trailer Ram 2500 (Diesel) 2007 Owner's Guide

NOTE: Fold the7x10inch trailer towing mirrors
rearward prior to entering an automated car wash.
Blindspot Mirror
Trailer Towing Position
372 STARTING AND OPERATING

CAUTION!
Overfilling or underfilling the crankcase will cause
oil aeration or loss of oil pressure. This could damage
your engine.Never operate the engine with oil level below the “ADD”
mark or above the upper “SAFE” mark.Change Engine Oil (5.9L Diesel Engine)
Road conditions as well as your kind of driving affect the
interval at which your oil should be changed. Check the
following to determine if any apply to you:
•Frequent short trips where the engine does not achieve
full operating temperature (operating temperature de-
fined as 190° F (66° C ) coolant temperature).
•Extensive engine idling (over 10 minutes per hour of
operation) at ambient temperatures less than 32° F (0°
C).
•Driving in dusty conditions.
•Frequent trailer towing.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
MAINTAINING YOUR VEHICLE 415
7

Severe usage consists of:
•Off-the-highway operation;
•Trailer towing;
•Snow plow operation;
•Prolonged operation with heavy loading, especially in
hot weather.
NOTE:If the transmission is disassembled for any
reason, the fluid and filter should be changed, and the
bands adjusted (if equipped).
Special Additives
The manufacturer recommends against the addition of
any additives to the transmission. Exception to this
policy is the use of special dyes to aid in detecting fluid
leaks. The use of transmission sealers should be avoided,
since they may adversely affect seals.
Front Wheel Bearings
Front wheel bearings for all Dodge Ram Trucks are
sealed-for-life. They do not require greasing or seal
replacement. In some instances, these bearings will
“purge” excess grease and the bearing housing will look
slightly wet. This is normal.
•Periodic inspection for excess play is recommended.
•If a bearing assembly is accidentally separated when
servicing the brake rotors, it should be replaced.
Rear Wheel Bearings
Clean and repack when brake linings are replaced or
rotors resurfaced.
Noise Control System Required Maintenance &
Warranty
For 3500 Two-Wheel Drive and Four-Wheel Drive mod-
els over 10,000 lbs. (4 535 kg) Gross Vehicle Weight
Rating.
458 MAINTAINING YOUR VEHICLE

Cavity Cartridge
FuseMini
FuseDescription
8 10 Amp
RedHeated Mirrors
9 30 Amp
PinkOff Road Module
Power
10 5 Amp
OrangeTrx-Off Rd Pkg Sen
(Gas Engine Only)
11 20 Amp
YellowIgnition Off Draw
(IOD)-Cabin Compart-
ment Node (CCN)/
Radio/Under Hood
Lamp/Wireless Control
Module (WCM)/
Satellite Digital Audio
Receiver (SDARS)/
Hands Free Module
(HFM)/EOMCavity Cartridge
FuseMini
FuseDescription
12 30 Amp
PinkElectric Brake
13 25 Amp
NaturalPower-Battery RWAL/
ABS Module Feed
14 15 Amp
BluePark Lamps Left
15 20 Amp
YellowTrailer Park Lamps
16 15 Amp
BluePark Lamps Right
17 15 Amp
BlueSpare
18 40 Amp
GreenABS Pump
19 30 Amp
PinkTrailer Tow Battery
Feed
MAINTAINING YOUR VEHICLE 469
7

EMISSION CONTROL SYSTEM MAINTENANCE
The “Scheduled” maintenance services, listed inbold
typein this section (Section 8) must be done at the times
or mileages specified to assure the continued proper
functioning of the emission control system. These, and all
other maintenance services included in this manual,
should be done to provide best vehicle performance and
reliability. More frequent maintenance may be needed for
vehicles in severe operating conditions such as dusty
areas and very short trip driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES — 5.9L TURBO
DIESEL
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under one or more of the following conditions that are
listed below and at the beginning of the schedule.
•Frequent short trips where the engine does not achieve
full operating temperature (operating temperature de-
fined as 190° F (66° C ) coolant temperature).
•Extensive engine idling (over 10 minutes per hour of
operation) at ambient temperatures less than 32° F (0°
C).
•Driving in dusty conditions.
•Frequent trailer towing.
•Taxi, police, or delivery service (commercial service).
494 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Schedule “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions.
•Frequent short trips where the engine does not achieve
full operating temperature (operating temperature de-
fined as 190° F (66° C ) coolant temperature).
•Extensive engine idling (over 10 minutes per hour of
operation) at ambient temperatures less than 32° F (0°
C).
•Driving in dusty conditions.
•Frequent trailer towing.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
•Extensive operation at high engine speeds (greater
than 2900 rpm) and loads (greater than 70% throttle).
NOTE:IfANYof these apply to you then change your
coolant every 100,000 miles (160 000 km) or 60 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
SCHEDULE “B” 497
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 45,000 52,500 60,000 67,500 75,000
(Kilometers) (72 000) (84 000) (97 000) (109 000) (121 000)
[Months] [36] [42] [48] [54] [60]
Change engine oil and engine oil filter. X X X X X
Lubricate Front Drive Shaft Fitting (4X4). X X X X X
Rotate tires. X X X X X
Check spare tire for proper pressure and correct
stowage.X X XXX
Lubricate outer tie rod ends. X X X X X
Drain and refill transfer case fluid (4X4). X
Change front and rear axle fluid (4X4). X X X
Drain and refill automatic transmission fluid,
change main sump filter and spin-on cooler filter
(if equipped). If your vehicle is used for police,
taxi, fleet or frequent trailer towing.X
Change manual transmission fluid. X
Flush and replace engine coolant at 60 months, if
not replaced at 100,000 miles (160 000 km).X
516 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

General Information.................... 18,114
Glass Cleaning.......................... 466
Grocery Bag Retainer..................... 181
Gross Axle Weight Rating.................. 359
Gross Vehicle Weight Rating................ 358
GVWR ............................... 355
Hands-Free Phone (UConnect™).............. 89
Hazard Warning Flasher................... 386
Head Restraints......................... 117
Headlights............................ 474
High Beam........................... 134
High Beam/Low Beam Select Switch........ 134
Lights On Reminder.................... 132
Passing............................. 134
Switch .............................. 130
Heated Mirrors....................... 88,181
Heated Seats........................... 125
Heater............................... 259High Beam/Low Beam Select (Dimmer) Switch . . 134
Hitches
TrailerTowing ........................ 362
Hoisting .............................. 398
HomeLink(Garage Door Opener) Transmitter . . . 160
Hood Release.......................... 127
Hoses.............................451,453
Hub Caps............................. 394
Hydraulic Clutch Fluid.................... 453
Ignition............................... 12
Key ................................. 12
Ignition Key Removal..................... 12
Illuminated Entry........................ 19
Infant Restraint........................ 60,61
Inflation Pressure Tires.................... 343
Information Center...................... 151
Information Center, Vehicle................. 151
Inside Rearview Mirror.................... 84
540 INDEX

Schedule “A”......................... 506
Manual, Service......................... 528
Manual Transmission..................303,455
Fluid Level Check...................... 455
Lubricant Selection..................... 491
Shift Speeds.......................... 304
Map/Reading Lights..................... 150
Mirrors ................................ 84
Automatic Dimming..................... 85
Electric Powered....................... 87
Outside.............................. 86
Rearview............................. 84
TrailerTowing ...................... 88,371
Modifications/Alterations, Vehicle............. 8
Mopar Parts.........................410,527
Multi-Function Control Lever............... 133
Navigation Radio........................ 245
Navigation System....................... 245New Vehicle Break-In Period................ 74
Noise Control
Maintenance.......................... 459
Tampering Prohibited................... 460
Noise Emission Warranty...............458,461
Occupant Restraints....................... 33
Occupant Restraints (2500/3500/Mega Cab Only) . . 33
Odometer..........................201,206
Trip .............................201,206
Off-Pavement Driving (Off-Road)............ 319
Off-Road Driving (Off-Pavement)............ 319
Oil Change Indicator................153,156,512
Oil Change Indicator, Reset................. 153
Oil, Engine............................ 488
Capacity............................ 487
Change Interval....................415,416
Dipstick............................. 414
Disposal............................ 421
INDEX 543
10

Tongue Weight/Trailer Weight.............. 363
Torque Converter Clutch................296,302
Tow Hooks, Emergency................... 403
Tow/Haul............................. 294
Towing ............................... 358
Disabled Vehicle....................... 404
Guide .............................. 363
Recreational.......................... 377
Weight .............................. 363
Traction.............................. 318
Traction Control......................... 455
TrailerTowing .......................... 358
Cooling System Tips.................... 371
Hitches............................. 362
Minimum Requirements................. 364
Mirrors ........................... 88,371
Trailer and Tongue Weight................ 363
Wiring .............................. 368
TrailerTowingGuide ..................... 363TrailerWeight .......................... 363
Transaxle
Automatic............................ 12
Manual.............................. 14
Transfer Case
Electronically Shifted.................... 310
Fluid ............................... 491
Transmission
Automatic......................291,297,455
Fluid ............................... 491
Maintenance.......................... 455
Manual........................275,303,455
Shifting ............................. 291
Transmitter Battery Service (Remote Keyless Entry) . 24
Transmitter, Garage Door Opener (HomeLink) . . 160
Tread Wear Indicators.................... 340
Trip Computer.......................... 143
Trip Odometer.......................201,206
Turn Signals...................133,199,474,478
INDEX 549
10