wheel Ram 2500 (Diesel) 2007 Owners Manual

Miles 45,000 52,500 60,000 67,500 75,000
(Kilometers) (72 000) (84 000) (96 000) (108 000) (120 000)
[Months] [36] [42] [48] [54] [60]
Change engine oil and engine oil filter. X X X
Lubricate Front Drive Shaft Fitting (2500/3500, 4X4). X X X X X
Rotate tires. X X X X X
Check spare tire for proper pressure and correct
stowage.X X XXX
Lubricate outer tie rod ends 2500/3500 (4X4) models. X X X X X
Check transfer case fluid level. X
Flush and replace engine coolant at 60 months, if not
replaced at 100,000 miles (160 000 km).X
Inspect drive belts, replace as necessary. X X
Replace fuel filter element. X X X
Inspect brake linings. X X
Inspect and adjust parking brake if necessary. X X
Inspect front wheel bearings. X
SCHEDULE “A” 507
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 82,500 90,000 97,500 100,000 105,000
(Kilometers) (132 000) (144 000) (156 000) (160 000) (168 000)
[Months] [66] [72] [78] [84]
Change engine oil and engine oil filter. X X
Lubricate Front Drive Shaft Fitting (2500/3500, 4X4). X X X X
Rotate tires. X X X X
Check spare tire for proper pressure and correct stowage. X X X X
Lubricate outer tie rod ends 2500/3500 (4X4) models. X X X X
Flush and replace engine coolant, if not replaced at 60 mos. X
Check transfer case fluid level (4X4). X
Inspect drive belt, replace as required. X
Replace fuel filter element. X X
Inspect front wheel bearings. X
Inspect brake linings. X
Inspect and adjust parking brake if necessary. X
Drain and refill automatic transmission fluid. Replace filter
and adjust bands (48 RE only).X
508 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 112,500 120,000 127,500 135,000 142,500 150,000
(Kilometers) (181 000) (193 000) (205 000) (217 000) (229 000) (241 000)
[Months] [90] [96] [102] [108] [114] [120]
Inspect front wheel bearings. X X
Inspect brake linings. X X
Inspect and adjust parking brake if necessary. X X
Adjust valve lash clearance.X
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent
mechanic.
510 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 7,500 15,000 22,500 30,000 37,500
(Kilometers) (12 000) (24 000) (36 000) (48 000) (60 000)
[Months] [6] [12] [18] [24] [30]
Inspect fan hub.X
Inspect damper.X
Inspect front wheel bearings. X
Inspect drive belt, replace as necessary. X
SCHEDULE “A” 515
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 45,000 52,500 60,000 67,500 75,000
(Kilometers) (72 000) (84 000) (97 000) (109 000) (121 000)
[Months] [36] [42] [48] [54] [60]
Inspect drive belt, replace as necessary. X X
Replace fuel filter element. X X X
Inspect brake linings. X X
Inspect and adjust parking brake if necessary. X X
Inspect fan hub. X
Inspect damper. X
Inspect front wheel bearings. X
Replace Crankcase Ventilation Filter (CCV).X
Clean or replace (if necessary), EGR Valve.X
Clean or replace (if necessary), EGR Cooler.X
SCHEDULE “A” 517
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 82,500 90,000 97,500 100,000 105,000
(Kilometers) (133 000) (145 000) (157 000) (160 000) (169 000)
[Months] [66] [72] [78] [84]
Inspect front wheel bearings. X
Inspect brake linings. X X
Inspect and adjust parking brake if necessary. X X
SCHEDULE “A” 519
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 112,500 120,000 127,500 135,000 142,500 150,000
(Kilometers) (181 000) (193 000) (205 000) (217 000) (229 000) (241 000)
[Months] [90] [96] [102] [108] [114] [120]
Drain and refill automatic transmission fluid
and change main sump filter and spin-on
cooler filter (if equipped).XX
Change manual transmission fluid. X
Inspect fan hub. X X
Inspect damper. X X
Replace fuel filter element. X X X
Inspect front wheel bearings. X X
Inspect brake linings. X X
Inspect and adjust parking brake if necessary. X X
Adjust valve lash clearance.X
Replace Crankcase Ventilation Filter (CCV).X
Clean or replace (if necessary), EGR Valve.X
Clean or replace (if necessary), EGR Cooler.X
SCHEDULE “A” 521
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel than the minimum required by law.WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
IF YOU NEED CONSUMER ASSISTANCE 531
9

Car Washes............................ 463
Carbon Monoxide Warning............... 76,190
CargoLight ............................ 132
Cassette Tape and Player Maintenance......... 255
Catalyst Full Message..................... 434
CD (Compact Disc) Player............209,217,231
Cellular Phone.......................... 89
Center High Mounted Stop Light............ 481
Center Lap Belts......................... 43
Center Seat Storage Compartment.........176,177
Certification Label....................... 355
Charge Air Cooler....................... 450
Chart, Tire Sizing........................ 327
Check Engine Light
(Malfunction Indicator Light)............... 202
Child Restraint........................ 60,61
Child Restraint Tether Anchors............. 65,69
Child Seat............................ 61,68
Cigar Lighter........................... 171Cleaning
Wheels............................. 465
Climate Control......................... 257
Clock .....................207,211,219,232,245
Clutch Linkage Maintenance................ 453
Compact Disc (CD) Maintenance............. 256
Compact Spare Tire...................... 338
Compass...........................146,147
Compass Calibration..................147,158
Compass Variance....................148,158
Computer, Trip/Travel.................... 143
Console, Overhead....................142,150
Contract, Service........................ 526
Coolant Pressure Cap (Radiator Cap).......... 447
Cooling System......................... 444
Adding Coolant (Antifreeze).............. 447
Coolant Capacity...................... 487
Coolant Level...................444,445,448
Disposal of Used Coolant................ 448
536 INDEX

Drain, Flush, and Refill.................. 446
Inspection........................... 448
Points to Remember.................... 449
Pressure Cap......................... 447
Radiator Cap......................... 447
Selection of Coolant (Antifreeze).........446,488
Temperature Gauge..................... 200
Cruise Control (Speed Control).............. 139
CupHolder ............................ 172
Customer Assistance..................... 524
Customer Programmable Features............ 153
Data Recorder, Event...................... 58
Daytime Running Lights................... 131
Dealer Service.......................... 411
Defroster, Rear Window................. 88,181
Defroster, Windshield................ 77,258,261
Delay (Intermittent) Wipers................. 135
Diesel Exhaust Brake..................... 290Diesel Fuel............................ 348
Diesel Fuel Requirements.................. 348
Differential, Limited-Slip.................. 317
Dipsticks .............................. 414
Power Steering........................ 439
Disc Brakes............................ 451
Disposal.............................. 421
Engine Oil........................... 421
Used Coolant (Antifreeze)................ 448
Door Locks............................. 25
Door Locks, Automatic.................... 153
Door Opener, Garage..................... 160
Draining Fuel/Water Separator Filter.......427,430
DriveBelts ............................ 422
Dual Rear Wheels.....................347,396
DVD Player (Video Entertainment System)...... 249
Electric Rear Window Defrost............. 88,181
Electrical Power Outlets................... 169
INDEX 537
10