transmission Ram 2500 (Diesel) 2007 Manual Online

Miles 82,500 90,000 97,500 100,000 105,000
(Kilometers) (132 000) (144 000) (156 000) (160 000) (168 000)
[Months] [66] [72] [78] [84]
Change engine oil and engine oil filter. X X
Lubricate Front Drive Shaft Fitting (2500/3500, 4X4). X X X X
Rotate tires. X X X X
Check spare tire for proper pressure and correct stowage. X X X X
Lubricate outer tie rod ends 2500/3500 (4X4) models. X X X X
Flush and replace engine coolant, if not replaced at 60 mos. X
Check transfer case fluid level (4X4). X
Inspect drive belt, replace as required. X
Replace fuel filter element. X X
Inspect front wheel bearings. X
Inspect brake linings. X
Inspect and adjust parking brake if necessary. X
Drain and refill automatic transmission fluid. Replace filter
and adjust bands (48 RE only).X
508 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

MAINTENANCE SCHEDULES — 6.7L TURBO
DIESEL
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 30 minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required. When refilling the washer fluid reservoir,
take some washer fluid and apply it to a cloth or towel
and wipe clean the wiper blades, this will help blade
performance.Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the batteries and clean and tighten the termi-
nals as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and transfer case (if
equipped), add as needed.
•Check Filter Minder™. Replace air cleaner filter
element if necessary.
•Check all lights and all other electrical items for correct
operation.
•Drain water from the fuel filter.
SCHEDULE “A” 511
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the U-Joints ( if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the manual transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Lubricate outer tie rod ends (4X4) models only.
•Lubricate Front Drive Shaft Fitting ( 4X4).
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
Oil Change Indicator System
Your vehicle is equipped with an engine oil change
indicator system. This system will alert you when it is
time to change your engine oil by displaying the words
“Oil Change Required” on your Electronic Vehicle Infor-
mation Center (EVIC). The engine oil change indicator
system is duty cycle based, which means the engine oil
change interval may fluctuate depending on your per-
sonal driving style. Driving styles such as frequent stop
and go type driving can increase the frequency of the
engine oil change. This is the result of more frequent
regeneration of the exhaust aftertreatment system, which
can decrease the life of the engine oil. Failure to change
the engine oil per the maintenance schedule can result in
internal engine damage.
512 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 45,000 52,500 60,000 67,500 75,000
(Kilometers) (72 000) (84 000) (97 000) (109 000) (121 000)
[Months] [36] [42] [48] [54] [60]
Change engine oil and engine oil filter. X X X X X
Lubricate Front Drive Shaft Fitting (4X4). X X X X X
Rotate tires. X X X X X
Check spare tire for proper pressure and correct
stowage.X X XXX
Lubricate outer tie rod ends. X X X X X
Drain and refill transfer case fluid (4X4). X
Change front and rear axle fluid (4X4). X X X
Drain and refill automatic transmission fluid,
change main sump filter and spin-on cooler filter
(if equipped). If your vehicle is used for police,
taxi, fleet or frequent trailer towing.X
Change manual transmission fluid. X
Flush and replace engine coolant at 60 months, if
not replaced at 100,000 miles (160 000 km).X
516 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 112,500 120,000 127,500 135,000 142,500 150,000
(Kilometers) (181 000) (193 000) (205 000) (217 000) (229 000) (241 000)
[Months] [90] [96] [102] [108] [114] [120]
Drain and refill automatic transmission fluid
and change main sump filter and spin-on
cooler filter (if equipped).XX
Change manual transmission fluid. X
Inspect fan hub. X X
Inspect damper. X X
Replace fuel filter element. X X X
Inspect front wheel bearings. X X
Inspect brake linings. X X
Inspect and adjust parking brake if necessary. X X
Adjust valve lash clearance.X
Replace Crankcase Ventilation Filter (CCV).X
Clean or replace (if necessary), EGR Valve.X
Clean or replace (if necessary), EGR Cooler.X
SCHEDULE “A” 521
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................... 352
Adjustable Pedals....................... 138
Air Cleaner, Engine
(Engine Air Cleaner Filter)............422,424,460
Air Conditioner Maintenance............... 438
Air Conditioning Refrigerant.............438,439
Air Conditioning System................259,438
Air Conditioning System, Zone Control........ 262
AirFilter ...........................422,424
Air Pressure, Tires....................335,343
Airbag.............................. 46,52
Airbag Light......................... 77,199
Airbag On/Off Switch..................... 52
Airbag, Side............................ 55
Alarm, Out of Park Sense...............296,302
Alarm, Panic............................ 23
Alarm (Security Alarm)................. 18,201
Alarm System (Security Alarm)............... 18
Alignment and Balance................... 342Alterations/Modifications, Vehicle............. 8
Antenna, Satellite Radio................... 252
Antifreeze (Engine Coolant)..............446,447
Capacities........................... 487
Anti-Lock Warning Light...............204,324
Anti-Theft Security Alarm (Theft Alarm)........ 18
Anti-Theft System..................... 18,201
Appearance Care........................ 463
Ashtray............................... 171
AutomaticDimmingMirror ................. 85
Automatic Door Locks.................... 153
Automatic Transaxle...................... 12
Interlock System........................ 15
Automatic Transmission................... 455
Adding Fluid......................... 456
Fluid and Filter Changes................. 457
Fluid Level Check...................... 455
FluidType ........................457,491
Shift Indicator........................ 201
534 INDEX

Filters
Engine Oil.....................414,419,488
Flashers
Turn Signal.......................... 133
Flat Tire Stowage.....................388,398
Fluid, Brake........................... 491
Fluid Capacities......................... 487
Fluid Level Checks
Brake............................... 452
Manual Transmission................... 455
Power Steering........................ 439
Transfer Case......................... 455
Fluids, Lubricants and Genuine Parts.......... 488
Fog Lights.......................132,202,477
Fold Flat Load Floor..................... 183
Four Wheel Drive....................... 306
Four-Way Hazard Flasher.................. 386
Freeing A Stuck Vehicle................... 402
Front Axle (Differential)................441,454Fuel..............................348,352
Adding............................. 352
Diesel......................348,350,352,488
Gauge.............................. 206
Light ............................... 206
Requirements......................348,350
Specifications......................349,351
Tank Capacity........................ 487
Fuses................................ 468
Garage Door Opener (HomeLink) ........... 160
Gauges............................... 198
Coolant Temperature.................... 200
Fuel................................ 206
Oil Pressure.......................... 200
Speedometer......................... 199
Tachometer.......................... 199
Voltmeter.........................198,282
Gear Ranges......................291,297,304
INDEX 539
10

Fog ..........................132,202,477
Four-Wheel Drive Indicator............... 309
Hazard Warning Flasher................. 386
Headlights........................... 130
High Beam........................134,199
High Beam Indicator.................... 199
High Beam/Low Beam Select............. 134
Illuminated Entry....................... 19
Instrument Cluster..................... 198
Intensity Control....................... 129
Interior..........................129,142
Lights On Reminder.................... 132
Passing............................. 134
Reading............................. 150
Seat Belt Reminder..................... 199
Service...........................473,474
Side Marker.......................... 486
Transfer Case......................... 309
Transmission Warning................... 205Turn Signal..................133,199,474,478
Warning (Instrument Cluster Description)..... 198
Limited-Slip Differential................317,454
Loading Vehicle......................... 355
Tires ............................... 330
Locks................................. 25
Child Protection........................ 29
Door................................ 25
Keys................................ 12
Power Door........................... 26
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 65
Lubrication, Body....................... 441
LugNuts ............................. 394
Lumbar Support........................ 118
Maintenance........................... 411
Maintenance Procedures................... 414
Maintenance Schedule..................494,511
542 INDEX

Schedule “A”......................... 506
Manual, Service......................... 528
Manual Transmission..................303,455
Fluid Level Check...................... 455
Lubricant Selection..................... 491
Shift Speeds.......................... 304
Map/Reading Lights..................... 150
Mirrors ................................ 84
Automatic Dimming..................... 85
Electric Powered....................... 87
Outside.............................. 86
Rearview............................. 84
TrailerTowing ...................... 88,371
Modifications/Alterations, Vehicle............. 8
Mopar Parts.........................410,527
Multi-Function Control Lever............... 133
Navigation Radio........................ 245
Navigation System....................... 245New Vehicle Break-In Period................ 74
Noise Control
Maintenance.......................... 459
Tampering Prohibited................... 460
Noise Emission Warranty...............458,461
Occupant Restraints....................... 33
Occupant Restraints (2500/3500/Mega Cab Only) . . 33
Odometer..........................201,206
Trip .............................201,206
Off-Pavement Driving (Off-Road)............ 319
Off-Road Driving (Off-Pavement)............ 319
Oil Change Indicator................153,156,512
Oil Change Indicator, Reset................. 153
Oil, Engine............................ 488
Capacity............................ 487
Change Interval....................415,416
Dipstick............................. 414
Disposal............................ 421
INDEX 543
10

Automatic Transmission...............291,297
Manual Transmission................... 303
Transfer Case......................... 308
Transfer Case, Shifting into Transfer Case
Neutral (N).........................378,380
Transfer Case, Shifting out of Transfer Case
Neutral (N).........................379,382
Shoulder Belt Upper Anchorage.............. 42
Shoulder Belts........................... 34
Side Airbag............................. 55
Signals, Turn........................... 133
Sliding Rear Window
Power............................ 32,182
Slippery Surfaces, Driving On............... 318
Snow Chains (Tire Chains)................. 343
Snow Plow............................ 373
Snow Tires............................ 345
Soot Filter............................. 434
Spare Tire............................. 338Speed Control (Cruise Control).............. 139
Speedometer........................... 199
Starting............................... 275
Automatic Transmission................. 276
Engine Block Heater.................276,283
Manual Transmission................... 275
Starting Procedures...................... 275
Starting Procedures (Diesel Engines).......... 275
Steering
Linkage............................. 440
Power...........................324,439
Wheel Lock........................... 15
Wheel, Tilt........................... 137
Steering Wheel Mounted Sound System Controls . 253
Storage, Behind the Seat................... 176
Storage Compartment, Center Seat.........176,177
Storage, Vehicle......................... 472
StoringYourVehicle ...................... 472
Sun Roof.............................. 166
INDEX 547
10