spare wheel Ram 2500 2013 Owner's Guide

Remove the jack and tools from the bracket assembly.
Turn the jack-turn-screw counterclockwise to release jack
from bracket assembly.WARNING!
After using the jack and tools, always reinstall them
in the original carrier and location. While driving
you may experience abrupt stopping, rapid accelera-
tion or sharp turns. A loose jack, tools, bracket or
other objects in the vehicle may move around with
force, resulting in serious injury.
Removing The Spare Tire
1. Remove the spare tire before attempting to jack up thetruck. Attach the wheel wrench to the jack extension
tube with the curved angle facing away from the
vehicle. Insert the tube through the access hole be-
tween the lower tailgate and the top of the bumper
and into the winch mechanism tube.
Jack And Tools Bracket Assembly
6
WHAT TO DO IN EMERGENCIES 599

2. Rotate the wheel wrench handle counterclockwiseuntil the spare tire is on the ground with enough cable
slack to allow you to pull it out from under the vehicle. 3. Pull the spare tire out from under the vehicle to gain
access to the spare tire retainer.
600 WHAT TO DO IN EMERGENCIES

WARNING!(Continued)
•Do not let anyone sit in the vehicle when it is on a
jack.
• Do not get under the vehicle when it is on a jack. If
you need to get under a raised vehicle, take it to a
service center where it can be raised on a lift.
• Only use the jack in the positions indicated and for
lifting this vehicle during a tire change.
• If working on or near a roadway, be extremely
careful of motor traffic.
• To assure that spare tires, flat or inflated, are
securely stowed, spares must be stowed with the
valve stem facing the ground.
CAUTION!
Do not attempt to raise the vehicle by jacking on
locations other than those indicated in the Jacking
Instructions for this vehicle.
1. Remove the spare wheel, jack, and tools from storage.
2. Using the lug wrench, loosen, but do not remove, the wheel nuts by turning them counterclockwise one
turn while the wheel is still on the ground.
Jack Warning Label
604 WHAT TO DO IN EMERGENCIES

5. Remove the wheel nuts and pull the wheel off. Onsingle rear-wheel (SRW) trucks, install the spare wheel
and wheel nuts with the cone shaped end of the wheel
nuts toward the wheel. On 3500 dual rear-wheel
models (DRW) the wheel nuts are a two-piece assem-
bly with a flat face. Lightly tighten the wheel nuts. To
avoid the risk of forcing the vehicle off the jack, do not
fully tighten the wheel nuts until the vehicle has been
lowered.
6. Using the lug wrench, finish tightening the wheel nuts using a crisscross pattern. The correct wheel nut
tightness for a cone type wheel nut is 120–140 ft lbs
(160–190 N·m) torque, for a flanged type wheel nut is
130–160 ft lbs (175–215 N·m) torque. If in doubt about
the correct tightness, have them checked with a torque
wrench by your authorized dealer or at a service
station.WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could injure someone in the vehicle. Al-
ways stow the jack parts and the extra tire and wheel
in the places provided.
7.
Install the wheel center cap and remove the wheel blocks.
Do not install chrome or aluminum wheel center caps on
the spare wheel. This may result in cap damage.
8. Lower the jack to its fully closed position. If the bottle jack will not lower by turning the dial (thumbwheel)
by hand, it may be necessary to use the jack drive tube
in order to lower the jack. Stow the replaced tire, jack,
and tools as previously described.
9. Adjust the tire pressure when possible.
NOTE: Do not oil wheel studs. For chrome wheels, do
not substitute with chrome plated wheel nuts.
608 WHAT TO DO IN EMERGENCIES

To Stow The Flat Or Spare
NOTE: Have the flat tire repaired or replaced immedi-
ately.
WARNING!
A loose tire thrown forward in a collision or hard
stop could injure the occupants in the vehicle. Have
the deflated (flat) tire repaired or replaced immedi-
ately.
1. Turn the wheel so that the valve stem is facing the ground and toward the rear of the vehicle for conve-
nience in checking the spare tire inflation. Slide the
wheel retainer through the center of the wheel. 2. Lift the spare tire with one hand to give clearance to
tilt the retainer at the end of the cable and position it
properly across the wheel opening.
6
WHAT TO DO IN EMERGENCIES 609

Slots in the wheels will assist in properly orienting the
inner and outer wheels. Align these slots when assem-
bling the wheels for best access to the tire valve on the
inner wheel. The tires of both dual wheels must be
completely off the ground when tightening, to ensure
wheel centering and maximum wheel clamping.
Dual wheel models require a special heavy-duty lug nut
tightening adapter (included with the vehicle) to cor-
rectly tighten the lug nuts. Also, when it is necessary to
remove and install dual rear wheels, use a proper vehicle
lifting device.
NOTE:When installing a spare tire as part of a dual rear
wheel end combination, the tire diameter of the two
individual tires must be compared. If there is a significant
difference, the larger tire should be installed in a front
location. The correct direction of rotation for dual tire
installations must also be observed. These dual rear wheels should be tightened as follows:
1. Tighten the wheel nuts in the numbered sequence to a
snug fit.
2. Retighten the wheel nuts in the same sequence to the torques listed in the table. Go through the sequence a
Tightening Pattern
616 WHAT TO DO IN EMERGENCIES

Car Washes............................ .669
Cellular Phone .......................... .313
Center High Mounted Stop Light ..............692
Center Seat Storage Compartment .............216
Certification Label ........................ .536
Chart, Tire Sizing ........................ .488
Check Engine Light (Malfunction Indicator Light) . .255
Checking Your Vehicle For Safety ..............116
Checks, Safety ............................116
Child Restraint ............................82
Cigar Lighter ........................... .209
Clean Air Gasoline ....................... .527
Cleaning Wheels .............................. .671
Climate Control ......................... .314
Cold Weather Operation ....................345
Compact Disc (CD) Maintenance ..............312
Compact Spare Tire ....................... .503
Console, Overhead ....................... .191Contract, Service
......................... .715
Coolant Pressure Cap (Radiator Cap) ...........657
Cooling System .......................... .654
Adding Coolant (Antifreeze) ...............656
Coolant Capacity ...................... .696
Coolant Level ......................... .654
Disposal of Used Coolant .................658
Drain, Flush, and Refill ...................655
Inspection ........................... .658
Points to Remember .....................660
Pressure Cap ......................... .657
Radiator Cap ......................... .657
Selection of Coolant (Antifreeze) .............655
Corrosion Protection ...................... .668
Cupholders ..............................211
Customer Assistance ...................... .713
Data Recorder, Event .......................81
Daytime Running Lights ....................159
724 INDEX

Wheel, Heated........................ .173
Wheel, Tilt ........................... .172
Steering Wheel Audio Controls ................311
Steering Wheel Mounted Sound System Controls . . .311
Storage Compartment, Center Seat .............216
Storage, Vehicle .......................... .331
Storing Your Vehicle ...................... .685
Sun Roof .............................. .202
Supplemental Tire Pressure Information .........508
Suspension, Air .......................... .410
Sway Control, Trailer ...................... .485
Synthetic Engine Oil ...................... .645
System, Remote Starting .....................30
Tachometer ............................. .255
Tailgate ............................... .242
Temperature Control, Automatic (ATC) ..........324
Tilt Steering Column ...................... .172
Tip Start ............................... .343Tire and Loading Information Placard
...........493
Tire Markings ........................... .487
Tires ................................. .120
Aging (Life of Tires) .....................506
Air Pressure .......................... .498
Chains .............................. .509
Compact Spare ........................ .503
Dual ............................... .512
General Information .....................498
High Speed .......................... .501
Inflation Pressures ...................... .499
Life of Tires .......................... .506
Load Capacity ........................ .493
Pressure Monitor System (TPMS) ............513
Pressure Warning Light ...................260
Quality Grading ....................... .719
Radial .............................. .501
Replacement .......................... .507
Rotation ..............................

511
736 INDEX