fuel cap Ram 2500 2015 User Guide

SELECT button to turn off the message. If the problem
continues, the message will appear the next time the
vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the Malfunction Indicator Light (MIL).
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.For states that require an Inspection and Mainte-
nance (I/M), this check verifies the “Malfunction
Indicator Light (MIL)” is functioning and is not
on when the engine is running, and that the OBD II
system is ready for testing. Normally, the OBD II system will be ready. The OBD II
system may
notbe ready if your vehicle was recently
serviced, recently had a dead battery or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
Your vehicle has a simple ignition actuated test, which
you can use prior to going to the test station. To check if
your vehicle’s OBD II system is ready, you must do the
following:
1. Cycle the ignition switch to the ON position, but do not crank or start the engine.
NOTE: If you crank or start the engine, you will have to
start this test over.
2. As soon as you cycle the ignition switch to the ON position, you will see the Malfunction Indicator Light
(MIL) symbol come on as part of a normal bulb check.
748 MAINTAINING YOUR VEHICLE

CAUTION!
Do not use chemical flushes in your engine oil as the
chemicals can damage your engine. Such damage is
not covered by the New Vehicle Limited Warranty.
Engine Oil Viscosity — 3.6L Engines (1500 Models
Only)
MOPAR® SAE 5W-20 engine oil approved to FCA US
Material Standard MS-6395 or equivalent Pennzoil® or
Shell Helix® is recommended for all operating tempera-
tures. This engine oil improves low temperature starting
and vehicle fuel economy.
The engine oil filler cap also shows the recommended
engine oil viscosity for your vehicle. For information on
engine oil filler cap location, refer to “Engine Compart-
ment” in “Maintaining Your Vehicle” for further informa-
tion.NOTE:
MOPAR® SAE 5W-30 engine oil approved to
FCA US Material Standard MS-6395 may be used when
SAE 5W-20 engine oil meeting MS-6395 is not available.
Engine Oil Viscosity — 5.7L Engine (1500/2500/3500
Models)
MOPAR SAE 5W-20 engine oil or equivalent Pennzoil®
or Shell Helix® is recommended for all operating tem-
peratures. This engine oil improves low temperature
starting and vehicle fuel economy. The engine oil filler
cap also shows the recommended engine oil viscosity for
your engine. For information on engine oil filler cap
location, refer to “Engine Compartment” in “Maintaining
Your Vehicle” for further information.
NOTE:
• Lubricants which do not have both the engine oil
certification mark and the correct SAE viscosity grade
number should not be used.
7
MAINTAINING YOUR VEHICLE 753

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
1500 Regular Cab Shortbed/Crew Quad Cab Models 26 Gallons98 Liters
1500 Regular Cab Longbed/Crew Quad Cab Models (Optional) 32 Gallons 121 Liters
2500/3500 Shortbed Models 31 Gallons117 Liters
2500/3500 Longbed Models 32 Gallons121 Liters
Engine Oil With Filter
3.6L Engine (We recommend you use SAE 5W-20, API Certified) 6 Quarts5.6 Liters
5.7L Engines (We recommend you use SAE 5W-20, API Certified) 7 Quarts 6.6 Liters
5.7L Engine (We recommend you use SAE 5W-30, API Certified),
for 2500/3500 trucks operating under a gross combined weight
rating greater than 14,000 lbs (6 350 kg). 7 Quarts
6.6 Liters
6.4L Engines (We recommend you use SAE 0W-40 engine oil
meeting the requirements of FCA US Material Standard MS-12633
for use in all operating temperatures.) 7 Quarts
6.6 Liters
7
MAINTAINING YOUR VEHICLE 815

ComponentFluid, Lubricant, or Genuine Part
Engine Oil – 5.7L Engine 2500/3500
trucks operating under a gross com-
bined weight rating greaterthan
14,000 lbs/(6,350 kg.) We recommend you use API Certified SAE 5W-30 Engine Oil, meeting the
requirements of FCA US Material Standard MS-6395 such as MOPAR®,
Pennzoil®, Shell Helix® or equivalent. Refer to your engine oil filler cap
for correct SAE grade.
Engine Oil – 6.4L For best performance and maximum protection under all types of operat-
ing conditions, the manufacturer only recommends full synthetic engine
oils that meet the American Petroleum Institute (API) categories of SN. The
manufacturer recommends the use of Pennzoil Ultra™ 0W-40 or equiva-
lent MOPAR® engine oil meeting the requirements of FCA US Material
Standard MS-12633 for use in all operating temperatures.
Engine Oil Filter We recommend you use MOPAR® brand Engine Oil Filters.
Spark Plugs We recommend you use MOPAR® Spark Plugs.
Fuel Selection – 3.6L Engine 87 Octane, 0-15% Ethanol.
Fuel Selection – 3.6L Flex Fuel (E-85)
Engine – If Equipped 87 Octane, Up To 85% Ethanol.
Fuel Selection – 5.7L/6.4L Engines 89 Octane Recommended - 87 Octane Acceptable, 0-15% Ethanol.
818 MAINTAINING YOUR VEHICLE

Break-In Recommendations................113
Compartment ......................... .744
Compartment Identification .........744, 745, 746
Coolant (Antifreeze) .....................817
Exhaust Gas Caution .................114,632
Flooded, Starting ...................... .445
Fuel Requirements ...................627, 815
Jump Starting ......................... .725
Oil .......................... .751, 815, 817
Oil Filler Cap ...................... .753, 754
Oil Selection ...................... .752, 815
Oil Synthetic ......................... .754
Overheating .......................... .679
Engine Oil Viscosity ....................753, 754
Engine Oil Viscosity Chart ...................753
Enhanced Accident Response Feature ............78
Entry System, Illuminated ....................24
Ethanol ............................... .629
Event Data Recorder ........................81 Exhaust Gas Caution
....................114,632
Exhaust System .......................114,768
Exterior Lighting ......................... .165
Exterior Lights ...........................117
Filters Air Cleaner .......................... .755
Engine Oil ........................ .754, 817
Engine Oil Disposal .....................754
Flashers Turn Signal .....................117, 175, 285
Flat Tire Stowage ..................... .698, 719
Flexible Fuel Vehicles Cruising Range ........................ .635
Engine Oil ........................... .634
Fuel Requirements ...................633, 634
Maintenance .......................... .636
Replacement Parts ...................... .635
Starting ............................. .635
10
INDEX 847

Flooded Engine Starting....................445
Fluid, Brake ............................ .820
Fluid Capacities ......................... .815
Fluid Leaks .............................118
Fluid Level Checks Brake ............................... .779
Power Steering ........................ .571
Fluids, Lubricants and Genuine Parts ...........817
Fog Lights ....................... .170, 285, 808
Fold Flat Load Floor ...................... .244
Four-Way Hazard Flasher ...................679
Four Wheel Drive ........................ .487
Freeing A Stuck Vehicle .....................730
Front Axle (Differential) .....................780
Fuel .................................. .627
Adding ............................. .636
Clean Air ............................ .629
Ethanol ............................. .629
Filler Cap (Gas Cap) .....................638 Gasoline
............................. .627
Methanol ............................ .629
Octane Rating ..................... .627, 817
Requirements ...................... .627, 815
Tank Capacity ......................... .815
Fuel, Flexible ........................... .633
Fuses ................................. .794
Garage Door Opener (HomeLink®) .........211,218
Gas Cap (Fuel Filler Cap) ................638, 747
Gasoline, Clean Air ....................... .629
Gasoline (Fuel) .......................... .627
Gasoline, Reformulated .....................629
Gauges Speedometer ......................... .285
Tachometer ........................... .285
Gear Ranges ........................ .465, 477
Gear Select Lever Override ..................733
General

Information ...................... .627
848 INDEX

Occupant Restraints........................49
Octane Rating, Gasoline (Fuel) ................627
Off-Pavement Driving (Off-Road) ...........526, 549
Off-Road Driving (Off-Pavement) ...........526, 549
Oil, Engine ......................... .751, 817
Capacity ............................ .815
Change Interval ....................... .752
Dipstick ............................. .751
Disposal ............................. .754
Filter ............................ .754, 817
Filter Disposal ........................ .754
Identification Logo ..................... .752
Recommendation ....................752, 815
Synthetic ............................ .754
Viscosity ...................... .753, 754, 815
Oil Filter, Selection ....................... .754
Onboard Diagnostic System ..................747
Operating Precautions ..................... .747
Operator Manual (Owner’s Manual) .............4Outside Rearview Mirrors
...................134
Overdrive .......................... .474, 485
Overdrive OFF Switch ..................474, 485
Overhead Console ........................ .209
Overheating, Engine ...................... .679
Owner’s Manual (Operator Manual) ..........4,837
Paint Care ............................. .786
Panic Alarm ..............................28
Parking Brake ........................... .572
ParkSense® System, Rear ................189, 198
Passing Light ........................... .176
Passive Entry .............................42
Pedals, Adjustable ........................ .183
Personal Settings ..................... .319, 346
Pets ...................................112
Pets, Transporting .........................112
Pickup Box ...................... .248, 251, 268
Placard, Tire and Loading Information ..........598
10
INDEX 853