engine PORSCHE BOXSTER 2006 2.G Owners Manual

Practical Tips, Emergency Service
253
Removing the batteryThe battery is located in the luggage compart-
ment under a black plastic lid.
1. Switch off engine and all electrical loads.
2. Open turn-locks A.
Remove plastic lid.
Warning!
Risk of damage to generator and electronic
control units.
fDo not disconnect battery while the engine is
running.
Risk of caustic burns from escaping acid.
fDo not tilt the battery when removing it.
3. Pull off vent hose C.
4. Important: disconnect the negative lead first,
and then the positive lead – danger of short
circuit!
5. Unscrew fastening screw B.
6. Remove battery.

256
Practical Tips, Emergency Service
Jump lead startingfPlease observe the chapter “EMERGENCY
UNLOCKING OF THE FRONT LUGGAGE
COMPARTMENT LID” on Page 248.
fPlease observe the chapter “BATTERY” on
Page 249.
If the battery is flat, the battery of another vehicle
can be used to start the car with the aid of jump
leads.
Both batteries must be 12 volt types. The
capacity (Ampere hours, Ah) of the donor battery
must not be substantially less than that of the
discharged battery.
The discharged battery must be correctly
connected to the vehicle’s electrical system.
Warning!
Risk of damage and injury due to short
circuit.
fUse only standard jump leads with sufficient
cross section and completely insulated
clamps.
Follow the jump lead manufacturer’s instruc-
tions.
fRoute the jump leads so that they cannot be
caught by moving parts in the engine compart-
ment.
The vehicles must not be in contact, otherwise
current might flow as soon as the positive
terminals are connected.
fCarefully ensure that conductive jewellery
(rings, chains, watch straps) do not come into
contact with live parts of the vehicle.
Danger of caustic burns.
fDo not lean over the battery.
Danger of gas explosion.
fKeep sources of ignition, e.g. naked flame,
burning cigarettes or sparks due to cable
contact, away from the battery.
fBefore connecting jump leads, it is essential to thaw out a frozen battery.
Connecting jump leadsAlways observe the sequence below:
1. Connect the red positive lead to the positive
terminal of the discharged battery first, then
connect it to the positive terminal of the donor
battery.
2. First connect the black negative cable to the
negative terminal of the donor battery, then
connect it to a suitable grounding point on the
vehicle with the discharged battery.
This grounding point must lie as far as possible
from the battery.
For example, a solid metal part or the engine
block are suitable grounding points.
If no suitable grounding points are to be found
on either vehicle, the negative cable must
carefully be connected directly to the negative
terminal of the battery.
If a suitable grounding point is to be found only
on the donor vehicle, the negative cable must
first be connected to the terminal of the
discharged battery, then to the grounding point
of the donor vehicle.

Practical Tips, Emergency Service
257
3. Run the engine of the donor car at a higher
speed.
4. Start the engine.
An attempted start using jump leads should
not last more than 15 seconds. Then allow a
waiting period of at least one minute.
5.Note
Before disconnecting the jump leads, electrical
loads such as the heated rear window and the
heating fan blower should be switched on (the
vehicle’s lights must not be switched on). This
reduces voltage peaks which may occur when
disconnecting the jump leads.
With the engine running, remove both jump
leads in reverse order.

278
Vehicle Identification, Technical Data
Vehicle IdentificationWhen ordering spare parts or making inquiries,
please always quote the vehicle identification num-
ber. Vehicle data bankThe vehicle data bank is attached to the inside of
the ”Maintenance“ booklet.
It contains all important data about your car.
Note
This data bank cannot be re-ordered if it is lost or
damaged.
This label contains the following information:
1. Vehicle Identification No.
2. Type/Type description
3. Engine code/Transmission code
4. Paint No./Interior
Vehicle identification number In accordance with Federal Safety Regulations,
the vehicle identification number of your car is lo-
cated at the bottom left of the windshield frame
and can be seen from the outside.
The vehicle identification number is in the front lug-
gage compartment under the battery cover and at
the bottom left behind the windshield.
Removing the battery cover
fPlease observe the chapter “BATTERY” on
Page 249.
Safety compliance sticker The safety compliance sticker is your assurance
that your new Porsche complies with all applicable
Federal Motor Vehicle Safety Standards which
were in effect at the time the vehicle was manuf-
actured.
The sticker also shows the month and year of pro-
duction and the vehicle identification number of
your car (perforations) as well as the Gross Vehic-
le Weight Rating and the Gross Axle Weight Ra-
ting.

Vehicle Identification, Technical Data
279
Tire pressure plateThe tire pressure plate is attached to the left-hand
door aperture.
Engine number The engine number is stamped on the underside
of the crankcase.

280
Vehicle Identification, Technical Data
Technical DataEngine data
Boxster Boxster S
Type M 96/25 M 96/26
Horizontally opposed engine, liquid cooledHorizontally opposed engine, liquid cooled
Number of cylinders 6 6
Bore 3.37 in./85.5 mm 3.66 in./93 mm
Stroke 3.07 in./78 mm 3.07 in./78 mm
Cubic capacity 163.96 cu. in./2687 cm
3 193.98 cu. in./3179 cm
3
Net-horsepower, SAE J 1349 240 hp/176 kW 280 hp/206 kW
at crankshaft speed 6400 rpm 6200 rpm
Net torque, SAE J 1349 199 ft. lb./270 Nm 236 ft. lb./320 Nm
at crankshaft speed 4700 - 6000 rpm 4700 - 6000rpm
Alternator 2100 W 2100 W
Firing order 1 - 6 - 2 - 4 - 3 - 5 1 - 6 - 2 - 4 - 3 - 5
Engine control Stationary high-voltage distribution, sequential injection,
cylinder-selective knock-control, stereo oxygen sensor closed-loop control, diagnostic system,
4 overhead camshafts, Porsche VarioCam, hydraulic valve clearance compensation

286
Vehicle Identification, Technical Data
Capacities Use only fluids and fuels authorized by Porsche. Your authorized Porsche dealer will gladly advise you.
Your Porsche has been designed so that it is not necessary to mix any additives with oils or fuels.
EngineOil change quantity without oil filter approx. 1.98 U.S.gallons/7.5liters
Oil change quantity with oil filter approx. 2.05 U.S.gallons/7.75 liters
Please observe the chapter “ENGINE OIL RECOMMENDATION” on Page 190.
Coolant Boxster
Manual transmission: approx. 5.81 U.S. gallons/22 liters
Tiptronic S: approx. 6.34 U.S. gallons/24 liters
Boxster S
Manual transmission: approx. 5.89 U.S. gallons/22.3 liters
Tiptronic S: approx. 6.42 U.S. gallons/24.3 liters
Manual transmission and differential 5-speed: approx. 2.4 quarts/2.25 liters, 6-speed: approx. 3 quarts/2.8 liters
Tiptronic Sapprox. 2.51 U.S. gallons/9.5 liters
Differential with Tiptronic Sapprox. 0.21 U.S. gallons/0.8 liters
Power steeringapprox. 1.1 quarts/1 liter hydraulic fluid Pentosin CHF 11 S
®
Brake fluidapprox. 0.4 quarts/0.39 liters; use only Original Porsche brake fluid
Windshield washerapprox. 0.66 U.S. gallons/2.5 liters without headlight washer
approx. 1.59 U.S. gallons/6 liters with headlight washer
Fuel tankRefill volume approx. 16.9 U.S. gallons/64 liters, including approx. 2.6 U.S.gallons/10 liters reserve.
Fuel qualityYour engine is designed to provide optimum performance and fuel economy using unleaded premium fuel with
an octane rating of 98 RON (93 CLC or AKI).
Porsche therefore recommends the use of these fuels in your vehicle.
Porsche also recognizes that these fuels may not always be available. Be assured that your vehicle will operate
properly on unleaded premium fuels with octane numbers of at least 95 RON (90 CLC or AKI), since the engine’s
“Electronic Oktane™ knock control” will adapt the ignition timing, if necessary.

288Diagrams Acceleration diagram
Values have been determined at DIN empty
weight and with a 50 % load without
additional equipment.
Transmission diagram
The transmission diagram is based on
standard values on the basis of a mean
effective scrub radius. Changes of the scrub
radius, the tire tolerance, wear and tear,
deviating country equipment and tire slip
have not been taken into account.
Boxster S: Engine diagram at full power

289
Boxster: Engine diagram at full power

292
Index
IndexAABS (antilock brake system) .......................... 61
Advanced Airbag........................................... 46
Air conditioning ...................................130
, 133
Air distribution ....................................130, 133
Air filter ...................................................... 208
Airbag .......................................................... 44
Function ............................................... 46
Warning light ........................................ 49
Air-conditioning compressor ................132, 135
Alarm system ............................................. 157
Alcantara ................................................... 217
Antenna .............................................157, 212
Antilock brake system................................... 61
Warning light ........................................ 62
Ashtray ...................................................... 138
Assembly aids for wheel changes................. 242
Assistant ...................................................... 70
Audio operation .......................................... 155
Auto-button air conditioning ......................... 133
Automatic
Anti-glare mirrors .................................. 30
Car washes ........................................ 210
Door locking ......................................... 24
Headlight beam adjustment.................. 125
Speed control ....................................... 82
Automatic air conditioning system ................ 133
Average consumption............................93, 114
Average speed .....................................93, 114
BBackrest
Adjustment ........................................... 34
Release ................................................ 34
Battery....................................................... 249
Care .................................................. 250
Charge state....................................... 250
Putting vehicle into operation ............... 252
Remote control ................................... 255
Removing ........................................... 253
Warning light......................................... 90
Winter driving...................................... 251
Before driving off ....................................12
, 13
Blower adjustment..............................130, 133
Brake light..........................................269, 270
Brakes
Brake pad warning light ......................... 91
Fluid ...........................................192, 286
Fluid warning light.......................109, 192
Pads ..............................................14, 60
Test stand ............................................ 66
Break in hints................................................ 14
Bulbs
Chart ................................................. 259
Replacing ........................................... 259
CCabriolet .................................................... 170
Canholder .................................................. 144
Capacities, overview ................................... 286Car care ..................................................... 184
Car telephone ............................................. 157
Car washes ................................................ 210
Catalytic converters ....................................201
Cautions............................................ 184
, 220
Central locking....................................... 19, 21
Emergency operation ..................... 19, 22
Central vents .............................................. 136
Central warning light..................................... 91
Changing wheels ......................................... 242
Check engine
Warning light......................................... 90
Checking pressure ...................................... 241
Child restraint systems .................................. 51
Chime ........................................................ 124
CHRONO stopwatch ......................................98
Circulating-air button .......................... 130, 133
Clock .................................................. 89, 114
Clutch ........................................................ 162
Clutch pedal ................................................. 56
Combination filter ........................................208
Comfort seat ................................................ 34
Coming Home mode ................................... 124
Compact disc
holder ................................................ 143
Player ................................................ 156
Storage .............................................. 152
Convertible top ........................................... 170
Care................................................... 211
Coolant ....................................... 86
, 186
, 286
Level .................................................. 186
Temperature gauge............................... 86