belt Ram 2500 2019 Repair Manual

SERVICING AND MAINTENANCE 511
Engine Air Cleaner Filter Installation
NOTE:
Inspect and clean the housing if dirt or debris is present
before replacing the air filter element.
1. Install the air cleaner filter element into the housingassembly with the air cleaner filter inspection surface
facing downward.
2. Install the air cleaner cover onto the housing assembly.
3. Tighten the fasteners (six) on the air cleaner filter assembly
Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an authorized dealer at the start
of each warm season. This service should include cleaning of
the condenser fins and a performance test. Drive belt tension
should also be checked at this time.
WARNING!
• Use only refrigerants and compressor lubricants approved by the manufacturer for your air condi -
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other unap -
proved refrigerants or lubricants can cause the system
to fail, requiring costly repairs. Refer to Warranty Infor -
mation Book, for further warranty information.
• The air conditioning system contains refrigerant under high pressure. To avoid risk of personal injury or
damage to the system, adding refrigerant or any repair
requiring lines to be disconnected should be done by
an experienced technician.
CAUTION!
Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air
conditioning components. Such damage is not covered
by the New Vehicle Limited Warranty.
7

516 SERVICING AND MAINTENANCE
9. Reattach the glove compartment tension tether byinserting the tether clip in the glove compartment and
sliding the clip away from the face of the glove compart -
ment door.
Accessory Drive Belt Inspection
When inspecting accessory drive belts, small cracks that run
across ribbed surface of belt from rib to rib, are considered
normal. These are not a reason to replace belt. However,
cracks running along a rib (not across) are not normal. Any belt with cracks running along a rib must be replaced. Also
have the belt replaced if it has excessive wear, frayed cords
or severe glazing.
Accessory Belt (Serpentine Belt)
Conditions that would require replacement:

• Rib chunking (one or more ribs has separated from belt body)

• Rib or belt wear
• Longitudinal belt cracking (cracks between two ribs)
• Belt slips
• “Groove jumping" (belt does not maintain correct position on pulley)
WARNING!
• Do not attempt to inspect an accessory drive belt with vehicle running.
• When working near the radiator cooling fan, discon -
nect the fan motor lead. The fan is temperature
controlled and can start at any time regardless of igni -
tion mode. You could be injured by the moving fan
blades.
• You can be badly injured working on or around a motor vehicle. Only do service work for which you have the
knowledge and the proper equipment. If you have any
doubt about your ability to perform a service job, take
your vehicle to a competent mechanic.

SERVICING AND MAINTENANCE 517
• Belt broken (note: identify and correct problem before newbelt is installed)
• Noise (objectionable squeal, squeak, or rumble is heard or felt while drive belt is in operation)
Some conditions can be caused by a faulty component such
as a belt pulley. Belt pulleys should be carefully inspected for
damage and proper alignment.
Belt replacement on some models requires the use of special
tools, we recommend having your vehicle serviced at an
authorized dealer.
Body Lubrication
Locks and all body pivot points, including such items as seat
tracks, door hinge pivot points and rollers, liftgate, tailgate,
decklid, sliding doors and hood hinges, should be lubricated
periodically with a lithium based grease, such as Mopar
Spray White Lube to assure quiet, easy operation and to
protect against rust and wear. Prior to the application of any
lubricant, the parts concerned should be wiped clean to
remove dust and grit; after lubricating excess oil and grease
should be removed. Particular attention should also be given
to hood latching components to ensure proper function. When performing other underhood services, the hood latch,
release mechanism and safety catch should be cleaned and
lubricated.
The external lock cylinders should be lubricated twice a year,
preferably in the Fall and Spring. Apply a small amount of a
high quality lubricant, such as Mopar Lock Cylinder Lubri
-
cant directly into the lock cylinder.
Windshield Wiper Blades
Clean the rubber edges of the wiper blades and the wind -
shield periodically with a sponge or soft cloth and a mild
nonabrasive cleaner. This will remove accumulations of salt
or road film.
Operation of the wipers on dry glass for long periods may
cause deterioration of the wiper blades. Always use washer
fluid when using the wipers to remove salt or dirt from a dry
windshield.
Avoid using the wiper blades to remove frost or ice from the
windshield. Keep the blade rubber out of contact with petro -
leum products such as engine oil, gasoline, etc.
7

562 SERVICING AND MAINTENANCE
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical solvents
or abrasive cleaners. This will weaken the fabric. Sun
damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or luke-
warm water. Do not remove the belts from the vehicle to
wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
NOTE:
If the belts retract slowly, inspect the upper turning loop for
soiling. If soiling is present, clean with a wet soft cloth until
all residue is removed.Plastic And Coated Parts
Use Mopar Total Clean to clean vinyl upholstery.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care must
be taken to avoid scratching the plastic.
1. Clean with a wet soft cloth. A mild soap solution may be used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
cloth.
2. Dry with a soft cloth.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do not
disassemble or modify the system. Seat belt assemblies
must be replaced after a collision if they have been
damaged (i.e., bent retractor, torn webbing, etc.).
CAUTION!
• Direct contact of air fresheners, insect repellents, suntan lotions, or hand sanitizers to the plastic,
painted, or decorated surfaces of the interior may cause
permanent damage. Wipe away immediately.
• Damage caused by these type of products may not be covered by your New Vehicle Limited Warranty.

679
Automatic Door Locks ............................................................. 39
Automatic Headlights .............................................................. 69
Automatic Tailgate Release ................................................... 102
Automatic Temperature Control (ATC) ................................ 91
Automatic Transmission ................................................ 301, 529 Adding Fluid ....................................................................... 529Fluid And Filter Change .................................................... 529
Fluid Change........................................................................ 529
Fluid Level Check ....................................................... 528, 529
Fluid Type .................................................................... 528, 574
Special Additives................................................................. 528
Automatic Transmission Limp Home Mode ...................... 306
Auxiliary Driving Systems .................................................... 208
Axle Fluid......................................................................... 529, 574
Axle Lubrication...................................................................... 529 B
Back-Up .................................................................................... 397
Back-Up Camera ..................................................................... 397
Bar, Stabilizer/Sway System ................................................. 322
Battery............................................................................... 182, 506 Charging System Light....................................................... 182
Keyless Key Fob Replacement ............................................ 21
Battery Saver Feature ............................................................... 73 Belts, Seat ................................................................................. 287
Blind Spot Monitoring............................................................ 208
Body Builders Guide ................................................................ 15 Body Mechanism Lubrication ...............................................517
B-Pillar Location ......................................................................537
Brake Assist System ................................................................197
Brake Control System .............................................................196
Brake Fluid .......................................................................527, 574
Brake System....................................................................527, 565 Fluid Check ..........................................................................527
Master Cylinder ...................................................................527Parking ..................................................................................298
Warning Light......................................................................180
Brake/Transmission Interlock ..............................................301
Bulb Replacement ...................................................................446
Bulbs, Light ......................................................................289, 446 C
Cab Top Clearance Lights ......................................................455
Camera...................................................................................... 397
Camera, Rear....................................................................397, 401
Camper .....................................................................................144
Capacities, Fluid ......................................................................571
Caps, Filler Oil (Engine) ..................................................................504, 508
Radiator (Coolant Pressure)...............................................525
Car Washes ..............................................................................558
Carbon Monoxide Warning ...........................................286, 570
Cargo Light ................................................................................72 Cellular Phone .........................................................................647
11

680
Center High Mounted Stop Light......................................... 453
Center Seat Storage Compartment ....................................... 113
Changing A Flat Tire .............................................................. 469
Chart, Tire Sizing .................................................................... 533
Check Engine Light (Malfunction Indicator Light) ........... 193
Checking Your Vehicle For Safety ........................................ 286
Checks, Safety .......................................................................... 286
Child Restraint ........................................................................ 258
Child Restraints Booster Seats ........................................................................ 262
Child Seat Installation ................................................ 275, 277
How To Stow An unused ALR Seat Belt ......................... 273Infant And Child Restraints .............................................. 260Locating The LATCH Anchorages ................................... 269
Lower Anchors And Tethers For Children ..................... 264Older Children And Child Restraints .............................. 261
Seating Positions ................................................................. 263
Clean Air Gasoline .................................................................. 568
Cleaning Wheels................................................................................... 551
Climate Control ......................................................................... 79 Automatic ............................................................................... 83
Manual .................................................................................... 79
Cold Weather Operation........................................................ 296
Compact Disc (CD) Maintenance ......................................... 672
Compact Spare Tire ................................................................ 549 Contract, Service......................................................................675
Cooling Pressure Cap (Radiator Cap) ..................................525
Cooling System ........................................................................522
Adding Coolant (Antifreeze) .............................................524
Coolant Level ...............................................................522, 525Cooling Capacity .................................................................571
Disposal Of Used Coolant..................................................525Drain, Flush, And Refill .....................................................523
Inspection ............................................................................. 525
Points To Remember ........................................................... 526Pressure Cap ........................................................................525Radiator Cap ........................................................................525Selection Of Coolant (Antifreeze) .....................523, 571, 572
Corrosion Protection ...............................................................557
Cruise Control (Speed Control) ....................................354, 357
Cruise Light .....................................................................191, 192
Cupholders...............................................................................122
Customer Assistance ..............................................................673
Cybersecurity ...........................................................................576 D
Daytime Running Lights ..........................................................68
Dealer Service ..........................................................................506
Defroster, Rear Window ..........................................................79
Defroster, Windshield ......................................................79, 287
Delay (Intermittent) Wipers ....................................................77
Diagnostic System, Onboard .................................................192

685
Seat Belt Reminder .............................................................. 179Security Alarm..................................................................... 181
Service ................................................................................... 446Side Marker .......................................................................... 457
Traction Control .................................................................. 204
Transfer Case ....................................................................... 317Turn Signals ........................................... 71, 191, 289, 447, 452
Warning Instrument Cluster Descriptions .............. 181, 191
Limited-Slip Differential ................................................ 337, 530
Load Shed Battery Saver Mode............................................. 177
Load Shed Battery Saver On ................................................. 177
Load Shed Electrical Load Reduction .................................. 177
Load Shed Intelligent Battery Sensor ................................... 177
Loading Vehicle ...................................................................... 410 Tires....................................................................................... 537
Locks Automatic Door..................................................................... 39
Child Protection .................................................................... 39
Power Door ............................................................................ 35
Low Tire Pressure System ..................................................... 220
Lubrication, Body ................................................................... 517
Lug Nuts/Bolts ....................................................................... 565 M
Maintenance............................................................................. 100
Maintenance Free Battery ...................................................... 506
Maintenance Schedule ........................................................... 499 Malfunction Indicator Light (Check Engine) ......................184
Manual Park Release .........................................................................492
Service ...................................................................................677
Media Hub ...............................................................................643
Memory Seat ..............................................................................45
Methanol...................................................................................568
Mirrors ........................................................................................57 Electric Powered ....................................................................60
Heated .....................................................................................63
Memory...................................................................................45
Outside....................................................................................59
Rearview .............................................................57, 58, 59, 441 Trailer Towing .......................................................................62
Modifications/Alterations Vehicle.....................................................................................15
Monitor, Tire Pressure System ..............................................220
Mopar Parts..............................................................................676
MP3 Control ............................................................................. 643
Multi-Function Control Lever .................................................67 N
Navigation System (Uconnect GPS) .....................................397
New Vehicle Break-In Period ................................................297 O
Occupant Restraints ................................................................230
Octane Rating, Gasoline (Fuel)..............................................567
11

687
Rearward ................................................................................ 44
Recline..................................................................................... 44
Tilt ........................................................................................... 44
Up ............................................................................................ 44
Power Steering Fluid .............................................................. 574
Pregnant Women And Seat Belts.......................................... 242
Pretensioners Seat Belts............................................................................... 242 R
Radial Ply Tires ....................................................................... 543
Radiator Cap (Coolant Pressure Cap).......................... 522, 525
Radio Frequency General Information ........................................... 24, 29, 31, 38
Radio Operation ...................................................................... 647
Rain Sensitive Wiper System................................................... 78
Ramp Travel Index ................................................................. 324
Rear Axle (Differential) .......................................................... 529
Rear Camera ............................................................................ 401
Rear Cargo Area Utility Rails................................................ 142
Rear Cross Path ....................................................................... 213
Rear ParkSense System .................................................. 379, 387
Rear Window, Sliding .............................................................. 97
Reclining Rear Seats ................................................................. 43
Recreational Towing ............................................................... 430 Shifting Into Transfer Case Neutral (N) .......................... 433
Shifting Out Of Transfer Case Neutral (N) ..................... 435 Reformulated Gasoline........................................................... 568
Refrigerant................................................................................512
Release, Hood ..........................................................................101
Release, Tailgate ......................................................................102
Reminder, Seat Belt .................................................................232
Remote Keyless Entry...............................................................19 Panic Alarm............................................................................19
Programming Additional Key Fobs ............................. 24, 30
Remote Starting Exit Remote Start Mode........................................................29

Uconnect Customer Programmable Features ... 588, 613, 633

Uconnect Settings ................................................588, 613, 633
Replacement Bulbs..................................................................446
Replacement Keys .....................................................................31
Replacement Tires ...................................................................546
Reporting Safety Defects ........................................................676
Restraints, Child ......................................................................258
Restraints, Head ........................................................................51 Rotation, Tires..........................................................................553 S
Safety Checks Inside Vehicle .................................................287
Safety Checks Outside Vehicle ..............................................289
Safety Defects, Reporting .......................................................676
Safety Information, Tire .........................................................531
Safety Tips ................................................................................286
Safety, Exhaust Gas.................................................................286
11

688
Schedule, Maintenance .......................................................... 499
Seat Belt Reminder.................................................................. 179
Seat Belts .......................................................................... 231, 287Adjustable Shoulder Belt ................................................... 237
Adjustable Upper Shoulder Anchorage .......................... 237
Adjustable Upper Shoulder Belt Anchorage................... 237
Automatic Locking Retractor (ALR) ................................ 243
Child Restraints ................................................................... 258Energy Management Feature ............................................ 242
Extender................................................................................ 241
Front Seat...................................................................... 231, 235
Inspection ............................................................................. 287
Lap/Shoulder Belt Operation ........................................... 235
Lap/Shoulder Belt Untwisting ......................................... 237Operating Instructions ....................................................... 235
Pregnant Women................................................................. 242
Pretensioners........................................................................ 242
Reminder .............................................................................. 232
Seat Belt Extender ............................................................... 241Seat Belt Pretensioner ......................................................... 242
Seat Belt Reminder .............................................................. 232Untwisting Procedure ........................................................ 237
Seat Belts Maintenance........................................................... 562
Seats ................................................................................ 40, 42, 44 Adjustment....................................................................... 40, 44Easy Entry .............................................................................. 48 Folding Floor ........................................................................119
Head Restraints .....................................................................51
Memory...................................................................................45
Power ......................................................................................43
Rear Folding ...........................................................................40
Reclining Rear ........................................................................43
Tilting ......................................................................................40
Security Alarm ...................................................................32, 181
Selection Of Coolant (Antifreeze) .........................................572
Sentry Key Key Programming .................................................................30
Sentry Key (Immobilizer).........................................................30
Sentry Key Replacement ..........................................................31
Service Assistance ...................................................................673
Service Contract.......................................................................675
Service Manuals ......................................................................677
Shifting...................................................................................... 299 Automatic Transmission ....................................................301
Transfer Case .......................................................................316Transfer Case, Shifting Into Transfer Case
Neutral (N) ...........................................................................433
Transfer Case, Shifting Out Of Transfer Case
Neutral (N) ...........................................................................435
Side Steps, Power ......................................................................35
Signals, Turn ..............................................................71, 191, 289
Siri..............................................................................................666

691
Transmission............................................................................ 301Automatic ..................................................................... 301, 528
Fluid ...................................................................................... 574
Maintenance......................................................................... 528
Shifting.................................................................................. 299
Transporting Pets .................................................................... 286
Tread Wear Indicators............................................................ 545
Turn Signals ....................................................... 71, 191, 447, 452 U
Uconnect Uconnect Settings ................ 578, 585, 588, 610, 613, 631, 633
Uconnect Settings Customer Programmable
Features .................................. 36, 585, 588, 610, 613, 631, 633
Passive Entry Programming ........................ 36, 585, 610, 631
Uconnect Voice Command .................................................... 649
Uniform Tire Quality Grades ................................................ 555
Universal Garage Door Opener (HomeLink) ..................... 104
Universal Transmitter ............................................................ 104
Unleaded Gasoline.................................................................. 567
Untwisting Procedure, Seat Belt ........................................... 237
USB ............................................................................................ 643
Utility Rails, Rear Cargo Area............................................... 142 V
Vehicle Identification Number (VIN) ..................................564
Vehicle Loading...............................................................410, 538
Vehicle Modifications/Alterations .........................................15
Vehicle Storage ..................................................................92, 557
Vehicle User Guide In Vehicle Help ......................................................................16
Navigation ..............................................................................16
Operating Instructions..........................................................16
Searching User Guide ...........................................................16
Viscosity, Engine Oil...............................................................508
Voice Recognition System (VR) ............................................649
11