remote control Ram 1500 2011 User Guide
[x] Cancel search | Manufacturer: RAM, Model Year: 2011, Model line: 1500, Model: Ram 1500 2011Pages: 636, PDF Size: 4.88 MB
Page 375 of 636
1.Motor: The winch motor is powered by the vehicle
charging system and features a thermal protection switch
that automatically stops motor function in the power-in
direction if the motor gets too hot.
2. Remote Socket: The remote socket allows the remote
control to be attached to the control pack to allow the
winch to function.
3. Winch Drum With Integral Brake: The winch drum
allows the wire rope to be stored on the winch and
transmits force to the wire rope. The winch is equipped
with an integral brake that will stop rotation of the winch
drum if the winch motor is stopped.
4. 3-Stage Planetary Gear Set: Provides balance between
speed and pulling power.
5. Wire Rope: The wire rope allows the winch to be
connected to an anchor to provide a pulling force. 6.
Clutch Lever: The clutch lever allows the winch drum
to be disconnected from the winch motor to allow the
wire rope to be pulled from the winch by hand.
7. Remote Control: The remote control provides the
interface between the winch operator and the winch. The
remote control provides the ability to power the winch in,
out, and stop the winch. To operate the winch, the toggle
switch is pressed down to power the winch in and up to
power the winch out. The winch will stop if the switch is
left in the neutral (center) position.
CAUTION!
If not installed, the hook strap must be placed on the
hook.
Fairlead: The fairlead acts as a guide for the wire rope
and minimizes damage to the rope.
5
STARTING AND OPERATING 373
Page 378 of 636
WARNING! (Continued)
•Always stand clear of wire rope and load and keep
others away during winching.
•Always keep hands and clothing clear of the wire
rope, hook and fairlead opening during operation
and when spooling.
•Never wrap wire rope back onto itself. Always use
a choker chain, wire choker rope or tree trunk
protector on the anchor.
•Never attach a recovery strap to the winch hook to
increase the length of a pull.
•Never attempt to tow a vehicle with the recovery
strap attached directly to the winch hook.
•Never usebungeestraps that develop tremen-
dous and potentially dangerous amounts of force
when stretched.
(Continued)
WARNING! (Continued)
•Always disconnect the remote control when not in
use.
•Never winch when there are less than five wraps
of wire rope around the winch drum.
•Always pass remote control through a window to
avoid pinching lead in door, then using remote
inside a vehicle.
•Never leave the remote control plugged into the
winch while free spooling, rigging or sitting idle.
376 STARTING AND OPERATING
Page 379 of 636
General Information
Practice using your winch before you get stuck. Some key
points to remember when using your winch are:
1. Always take your time to assess the situation and plan
your pull carefully.
2. Always take your time when using a winch.
3. Use the right equipment for the situation.
4. Always wear leather gloves and do not allow the wire
rope to slip through your hands when handling the rope.
5. Only the operator should handle the wire rope and
remote control.
6. Think safety at all times.
Vehicle Recovery Using The Winch
CAUTION!
•Always Know Your Winch: Take the time to fully
read and understand the included Installation and
Operations Guide, and Basic Guide to Winching
Techniques, in order to understand your winch
and the winching operation.
•Always inspect winch installation and wire rope
condition before operating the winch. Frayed,
kinked or damaged wire rope must be replaced
immediately. Loose or damaged winch installation
must be corrected immediately.
•Always be sure any element which can interfere
with safe winching operations is removed prior to
initiating winching.
•Always keep remote control lead clear of the
drum, wire rope and rigging.(Continued)
5
STARTING AND OPERATING 377
Page 384 of 636
NOTE:Always ensure the clutch is fully engaged or
disengaged.
9. Connect the remote control to the winch control box,
located behind the front bumper. Be careful not to let the
remote control cord dangle in front of the winch. If you
choose to control the winch from inside your vehicle,
always pass the remote through a window to avoid
pinching the cord in the door. Always disconnect the
remote control when not in use.
10. Put wire rope under tension. Using the remote con-
trol switch, slowly wind the wire rope until no slack
remains. Once the wire rope is under tension, stand well
clear of it and never step over it.
382 STARTING AND OPERATING
Page 387 of 636
For additional assistance, the winched vehicle can be
slowly driven while being pulled by the winch. Continue
pulling until the vehicle is on stable ground. If you are
able to drive the vehicle, the winching operation is
complete.NOTE:
•Avoid overheating the winch motor. For extended
winching, stop at reasonable intervals to allow the
winch motor to cool down.
•What to look for under load:
The wire rope must
always spool onto the drum as indicated by the drum
rotation decal on the winch. As you power-in, make
sure the wire rope winds evenly and tightly on the
drum. This prevents the outer wire wraps from draw-
ing into the inner wraps, binding and damaging the
wire rope. Avoid shock loads by using the control
switch intermittently to take up wire rope slack. Shock
loads can momentarily far exceed the winch and wire
rope ratings. During side pulls the wire rope tends to
stack up at one end of the drum. This stack can become
large enough to cause serious damage to the winch.
So, line up pulls as straight ahead as possible and stop
winching if the wire rope comes close to the tie rods or
mounting plate. To fix an uneven stack, spool out that
Using The Remote Control
5
STARTING AND OPERATING 385
Page 388 of 636
section of the rope and reposition it to the opposite end
of the drum, which will free up space for continued
winching.
16. Secure vehicle. Once recovery of the vehicle’s is
complete, be sure to secure the vehicle’s brakes and put
the transmission in PARK. Release tension in the wire
rope.
17. Disconnect the wire rope, and disconnect from the
anchor.
18. Rewind the wire rope. The person handling the wire
rope should walk the rope in and not let it slide through
the hand, control the winch at all times.
WARNING!
To prevent serious injury, NEVER put your fingers
inside the hook area as you are powering-in.
NOTE: How to spool under no load: Arrange the
remote control lead so it cannot be caught in the winch.
386 STARTING AND OPERATING
Page 389 of 636
Arrange the wire rope so it will not kink or tangle when
spooled. Be sure any wire rope already on the spooling
drum is wound tightly and evenly layered. Tighten and
straighten the layer if necessary. Keep the wire rope
under light tension and spool the wire rope back and
onto the winch drum in even layers. Stop frequently to
tighten and straighten the layers as necessary. Repeat this
process until the winch hook is the same distance as the
full length of the remote control from the winch. Pinch
the hook between your thumb and forefinger and attach
the hook strap. Hold the hook strap between the thumb
and forefinger to keep tension on the wire rope. Walk the
wire rope towards the fairlead, carefully spooling in the
remaining wire rope. By pulsing the remote control
switch.
19. Store the hook on the most outboard loop of the tow
hook.20. Disconnect the remote control. Disconnect the remote
control cord from the control box and store in a clean and
dry place. Winching operations are now complete. Put
the cap on the solenoid plug-in.
NOTE:
Always store the remote control in a protected,
clean, dry area.
5
STARTING AND OPERATING 387
Page 629 of 636
Reclining Rear Seats...................... 110
Recorder, Event Data ...................... 66
Recreational Towing ...................... 478
Shifting into Transfer Case Neutral(N) . . . 481,483
Shifting out of Transfer Case
Neutral (N) ...................... 482,486
Reformulated Gasoline .................... 444
Refrigerant ............................ 539
Reminder, Seat Belt ....................... 51
Remote Control Starting System ....................... 26
Remote Keyless Entry (RKE) ................. 20
Remote Sound System (Radio) Controls ........ 288
Remote Starting System .................... 26
Replacement Keys ........................ 17
Replacement Parts ....................... 531
Replacement Tires ....................... 423
Reporting Safety Defects ................... 608
Resetting Oil Change Indicator ...........217,235Restraint, Head
......................... 114
Restraints, Child ....................... 67,74
Restraints, Occupant ...................... 38
Rotation, Tires .......................... 428
Safety Checks Inside Vehicle ................. 83
Safety Checks Outside Vehicle ............... 85
Safety Defects, Reporting .................. 608
Safety Information, Tire ................... 406
Safety Tips ............................. 82
Safety, Exhaust Gas ....................... 82
Satellite Radio Antenna ................... 271
Schedule, Maintenance .................... 586
Seat Belt Maintenance .................... 562
Seat Belt Reminder ....................... 51
Seat Belts .......................... 38,39,83
Adjustable Upper Shoulder Anchorage ...... 47
And Pregnant Women .................. 52
Child Restraint ..................... 67,70
10
INDEX 627
Page 631 of 636
Sliding Rear WindowPower ............................ 181
Snow Chains (Tire Chains) ................. 425
Snow Plow ............................ 474
Snow Tires ............................ 427
Spare Tire .......................... 419,420
Spark Plugs ............................ 582
Speed Control (Cruise Control) .............. 134
Speedometer ........................... 211
Stabilizer/Sway Bar System ................ 344
Starting ............................. 26,309
Automatic Transmission ................ 309
Cold Weather ....................... 310
Engine Fails to Start .................. 310
Remote ............................ 26
Starting Procedures (Gas Engines) ............ 309
Steering Power .......................... 390,391
Wheel, Heated ...................... 132 Wheel, Tilt
......................... 131
Steering Wheel Audio Controls .............. 288
Steering Wheel Mounted Sound System
Controls .............................. 288
Storage Compartment, Center Seat ........... 174
Storage, Vehicle ...................... 301,569
Storing Your Vehicle ...................... 569
Sun Roof .............................. 158
Supplemental Tire Pressure Information ........ 424
Sway Control, Trailer ..................... 405
Synthetic Engine Oil ...................... 535
System, Remote Starting .................... 26
Tachometer ............................ 210
Tailgate ............................... 198
Temperature Control, Automatic (ATC) ........ 295
Temperature Gauge, Engine Coolant .......... 210
Tether Anchor, Child Restraint .............72,76
Tilt Steering Column ..................... 131
10
INDEX 629