of the vehicle in case it begins to roll.
Be ready to apply the regular brake at once
should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and transmission in N (Neutral),
slowly remove foot pressure from the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
To check the P (Park) mechanism’s holding
ability: With the engine running, shift to P (Park).
Then release the parking brake followed by
the regular brake.
Contact your dealer/retailer if service is required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
Tire Sealant and Compressor Kit
Check the sealant expiration date printed on the
instruction label of the Tire Sealant and Compressor Kit
at least once a year. See your dealer/retailer for a
replacement canister.
6-11

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number, or specication can be obtained from your
dealer/retailer.
Usage Fluid/Lubricant
Engine Oil
(2.4L L4
engine)Engine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on
page 5-15.
Engine Oil
(2.0L L4
engine)The engine requires a special
engine oil meeting GM Standard
GM4718M. Oils meeting this
standard can be identied with the
American Petroleum Institute (API)
Certied for Gasoline Engines
starburst symbol. However, not all
synthetic API oils with the starburst
symbol will meet this GM standard.
Look for and use only an oil that
meets GM Standard GM4718M. For
the proper viscosity, seeEngine Oil
on page 5-15.
Usage Fluid/Lubricant
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 5-25.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Hydraulic
Clutch SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184, in
Canada 89021186).
Windshield
WasherOptikleen
®Washer Solvent.
Manual
TransmissionManual Transmission Fluid
(GM Part No. U.S. 89021806, in
Canada 89021807).
Automatic
TransmissionDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
6-12

Reporting Safety Defects to
General Motors
In addition to notifying NHTSA (or Transport Canada) in
a situation like this, please notify General Motors.
Call 1-800-762-2737, or write:
Pontiac Customer Assistance Center
P.O. Box 33172
Detroit, MI 48232-5172
In Canada, call 1-800-263-3777 (English) or
1-800-263-7854 (French), or write:
General Motors of Canada Limited
Customer Communication Centre, CA1-163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle suspension,
brakes, electrical, steering, body, etc.
Service Bulletins
Service Bulletins give additional technical service
information needed to knowledgeably service General
Motors cars and trucks. Each bulletin contains
instructions to assist in the diagnosis and service of
your vehicle.
Owner Information
Owner publications are written specically for owners
and intended to provide basic operational information
about the vehicle. The owner manual includes the
Maintenance Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner Manual, and
Warranty Booklet.
RETAIL SELL PRICE: $35.00 (U.S.) plus processing fee
Without Portfolio: Owner Manual only.
RETAIL SELL PRICE: $25.00 (U.S.) plus processing fee
Current and Past Model Order Forms
Technical Service Bulletins and Manuals are available
for current and past model GM vehicles. To request
an order form, specify year and model name of
the vehicle.
7-14

ORDER TOLL FREE: 1-800-551-4123
Monday-Friday 8:00 AM - 6:00 PM
Eastern Time
For Credit Card Orders Only
(VISA-MasterCard-Discover), visit Helm, Inc. on the
World Wide Web at: helminc.com
Or you can write to:
Helm, Incorporated
P.O. Box 07130
Detroit, MI 48207
Prices are subject to change without notice and without
incurring obligation. Allow ample time for delivery.
Note to Canadian Customers: All listed prices are
quoted in U.S. funds. Canadian residents are to make
checks payable in U.S. funds.
Vehicle Data Recording and
Privacy
Your GM vehicle has a number of sophisticated
computers that record information about the vehicle’s
performance and how it is driven. For example,
your vehicle uses computer modules to monitor and
control engine and transmission performance, to monitor
the conditions for airbag deployment and deploy
airbags in a crash and, if so equipped, to provideantilock braking to help the driver control the vehicle.
These modules may store data to help your dealer/
retailer technician service your vehicle. Some modules
may also store data about how you operate the
vehicle, such as rate of fuel consumption or average
speed. These modules may also retain the owner’s
personal preferences, such as radio pre-sets, seat
positions, and temperature settings.
Event Data Recorders
This vehicle has an Event Data Recorder (EDR). The
main purpose of an EDR is to record, in certain crash or
near crash-like situations, such as an airbag deployment
or hitting a road obstacle, data that will assist in
understanding how a vehicle’s systems performed. The
EDR is designed to record data related to vehicle
dynamics and safety systems for a short period of time,
typically 30 seconds or less. The EDR in this vehicle
is designed to record such data as:
How various systems in your vehicle were operating
Whether or not the driver and passenger safety
belts were buckled/fastened
How far, if at all, the driver was pressing the
accelerator and/or brake pedal
How fast the vehicle was traveling
7-15

Audio System(s).............................................3-49
Automatic Door Lock......................................... 2-7
Automatic Door Unlock...................................... 2-7
Automatic Transmission
Fluid..........................................................5-22
Operation...................................................2-19
B
Battery..........................................................5-35
Run-Down Protection...................................3-14
Bluetooth
®.....................................................3-68
Brake
Emergencies................................................ 4-5
Brake Fluid....................................................5-32
Brakes..........................................................5-32
System Warning Light..................................3-25
Braking........................................................... 4-4
Braking in Emergencies..................................... 4-5
Break-In, New Vehicle.....................................2-16
Bulb Replacement...........................................5-42
Back-Up Lamps...........................................5-44
Front Turn Signal, Parking and Fog Lamps.....5-43
Halogen Bulbs............................................5-42
Headlamp Aiming........................................5-41
Headlamps.................................................5-42Bulb Replacement (cont.)
License Plate Lamps....................................5-45
Replacement Bulbs......................................5-45
Taillamps, Turn Signal, and Stoplamps....5-43, 5-44
Buying New Tires...........................................5-63
C
California Fuel.................................................. 5-6
California Perchlorate Materials Requirements....... 5-4
California Proposition 65 Warning....................... 5-4
Canadian Owners................................................ ii
Capacities and Specications..........................5-104
Carbon Monoxide.............................2-8, 2-27, 4-17
Care of
Safety Belts................................................5-93
CD, MP3 .......................................................3-60
Center Console Storage Area...........................2-33
Chains, Tire...................................................5-70
Charging System Light....................................3-25
Check
Engine Lamp..............................................3-29
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-97
2

Entry/Exit Lighting...........................................3-14
Event Data Recorders.....................................7-15
Extender, Safety Belt.......................................1-21
F
Filter
Engine Air Cleaner......................................5-21
Finish Damage...............................................5-97
Fixed Mast Antenna........................................3-81
Flashers, Hazard Warning.................................. 3-5
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-70
Fluid
Automatic Transmission................................5-22
Power Steering...........................................5-30
Windshield Washer......................................5-31
Fog Lamp
Fog ...........................................................3-13
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6
Driving for Better Economy............................. 4-2
Filling a Portable Fuel Container....................5-10
Filling the Tank............................................. 5-8
Fuels in Foreign Countries.............................. 5-7Fuel (cont.)
Gage .........................................................3-33
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
Low Warning Light.......................................3-34
Fuses
Floor Console Fuse Block.............................5-99
Fuses and Circuit Breakers...........................5-99
Underhood Fuse Block...............................5-101
G
Gage
Fuel..........................................................3-33
Speedometer..............................................3-21
Tachometer.................................................3-21
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-5
Glove Box.....................................................2-33
GM Mobility Reimbursement Program.................. 7-6
H
Hazard Warning Flashers................................... 3-5
Headlamp
Aiming .......................................................5-41
Headlamp Wiring............................................5-99
5

Light
Airbag Readiness........................................3-23
Antilock Brake System (ABS) Warning............3-26
Brake System Warning.................................3-25
Charging System.........................................3-25
Engine Coolant Temperature Warning.............3-28
Highbeam On.............................................3-33
Low Coolant Warning...................................3-28
Low Fuel Warning.......................................3-34
Oil Pressure...............................................3-32
Passenger Airbag Status Indicator..................3-24
Safety Belt Reminders..................................3-22
Security.....................................................3-32
Tire Pressure..............................................3-29
Trunk Ajar..................................................3-33
Lighting
Entry/Exit...................................................3-14
Lights............................................................3-12
Flash-to-Pass............................................... 3-7
High/Low Beam Changer................................ 3-7
On Reminder..............................................3-13
Limited-Slip Rear Axle.....................................4-10
Loading Your Vehicle.......................................4-20
Locks
Automatic Door Lock..................................... 2-7
Automatic Door Unlock.................................. 2-7
Delayed Locking........................................... 2-7
Manual Door................................................ 2-6
Power Door .................................................. 2-6Loss of Control...............................................4-12
Low Coolant Warning Light..............................3-28
Low Fuel Warning Light...................................3-34
Lower Anchors and Tethers for Children.............1-31
M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-9
At Least Once a Year.................................... 6-9
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-16
Maintenance Replacement Parts....................6-14
Maintenance Requirements............................. 6-2
Owner Checks and Services........................... 6-8
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using.......................................................... 6-3
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Lamp...............................3-29
Manual Seats................................................... 1-2
Manual Transmission
Fluid..........................................................5-23
Operation...................................................2-22
Manual Windows............................................2-11
7

Tire
Pressure Light.............................................3-29
Tire Sealant
Storing.......................................................5-89
Tires.............................................................5-47
Aluminum or Chrome-Plated Wheels,
Cleaning.................................................5-96
Buying New Tires........................................5-63
Chains.......................................................5-70
Cleaning....................................................5-96
Different Size..............................................5-65
If a Tire Goes Flat.......................................5-70
Ination - Tire Pressure................................5-53
Inspection and Rotation................................5-60
Pressure Monitor Operation...........................5-56
Pressure Monitor System..............................5-54
Tire Sealant and Compressor Kit...........5-71, 5-80
Tire Sidewall Labeling..................................5-49
Tire Terminology and Denitions....................5-50
Uniform Tire Quality Grading.........................5-65
Wheel Alignment and Tire Balance.................5-67
Wheel Replacement.....................................5-67
When It Is Time for New Tires......................5-62
Winter Tires................................................5-48
Towing
Recreational Vehicle.....................................4-25
Towing a Trailer..........................................4-25
Your Vehicle...............................................4-25Traction
Control System (TCS).................................... 4-8
Limited-Slip Rear Axle..................................4-10
Traction Control System...................................3-27
Transmission
Fluid, Automatic...........................................5-22
Fluid, Manual..............................................5-23
Transmission Operation, Automatic....................2-19
Transmission Operation, Manual........................2-22
Trunk.............................................................. 2-8
Trunk Ajar Light
..............................................3-33
Turn and Lane-Change Signals.......................... 3-7
Turn Signal/Multifunction Lever........................... 3-6
U
Uniform Tire Quality Grading............................5-65
V
Vehicle
Control........................................................ 4-3
Loading......................................................4-20
Parking Your...............................................2-26
Running While Parked..................................2-28
Symbols......................................................... iv
Vehicle Data Recording and Privacy..................7-15
11