Fluid check Ram 2500 2019 User Guide

SERVICING AND MAINTENANCE 529
Fluid Level Check — Eight-Speed Transmission
The fluid level is preset at the factory and does not require
adjustment under normal operating conditions. Routine
fluid level checks are not required, therefore the transmis-
sion has no dipstick. An authorized dealer can check your
transmission fluid level using special service tools.
If you notice fluid leakage or transmission malfunction, visit
an authorized dealer immediately to have the transmission
fluid level checked. Operating the vehicle with an improper
fluid level can cause severe transmission damage. Fluid And Filter Changes — Eight-Speed Transmission
Under normal operating conditions, the fluid installed at the
factory will provide satisfactory lubrication for the life of the
vehicle.
Routine fluid and filter changes are not required. However,
change the fluid and filter if the fluid becomes contaminated
(with water, etc.), or if the transmission is disassembled for
any reason.
Rear Axle And 4x4 Front Driving Axle Fluid Level
For normal service, periodic fluid level checks are not
required. When the vehicle is serviced for other reasons the
exterior surfaces of the axle assembly should be inspected. If
gear oil leakage is suspected inspect the fluid level. Refer to
“Fluids And Lubricants” in “Technical Specifications” for
further information. This inspection should be made with
the vehicle in a level position.
For all 2500/3500 Model axles, the fluid level should be 1/
4 in ± 1/4 in (6.4 mm ± 6.4 mm) below the fill hole on the
9.25 in front, 11.5 in rear axle, and 12.0 in rear axle.
CAUTION!
If a transmission fluid leak occurs, visit an authorized
dealer immediately. Severe transmission damage may
occur. An authorized dealer has the proper tools to adjust
the fluid level accurately.
7

530 SERVICING AND MAINTENANCE
Lubricant Selection
Refer to “Fluids And Lubricants” in “Technical Specifica-
tion” for further information.
NOTE:
The presence of water in the gear lubricant will result in
corrosion and possible failure of differential components.
Operation of the vehicle in water, as may be encountered in
some off-highway types of service, will require draining and
refilling the axle to avoid damage.
Limited-Slip Differentials DO REQUIRE limited slip oil
additive (friction modifiers).
NOTE:
Slight noise and mild shuddering may be evident while
turning a vehicle with limited slip differential on concrete or
dry pavement. These conditions should be considered
normal operation of the limited slip differential.
Drain And Refill
Refer to the “Maintenance Plan” for the proper maintenance
intervals.Transfer Case
Selection Of Lubricant
Use only the manufacturer's recommended fluid. Refer to
“Fluids And Lubricants” in “Technical Specifications” for
further information.
Fluid Level Check
This fluid level can be checked by removing the filler plug.
The fluid level should be to the bottom edge of the filler plug
hole with the vehicle in a level position.
Drain And Refill
Refer to the “Maintenance Plan” in this section for the proper
maintenance intervals.

679
Automatic Door Locks ............................................................. 39
Automatic Headlights .............................................................. 69
Automatic Tailgate Release ................................................... 102
Automatic Temperature Control (ATC) ................................ 91
Automatic Transmission ................................................ 301, 529 Adding Fluid ....................................................................... 529Fluid And Filter Change .................................................... 529
Fluid Change........................................................................ 529
Fluid Level Check ....................................................... 528, 529
Fluid Type .................................................................... 528, 574
Special Additives................................................................. 528
Automatic Transmission Limp Home Mode ...................... 306
Auxiliary Driving Systems .................................................... 208
Axle Fluid......................................................................... 529, 574
Axle Lubrication...................................................................... 529 B
Back-Up .................................................................................... 397
Back-Up Camera ..................................................................... 397
Bar, Stabilizer/Sway System ................................................. 322
Battery............................................................................... 182, 506 Charging System Light....................................................... 182
Keyless Key Fob Replacement ............................................ 21
Battery Saver Feature ............................................................... 73 Belts, Seat ................................................................................. 287
Blind Spot Monitoring............................................................ 208
Body Builders Guide ................................................................ 15 Body Mechanism Lubrication ...............................................517
B-Pillar Location ......................................................................537
Brake Assist System ................................................................197
Brake Control System .............................................................196
Brake Fluid .......................................................................527, 574
Brake System....................................................................527, 565 Fluid Check ..........................................................................527
Master Cylinder ...................................................................527Parking ..................................................................................298
Warning Light......................................................................180
Brake/Transmission Interlock ..............................................301
Bulb Replacement ...................................................................446
Bulbs, Light ......................................................................289, 446 C
Cab Top Clearance Lights ......................................................455
Camera...................................................................................... 397
Camera, Rear....................................................................397, 401
Camper .....................................................................................144
Capacities, Fluid ......................................................................571
Caps, Filler Oil (Engine) ..................................................................504, 508
Radiator (Coolant Pressure)...............................................525
Car Washes ..............................................................................558
Carbon Monoxide Warning ...........................................286, 570
Cargo Light ................................................................................72 Cellular Phone .........................................................................647
11

682
Enhanced Accident Response Feature ......................... 255, 498
Entry System, Illuminated ....................................................... 76
Ethanol...................................................................................... 568
Exhaust Gas Cautions .................................................... 286, 570
Exhaust System ............................................................... 286, 520
Exterior Lighting ....................................................................... 67 Exterior Lights ................................................................... 67, 289 F
Filters Air Cleaner ........................................................................... 509Air Conditioning ........................................................... 93, 512
Engine Oil..................................................................... 509, 572
Engine Oil Disposal ............................................................ 508
Flashers Turn Signals ........................................................... 71, 191, 289
Flash-To-Pass ............................................................................. 69
Flat Tire Changing .................................................. 469, 531, 548
Flat Tire Stowage .................................................... 483, 531, 548
Fluid Capacities ....................................................................... 571
Fluid Leaks ............................................................................... 289
Fluid Level Checks Brake ..................................................................................... 527
Fluid, Brake .............................................................................. 574
Fluids And Lubricants ........................................................... 572
Fog Lights........................................................................... 71, 451
Fold Flat Load Floor ............................................................... 119 Fold-Flat Seats ...........................................................................40
Forward Collision Warning................................................... 216
Four Wheel Drive .................................................................... 309
Four-Way Hazard Flasher .....................................................440
Freeing A Stuck Vehicle .........................................................494
Front Axle (Differential) .........................................................529
Fuel ............................................................................................567 Adding ..................................................................................408
Additives ..............................................................................568
Clean Air...............................................................................568
Ethanol ..................................................................................568
Filler Cap (Gas Cap)............................................................ 410
Gasoline ................................................................................567Light ...................................................................................... 186
Materials Added ..................................................................568
Methanol...............................................................................568
Octane Rating...............................................................567, 572Requirements ...............................................................567, 571Tank Capacity ......................................................................571
Fuses..........................................................................................457 G
Garage Door Opener (HomeLink) ........................................104
Gas Cap (Fuel Filler Cap) .......................................................410
Gasoline, Clean Air .................................................................568
Gasoline, Reformulated..........................................................568
General Information ...............................................................230

684
J
Jack Location............................................................................ 469
Jump Starting........................................................................... 488 K
Key Fob Panic Alarm ........................................................................... 19
Programming Additional Key Fobs ............................. 24, 30
Key Fob Battery Service (Remote Keyless Entry)................. 21
Key Fob Programming (Remote Keyless Entry) .................. 24
Keyless Enter-N-Go .......................................................... 36, 291 Lock The Vehicle’s Doors................................... 585, 610, 631
Passive Entry.......................................................................... 36
Passive Entry Programming ...................................... 610, 631
Keys............................................................................................. 18 Replacement........................................................................... 31 L
Lane Change And Turn Signals .............................................. 71 Lane Change Assist .................................................................. 71
Latches ...................................................................................... 289 Hood ..................................................................................... 101
Lead Free Gasoline ................................................................. 567
Leaks, Fluid.............................................................................. 289
Life Of Tires ............................................................................. 545
Light Bulbs ....................................................................... 289, 446
Lights ........................................................................................ 289 Air Bag .................................................................. 180, 245, 287 Automatic High Beam ..........................................................68
Brake Assist Warning .........................................................204
Brake Warning .....................................................................180
Bulb Replacement................................................................446
Cab Top Clearance ..............................................................455
Cargo .......................................................................................72
Center Mounted Stop..........................................................453
Courtesy/Reading ................................................................74
Cruise ............................................................................191, 192 Daytime Running ..................................................................68
Electronic Stability Program(ESP) Indicator ...................181
Engine Temperature Warning ...........................................181
Exterior............................................................................67, 289Fog .........................................................................................451
Four Wheel Drive Indicator ...............................................317Hazard Warning Flasher ....................................................440
Headlights ........................................................................67, 69High Beam ..............................................................................68
Hill Descent Control Indicator .......................................... 206Illuminated Entry ..................................................................76
Interior ..............................................................................73, 74
Lights On Reminder..............................................................70
Low Fuel ...............................................................................186
Malfunction Indicator (Check Engine).............................184Park........................................................................................191Passing ....................................................................................69

687
Rearward ................................................................................ 44
Recline..................................................................................... 44
Tilt ........................................................................................... 44
Up ............................................................................................ 44
Power Steering Fluid .............................................................. 574
Pregnant Women And Seat Belts.......................................... 242
Pretensioners Seat Belts............................................................................... 242 R
Radial Ply Tires ....................................................................... 543
Radiator Cap (Coolant Pressure Cap).......................... 522, 525
Radio Frequency General Information ........................................... 24, 29, 31, 38
Radio Operation ...................................................................... 647
Rain Sensitive Wiper System................................................... 78
Ramp Travel Index ................................................................. 324
Rear Axle (Differential) .......................................................... 529
Rear Camera ............................................................................ 401
Rear Cargo Area Utility Rails................................................ 142
Rear Cross Path ....................................................................... 213
Rear ParkSense System .................................................. 379, 387
Rear Window, Sliding .............................................................. 97
Reclining Rear Seats ................................................................. 43
Recreational Towing ............................................................... 430 Shifting Into Transfer Case Neutral (N) .......................... 433
Shifting Out Of Transfer Case Neutral (N) ..................... 435 Reformulated Gasoline........................................................... 568
Refrigerant................................................................................512
Release, Hood ..........................................................................101
Release, Tailgate ......................................................................102
Reminder, Seat Belt .................................................................232
Remote Keyless Entry...............................................................19 Panic Alarm............................................................................19
Programming Additional Key Fobs ............................. 24, 30
Remote Starting Exit Remote Start Mode........................................................29

Uconnect Customer Programmable Features ... 588, 613, 633

Uconnect Settings ................................................588, 613, 633
Replacement Bulbs..................................................................446
Replacement Keys .....................................................................31
Replacement Tires ...................................................................546
Reporting Safety Defects ........................................................676
Restraints, Child ......................................................................258
Restraints, Head ........................................................................51 Rotation, Tires..........................................................................553 S
Safety Checks Inside Vehicle .................................................287
Safety Checks Outside Vehicle ..............................................289
Safety Defects, Reporting .......................................................676
Safety Information, Tire .........................................................531
Safety Tips ................................................................................286
Safety, Exhaust Gas.................................................................286
11