oil PORSCHE 911 GT3 2010 5.G Service Manual

194
Practical Tips, Emergency Service E Maximum Load rating
The maximum load in kilograms and pounds can
be carried by the tire. If you replace tires always
use a tire that has the same maximum load rating
as the factory installed tire.
FRadial
The identification indicates if the tire has radial
structure.
G Term of tubeless or tube tire
Identification for tubeless tires.
Speed code letterThe speed code letter indicates the maximum
permissible speed for the tire.
This code letter is shown on the tire sidewall.Tip on driving
Tires with a maximum speed rating that is lower
than the specified maximum vehicle speed may be
mounted only if they bear an M+S identification on
the tire sidewall.
fPlease note that in addition to the winter tires,
all-season and all-terrain tires are also subject
to speed limits and bear this identification.
Inscription on light alloy wheelsMaintenance note
fProtect the valve inserts against soiling with
valve caps.
Use only plastic valve caps.
Soiled valve inserts can cause a gradual loss
of air.
Note on operation
fThe rim width in inches A and the rim offset F
are visible from the outside.
The information is provided on the rear of the
spokes. The rim width and rim offset are also
visible close to the tire valve in some cases.
A- Rim width in inches
B- Rim-flange contour code letter
C- Symbol for drop-center rim
D- Rim diameter in inches
E-Double hump
F- Rim offset in mm
T= up to 118 mph (190 km/h)
H= up to 131 mph (210 km/h)
V= up to 150 mph (240 km/h)
W= up to 167 mph (270 km/h)
Y= up to 186 mph (300 km/h)
(Y)= up to 186 mph (300 km/h) in accordance
with Y-tires. Speeds in excess of
186 mph (300 km/h) are possible with
a maximum load rating of 85 %
(confirmation of tire manufacturer in excess
of 186 mph (300 km/h) required).
10_GT3_21.book Seite 194 Donnerstag, 4. Juni 2009 12:48 12

204
Practical Tips, Emergency Service
A- Filler bottle
B- Filler hoseTire sealantThe tire sealant can be used to seal small cuts,
especially in the tire tread.
Sealing the tire with the tire sealant is only an
emergency repair, so you can drive to the next
workshop. Even with the tire air-tight, it may be
used only for short trips in an emergency.The tire sealant and a compressor with pressure
tester can be found in the luggage compartment.
The tire sealant comprises:
– A filler bottle
– A sticker denoting the maximum permissible
speed for the driver’s field of vision
– A filler hose
– A valve turner and
– A spare valve insert.
Danger!
Risk of accident, resulting in serious
personal injury or death.
fUse the tire sealant only in the case of cuts or
punctures no larger than 0.15 in. (4 mm).
fNever use the tire sealant if the rim is damaged.
Warning!
The sealant is highly flammable and harmful
to health.
fFire, open flame and smoking are prohibited
when handling tire sealant.
fAvoid contact with skin, eyes or clothing due to
caustic chemical properties of the tire sealant.
fKeep tire sealant away from children.
fDo not inhale vapors, due to consequent harm
to personal health resulting in serious personal injury or death.
In case of contact with the sealant:
fIf sealant gets on the skin or in the eyes,
thoroughly rinse the affected part of the body
off immediately.
fChange soiled clothing immediately.
fGet medical attention immediately in the event
of an allergic reaction.
fIf sealant was swallowed, thoroughly rinse out
the mouth without delay and drink plenty of
water.
Do not induce vomiting.
Get medical attention immediately.
10_GT3_21.book Seite 204 Donnerstag, 4. Juni 2009 12:48 12

Practical Tips, Emergency Service
219
Bulb chart
Ty p e , r a t i n g
Halogen low beam
H7, 55W
Low beam with Bi-Xenon headlight Philips, D2S 35W
Halogen high beam
H9, 65W
Additional high beam with Bi-Xenon headlight without cornering light H11, 55W
Additional high beam with Bi-Xenon headlight with cornering light
H7 LL, 55 W
Turn signal indicator light, side WY5W
License plate light
C5W
Lights, Replacing Bulbs
Warning!
Risk of short circuit.
fAlways switch off the relevant consumer when
changing bulbs.
Risk of serious personal injury or death.
The Bi-Xenon headlights are under high
voltage when installed.
fBe careful during all work in the area of the Bi-
Xenon headlights.
Risk of damage. Bulbs of a higher wattage
can damage the lamp housing.
fOnly the bulbs shown in the chart may be used.
fNew bulbs must be clean and free from oil,
grease and fingerprints. Therefore, never
touch bulbs with your bare hands.
Use a cloth or soft paper while replacing bulbs.
10_GT3_21.book Seite 219 Donnerstag, 4. Juni 2009 12:48 12

236
Technical Data
Technical DataEngine data Ty p e M 9 7 / 7 7
Horizontally opposed engine,
liquid cooled
Number of cylinders 6
Bore 4.04 in./102.7 mm
Stroke 3.01 in./76.4 mm
Cubic capacity 231.6 cu. in./3797 cm
3
Net-horsepower 435 hp/320 kW
at crankshaft speed 7600 rpm
Net torque 317 ft. lb./430 Nm
at crankshaft speed 6250 rpm
Engine oil consumption up to 1.5 liters/1000 km
(1.6 quarts/622 miles)
Maximum permitted engine speed 8500 rpm
Engine control Stationary high-voltage distribution, sequential injection,
cylinder-selective knock-control, stereo oxygen sensor closed-loop control, diagnostic system,
4 overhead camshafts, Porsche VarioCam, hydraulic valve clearance compensation
10_GT3_21.book Seite 236 Donnerstag, 4. Juni 2009 12:48 12

Technical Data
239
CapacitiesUse only fluids and fuels authorized by Porsche. Your authorized Porsche dealer will gladly advise you.
Your Porsche has been designed so that it is not necessary to mix any additives with oils or fuels.
EngineOil change quantity without oil filter approx. 9.25 quarts / 8.75 liters
Oil change quantity with oil filter approx. 9.5 quarts / 9 liters
Please see the chapter “ENGINE OIL” on Page 159.
Coolantapprox. 7.9 U.S. gallons / 30 liters
Manual transmission
and differential
approx. 3.5 quarts / 3.3 liters transmission oil SAE 75W-90, Mobilube PTX
Fuel tank approx. 17.7 U.S. gallons / 67 liters
Fuel qualityYour engine is designed to provide optimum performance and fuel economy using
unleaded premium fuel with an octane rating of 98 RON (93 CLC or AKI).
Porsche therefore recommends the use of these fuels in your vehicle.
Porsche also recognizes that these fuels may not always be available. Be assured that your vehicle
will operate properly on unleaded premium fuels with octane numbers of at least 95 RON (90 CLC or AKI),
since the engine’s “Electronic Octane™ knock control” will adapt the ignition timing, if necessary.
Power steeringapprox. 1.35 quarts / 1.27 liter hydraulic fluid Pentosin CHF 11 S
® or Pentosin CHF 202
®
Brake fluid0.67 quarts / 0.63 liters; use only Original Porsche brake fluid.
Windshield washerapprox. 2.6 quarts / 2,5 liters without headlight washer
approx. 6.3 quarts / 6 liters with headlight washer
10_GT3_21.book Seite 239 Donnerstag, 4. Juni 2009 12:48 12

244
Index Brake fluid
Changing............................................ 163
Checking level .................................... 162
Level.................................................. 162
Warning light ...................................... 163
Brakes ....................................................... 162
Brake circuit division warning light ........ 163
Brake warning light ............................. 116
Fluid........................................... 162, 239
Fluid warning light ............................... 163
Function ............................................... 54
New brake pads or linings ..................... 56
Pads .................................................... 13
Parking brake ....................................... 53
Porsche Ceramic Composite Brake
(PCCB) ................................................... 6
Service brake ......................................... 6
Test stand ............................................ 61
Break in brakes ............................................ 13
Break in hints ............................................... 13
Bulbs, replacing.......................................... 219
CCapacities .................................................. 239
Car care .................................................... 174
Car telephone ............................................... 91
Car washes ................................................ 175
Carpet ....................................................... 180
Catalytic converters .................................... 169
Cautions ............................................ 157, 183Central locking...................................... 22, 208
Automatic relocking............................... 22
Emergency operation ............................ 23
Fault indication ...................................... 24
Overload protection....................... 24, 208
Central locking button................................... 24
Central vents .............................................. 101
Central warning light ................................... 116
Changing bulb............................................. 227
Check engine
Warning light....................................... 116
Check engine warning light .......................... 116
Opening the oil filler cap ...................... 161
Checking pressure ...................................... 203
Child restraint systems .................................. 47
Anchorages .......................................... 52
Direction of installation .......................... 48
Child seat bracket ......................................... 51
Chime .......................................................... 73
CHRONO Stopwatch .................................... 127
Cigarette lighter ............................................ 82
Circulating-air button..................................... 99
Clock ................................................. 114, 146
Clothes hook ................................................ 83
Clutch .................................................. 53, 155
Clutch pedal ................................................. 53
Combination filter........................................ 172
Coming home mode ...................................... 74
Communication management ......................... 89
Compact disc
Player .................................................. 90
Storage ................................................ 84
Compartment monitoring ............................... 26
Compressor .................................................87
Coolant ..............................................112, 158
Checking ............................................158
Level ..................................................158
Temperature gauge .............................112
Topping off .........................................158
Warning light .......................................112
Cooling system ...................................112, 158
Warning light .......................................112
Cornering light
Functional description ............................74
Indicator light ......................................111
Crankcase ventilation ..................................169
Cruise control .................................78, 79, 115
Cupholder.....................................................80DData bank ...................................................234
Daytime running lights ...................................73
Changing bulbs ...................................227
On-board computer .............................146
Decals........................................................175
Defrosting windows .................................32, 99
Diagnostic socket .........................................14
Diagram
Engine diagram ...................................242
Dimensions.................................................241
Door ............................................................21
Handles ................................................21
Locks ...........................................21, 176
Mirror ...................................................31
Mirror heating .......................................32
Mirrors .................................................30
Windows .................................21, 29, 177
10_GT3_21.book Seite 244 Donnerstag, 4. Juni 2009 12:48 12

Index
245
Driving
Hints .................................................... 11
Driving performance ................................... 240
Drop-center rim .......................................... 194
Dynamic cornering light
Functional description............................ 74
Dynamic engine mounting.............................. 63EElectrical system ........................................ 207
Emergency flasher switch.............................. 72
Emergency operation
Central locking...................................... 23
Ignition key ........................................... 69
Lids ................................................... 210
Tank flap ............................................ 165
Emergency service ..................................... 183
Emergency starting with jumper cables 217, 218
Emission control system ............. 116, 168, 169
Engine
Checking the oil level........................... 143
Exhaust .................................................. 8
Number .............................................. 235
Oil consumption ............................ 13, 159
Oil level .............................................. 160
Oil level indicator................................ 143
Oil pressure ........................................ 115
Oil temperature................................... 108
Oils ............................................ 159, 239
Speeds ........................................ 13, 240
Starting ................................................ 70
Stopping .............................................. 71Engine compartment
Blower .........................................71, 112
Blower fan ..........................................112
Care...................................................177
Lid .................................................85, 86
Lid warning light ....................................85
Engine oil
Choosing the right oil ..........................160
Consumption ........................................13
Topping off .........................................160
Viscosity.............................................160
Exhaust
Pipes .....................................................8
Tailpipes, stainless steel ......................178
External antenna ...........................................91
External audio source, AUX ............................93
FFiller flap ....................................................165
Filling pressure, tire.....................................237
Fire extinguisher ...........................................94
Flat tire ......................................................203
Floor mats ..................................................180
Fluids and fuels ...........................................239
FM reception ................................................89
Fog light, rear ...............................................73
Footbrake.....................................................54
Fresh air intake ...........................................101
Front axle lift system
Functional description ............................64
Lowering front axle................................65
Raise front axle .....................................64
Front lid .................................................85, 86Fuel................................................... 113, 165
Containers ..................................... 7, 167
Economy ........................................... 164
Evaporation control ............................ 167
Fuels containing ethanol ...................... 167
Level gauge ....................................... 113
Level warning light.............................. 113
Recommendation ....................... 166, 167
Recommendations.............................. 166
Tank.................................................. 166
Fuses, replacing......................................... 209
GGarage
Door ................................................... 71
Door opener ........................................ 95
Lift .................................................... 206
Glove compartment ...................................... 84
Gong ....................................... 17, 68, 73, 120
Ground clearance ........................................... 8HHalogen headlights
Changing bulb for low beam ................ 222
Handbrake ................................................... 53
Head restraints ............................................ 33
Headlights ................................................. 220
Adjusting ................................... 228, 229
Beam adjustment ................................. 74
Cleaning system ................... 76, 170, 239
Flasher ................................................ 75
Heated rear window..................................... 32
Heated rear window/Door mirror heating ..... 102
10_GT3_21.book Seite 245 Donnerstag, 4. Juni 2009 12:48 12

Index
247
OOctane rating ..................................... 166, 167
Odometer .................................................. 109
Off delay ...................................................... 74
Oil ............................................................. 159
Checking level .................................... 143
Choosing the right oil .......................... 160
Consumption ........................................ 13
Level checks ...................................... 160
Level indicator .................................... 143
Pressure ............................................ 115
Temperature....................................... 108
Topping off engine oil .......................... 160
OIL Display and measurement of the
engine oil level ............................................ 143
On-board computer ..................................... 117
Basic settings ............................. 118, 145
Calling on-board computer functions ..... 118
Functions and display possibilities ........ 118
General information ..................... 146, 147
Language versions .............................. 145
Operation, controls ............................. 117
Selecting a radio station ...................... 133
Setting the clock ................................. 146
Switching daytime running lights on/off. 146
Switching on navigation ....................... 133
Tire pressure warnings ........................ 139
Warnings and messages...................... 148
On-board literature .......................................... 2
Operating voice control ............................... 117
Operating your Porsche in other Countries .... 164
Orientation light ............................................ 66
Outside temperatur indicator ....................... 114
Oxygen sensor ........................................... 169
PPaint
Care...........................................174, 176
Data ...................................................235
Parking brake ...............................................53
Warning light.........................................54
Parking light ...........................................73, 75
Particle filter ...............................................172
Passenger compartment monitoring ...............26
Pen holder ....................................................84
Plastic parts ...............................................179
Care...................................................179
Platform lift.................................................206
Porsche Active Suspension Management
(PASM) .........................................................63
Sport mode ..........................................63
Switching off Sport mode ......................63
Porsche Ceramic Composite Brake (PCCB) .......6
Porsche Communication Management (PCM)...89
Porsche Stability Management (PSM) ..............59
Information light ....................................61
Power steering fluid level .....................171, 239
Power windows .............................................21
Practical tips ..............................................183
Putting vehicle into operation .......................213RRadiator fan..........................................71, 159
Radio reception ............................................89
Rain sensor ............................................76, 77
Range on remaining fuel ......................118, 147
Reading light ................................................66
Rear lid ..................................................85, 86
Rear view mirrors..........................................31Rear window defogger.......................... 32, 102
Rear window heating.................................. 102
Recirculating-air button ................................. 99
Refueling ................................................... 166
Relays ....................................................... 207
Remote control ............................................ 19
Readiness ............................................ 20
Replacing battery ............................... 216
Standby funktion .................................. 20
Synchronization.................................... 20
Replacement key.......................................... 18
Replacing bulbs.......................................... 219
Replacing wiper blades............................... 173
Rims
Diameter ........................................... 194
Rim width........................................... 194
TPM sensors...................................... 190
Running in.................................................... 13
SSafety belts ................................................. 38
Cleaning ............................................ 180
Height adjustment................................ 40
Tensioner ............................................ 38
Warning light ........................................ 39
Safety compliance sticker ........................... 234
SC OFF button ............................................. 60
SC+TC OFF button ....................................... 61
Sealing set ................................................ 204
Seals ........................................................ 179
Care .................................................. 179
10_GT3_21.book Seite 247 Donnerstag, 4. Juni 2009 12:48 12

Index
249
Towing lug ................................................... 87
TPM Tire pressure monitoring ...................... 134
Tracks ....................................................... 238
Traction Control (TC)..................................... 61
Transmission .............................................. 237
Drive-Off Assistant............................... 155
Fluid........................................... 172, 239
Manual transmission............................ 155
Porsche Doppelkupplung (PDK) ............ 155
Trip Odometer ............................................ 109
Trunk entrapment ......................................... 88
Turn signal
Indicator light...................................... 111
Turn signals ......................................... 75, 111
Turn signals, front....................................... 227UUndercoating...................................... 168, 178
Upshift indicator ................................. 111, 155
USB interface ............................................... 93
VValves ........................................................189
Vanity mirror.................................................37
Vehicle
Care...................................................174
Engine number....................................235
Identification .......................................234
Identification label ...............................234
Identification number ...........................234
Lifting.................................................206
Load capacity .....................................196
Putting into operation ..........................213
Safety compliance sticker ....................234
Washing .............................................175
Vehicle identification number ........................234
Ventilation ....................................................98
Vents ...................................................98, 101
Viscosity, engine oil.....................................160
Voice control, button ...................................117
Voice control, PCM .....................................117
WWarning lights and messages ...................... 148
Washer
Fluid .......................................... 170, 239
Fluid warning light............................... 170
Lever................................................... 76
Washing .................................................... 175
Weights ..................................................... 240
Welcome Home Function .............................. 74
Wheel .......................................... 13, 184, 238
Alignment .......................................... 190
Balancing........................................... 190
Care .................................................. 184
Central bolts ...................................... 197
Changing ................................... 198, 203
Checking pressure............................. 203
Inscription .......................................... 193
Loading information ............................ 195
Security wheel bolts ............................. 87
Sidewall ............................................. 193
Size .................................................. 193
Tire pressure ............................. 185, 237
Tire pressure plate ............................. 235
Tire sealant ................................ 203, 204
Wheels
Care .................................................. 178
Central bolts ...................................... 197
Tightening torque ............................... 197
TPM sensors...................................... 190
10_GT3_21.book Seite 249 Donnerstag, 4. Juni 2009 12:48 12

250
Index Windows .................................................... 177
Anti-crushing protection ......................... 29
Care .................................................. 177
Opening/Closing ................................... 29
Washer nozzles .................................... 76
Washer system ..................... 76, 170, 239
Windshield
Washer nozzles .................................... 76
Wiper blades, changing ....................... 173
Wiper/washer lever ............................... 76
Windshield wipers ................................. 76, 173
Replacing ........................................... 173
Winter operation
Battery ............................................... 213
Coolant .............................................. 158
Engine oil ........................................... 159
Jumper cables ............................ 217, 218
Locks ................................................ 176
Seals ................................................. 179
Snow chains ....................................... 192
Tires .......................................... 191, 238
Washer fluid ....................................... 170
Wiper blades ...................................... 173
Wiper
Blades ............................................... 173
Lever ................................................... 76
Wiper blades
Care .................................................. 177
Changing............................................ 173
10_GT3_21.book Seite 250 Donnerstag, 4. Juni 2009 12:48 12