engin light Ram 1500 2016 Manual Online

2. As soon as you cycle the ignition switch to the ON
position, you will see the Malfunction Indicator Light
(MIL) symbol come on as part of a normal bulb check.
3. Approximately 15 seconds later, one of two things will
happen:
•The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn OFF
the ignition or start the engine. This means that your
vehicle’s OBD II system isnot readyand you should
notproceed to the I/M station.
•The MIL will not flash at all and will remain fully
illuminated until you place the ignition in the off
position or start the engine. This means that your
vehicle’s OBD II system isreadyand you can proceed
to the I/M station.
If your OBD II system isnot ready,you should see your
authorized dealer or repair facility. If your vehicle wasrecently serviced or had a battery failure or replacement,
you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD II
system to update. A recheck with the above test routine
may then indicate that the system isnow ready.
Regardless of whether your vehicle’s OBD II system is
ready or not, if the MIL is illuminated during normal
vehicle operation you should have your vehicle serviced
before going to the I/M station. The I/M station can fail
your vehicle because the MIL is on with the engine
running.
REPLACEMENT PARTS
Use of genuine MOPAR parts for normal/scheduled
maintenance and repairs is highly recommended to en-
sure the designed performance. Damage or failures
caused by the use of non-MOPAR parts for maintenance
and repairs will not be covered by the New Vehicle
Limited Warranty.
7
MAINTAINING YOUR VEHICLE 793

Cavity Cartridge Fuse Micro Fuse Description
F11 30 Amp Pink – Integrated Trailer Brake Module – If Equipped
F12 40 Amp Green – Body Controller #3 / Interior Lights
F13 40 Amp Green – Blower Motor
F14 40 Amp Green – Body Controller #4 / Power Locks
F16 30 Amp Pink – Smart Bar – If Equipped
F19 20 Amp Blue (1500
LD Diesel)
30 Amp Pink (Cum-
mins Diesel)– SCR – If Equipped
F20 30 Amp Pink – Passenger Door Module
F21 30 Amp Pink – Drive Train Control Module
F22 20 Amp Blue
30 Amp Pink (Cum-
mins Diesel)– Engine Control Module
F23 30 Amp Pink – Body Controller #1
7
MAINTAINING YOUR VEHICLE 841

Cavity Cartridge Fuse Micro Fuse Description
F69 – 15 Amp Blue Mod SCR 12V (Cummins Diesel) – If Equipped
F70 – 30 Amp Green Fuel Pump Motor
F71 – 25 Amp Clear Amplifier
F72 – 10 Amp Red PCM – If Equipped
F73 – 20 Amp Yellow Fuel Transfer Pump (HD Only) – If Equipped
F74 – 20 Amp Yellow (Gas
Engine & 1500 LD
Diesel)Brake Vacuum Pump Gas/Diesel – If Equipped
F75 – 10 Amp Red Coolant Temperature Valve Actuator
F76 – 10 Amp Red Antilock Brakes / Electronic Stability Control
F77 – 10 Amp Red Drivetrain Control Module/Front Axle Discon-
nect Module
F78 – 10 Amp Red Engine Control Module / Electric Power Steer-
ing
F79 – 15 Amp Blue Clearance Lights
7
MAINTAINING YOUR VEHICLE 845

Severe Duty All Models Only
NOTE:Change Engine Oil at 4,000 miles (6,500 km) if the
vehicle is operated in a dusty and off road environment
or is operated predominantly at idle or only very low
engine RPM’s. This type of vehicle use is considered
Severe Duty.Once A Month Or Before A Long Trip:
•Check engine oil level
•Check windshield washer fluid level
•Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before the oil indicator system turns
on.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering (2500/3500 Models
Only) and automatic transmission (six-speed only)
and fill as needed
•Check function of all interior and exterior lights
8
MAINTENANCE SCHEDULES 871

Warranty expires. The manufacturer stands behind only
the manufacturer’s service contracts. If you purchased a
manufacturer’s service contract, you will receive Plan
Provisions and an Owner Identification Card in the mail
within three weeks of the vehicle delivery date. If you
have any questions about the service contract, call the
manufacturer’s Service Contract National Customer
Hotline at 1-800-521-9922 (Canadian residents, call (800)
465-2001 English / (800) 387-9983 French).
The manufacturer will not stand behind any service
contract that is not the manufacturer’s service contract. It
is not responsible for any service contract other than the
manufacturer’s service contract. If you purchased a ser-
vice contract that is not a manufacturer’s service contract,
and you require service after the manufacturer’s New
Vehicle Limited Warranty expires, please refer to the
contract documents, and contact the person listed in
those documents.We appreciate that you have made a major investment
when you purchased the vehicle. An authorized dealer
has also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
the ownership experience. You will be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARNING!
Engine exhaust (internal combustion engines only),
some of its constituents, and certain vehicle compo-
nents contain, or emit, chemicals known to the State
of California to cause cancer and birth defects, or
other reproductive harm. In addition, certain fluids
contained in vehicles and certain products of compo-
nent wear contain, or emit, chemicals known to the
State of California to cause cancer and birth defects,
or other reproductive harm.
884 IF YOU NEED CONSUMER ASSISTANCE

Adding Engine Coolant (Antifreeze)............817
Adding Fuel.............................683
Additives, Fuel...........................678
Adjust
Down...............................149
Forward..........................149, 150
Rearward.........................149, 150
Up .................................149
Adjustable Pedals.........................191
AirBag...............................69, 70
Advance Front Air Bag....................71
Air Bag Operation.......................72
Air Bag Warning Light....................80
Enhanced Accident Response................80
Event Data Recorder (EDR).................83
FrontAirBag...........................69
If A Deployment Occurs...................78
Knee Impact Bolsters.....................73
Maintaining Your Air Bag System............82Side Air Bags...........................73
Transporting Pets.......................116
Air Bag Deployment........................69
Air Bag Light......................80, 119, 299
Air Bag Maintenance.......................82
Air Cleaner, Engine (Engine Air Cleaner Filter). . . .799
Air Conditioner Maintenance.................805
Air Conditioning......................422, 427
Air Conditioning Controls................422, 427
Air Conditioning, Operating Tips...........441, 444
Air Conditioning Refrigerant..........805, 806, 807
Air Conditioning System..........422, 427, 440, 805
Air Pressure, Tires.....................648, 659
Air Suspension........................545, 557
Alarm, Panic.............................29
Alarm (Security Alarm)..................22, 302
Alarm System (Security Alarm)................22
Alterations/Modifications, Vehicle...............7
Antifreeze (Engine Coolant)...............816, 861
892 INDEX

Brake/Transmission Interlock.................489
Bulb Replacement......................849, 850
Bulbs, Light..........................121, 849
Cab Top Clearance Lights...................857
Camera, Rear............................214
Camper................................272
Capacities, Fluid..........................861
Caps, Filler
Oil (Engine)........................797, 798
Power Steering.........................615
Radiator (Coolant Pressure)................818
Carbon Monoxide Warning...............118,679
Cargo Light.............................182
Car Washes.............................831
Center High Mounted Stop Light..............855
Center Seat Storage Compartment.............244
Certification Label.........................686
Chart, Tire Sizing.........................637Check Engine Light (Malfunction Indicator Light) . .792
Checking Your Vehicle For Safety..............117
Checks, Safety............................117
Child Restraint............................84
Child Restraints
Booster Seats...........................89
Child Restraints.........................84
Child Seat Installation.................103, 105
How To Stow An Unused ALR Seat Belt.......101
Infants And Child Restraints................87
Install A LATCH-Compatible Child Restraint. . . .100
Installing Child Restraints Using The Vehicle Seat
Belt.................................102
Locating The LATCH Anchorages............97
Lower Anchors And Tethers For Children.......92
Older Children And Child Restraints..........88
Seating Positions........................91
Cigar Lighter............................237
Clean Air Gasoline........................676
894 INDEX

Disposal
Antifreeze (Engine Coolant)................819
Door Ajar...............................309
Door Ajar Light..........................309
Door Locks
Door Locks............................38
KeyFob...............................38
Remote...............................38
Remote Keyless Entry (RKE)................38
Door Locks, Automatic......................41
Door Opener, Garage.......................219
Driving
Off-Pavement..........................569
Off-Road.............................569
Through Flowing, Rising, Or Shallow Standing
Water................................589
Dual Rear Wheels......................663, 726
E-85 Fuel...............................680Electrical Power Outlets.....................232
Electric Rear Window Defrost.................249
Electronically Shifted Transfer Case......526, 533, 538
Electronic Brake Control System...............619
Anti-Lock Brake System..................620
Electronic Roll Mitigation.................631
Traction Control System...................625
Electronic Range Select (ERS)..........496, 506, 518
Electronic Speed Control (Cruise Control)........192
Electronic Stability Control (ESC)..............626
Electronic Throttle Control Warning Light........306
Electronic Vehicle Information Center (EVIC) . .214, 334
Electronic Vehicle Information Center (EVIC). . . .334
Electronic Vehicle Information Center (EVIC) Setup
Menu................................334
EVIC Messages.........................334
Selectable Menu Items....................339
Emergency Brake.........................616
896 INDEX

Emergency, In Case Of
Freeing Vehicle When Stuck................775
Hazard Warning Flasher..................725
Jump Starting..........................770
Tow Hooks............................776
Emission Control System Maintenance..........792
Engine..............................789, 790
Air Cleaner...........................799
Block Heater..........................486
Break-In Recommendations................116
Compartment..........................788
Compartment Identification.........788, 789, 790
Coolant (Antifreeze).....................863
Exhaust Gas Caution.................118,679
Flooded, Starting.......................480
Fuel Requirements...................674, 861
Jump Starting..........................770
Oil ...........................795, 861, 863
Oil Filler Cap.......................797, 798Oil Filter.............................799
Oil Selection.......................796, 861
Oil Synthetic..........................798
Overheating...........................725
Engine Oil Viscosity....................797, 798
Engine Oil Viscosity Chart...................797
Enhanced Accident Response Feature............80
Entry System, Illuminated....................24
Ethanol.............................676, 680
Event Data Recorder........................83
Exhaust Gas Caution....................118,679
Exhaust System.......................118,812
Exterior Lighting..........................173
Exterior Lights...........................121
Filters
Air Cleaner...........................799
Engine Oil.........................799, 863
Engine Oil Disposal.....................798
10
INDEX 897

Flashers
Turn Signal.....................121, 183, 329
Flat Tire Stowage......................743, 764
Flexible Fuel Vehicles
Cruising Range.........................682
Engine Oil............................681
Fuel Requirements...................680, 681
Maintenance...........................683
Replacement Parts.......................682
Starting..............................682
Flooded Engine Starting....................480
Fluid, Brake.............................867
Fluid Capacities..........................861
Fluid Leaks.............................121
Fluid Level Checks
Brake................................823
Power Steering.........................615
Fluids, Lubricants And Genuine Parts...........863
Fog Lights........................178, 320, 853Fold Flat Load Floor.......................251
Four-Way Hazard Flasher...................725
Four Wheel Drive.........................522
Freeing A Stuck Vehicle.....................775
Front Axle (Differential).....................825
Fuel...................................674
Adding..............................683
Additives.............................678
Clean Air.............................676
Ethanol...........................676, 680
Filler Cap (Gas Cap).....................685
Gasoline..............................674
Light................................317
Materials Added........................678
Methanol.............................676
Octane Rating......................674, 863
Requirements......................
.674, 861
Tank Capacity..........................861
Fuel, Flexible............................680
898 INDEX