flat tire Ram 3500 2015 Service Manual

WARNING!(Continued)
•Turn on the Hazard Warning flasher.
• Block the wheel diagonally opposite the wheel to
be raised.
• Set the parking brake firmly and set an automatic
transmission in PARK; a manual transmission in
REVERSE.
• Never start or run the engine with the vehicle on a
jack.
• Do not let anyone sit in the vehicle when it is on a
jack.
• Do not get under the vehicle when it is on a jack. If
you need to get under a raised vehicle, take it to a
service center where it can be raised on a lift.
• Only use the jack in the positions indicated and for
lifting this vehicle during a tire change.
(Continued)
WARNING! (Continued)
•If working on or near a roadway, be extremely
careful of motor traffic.
• To assure that spare tires, flat or inflated, are
securely stowed, spares must be stowed with the
valve stem facing the ground.
Jack Warning Label
712 WHAT TO DO IN EMERGENCIES

5. Remove the wheel nuts and pull the wheel off. Onsingle rear-wheel (SRW) trucks, install the spare wheel
and wheel nuts with the cone shaped end of the wheel
nuts toward the wheel. On 3500 dual rear-wheel
models (DRW) trucks, if the outer tire is being re-
placed then leave the inner wheel on the vehicle. If the
inner wheel is being replaced remove the outer wheel
and replace the inner wheel. The wheel nuts are a
two-piece assembly with a flat face. Lightly tighten the
wheel nuts. To avoid the risk of forcing the vehicle off
the jack, do not fully tighten the wheel nuts until the
vehicle has been lowered.
Rear Inner Wheel Proper Placement (Dual Rear Wheel
Equipped)
6
WHAT TO DO IN EMERGENCIES 717

7. Install the wheel center cap and remove the wheelblocks. Do not install chrome or aluminum wheel
center caps on the spare wheel. This may result in cap
damage.
8. Lower the jack to its fully closed position. Stow the replaced tire, jack, and tools as previously described.
NOTE: If the bottle jack will not lower by turning the dial
(thumbwheel) by hand, it may be necessary to use the
jack drive tube in order to lower the jack.
9. Adjust the tire pressure when possible.
NOTE: Do not oil wheel studs. For chrome wheels, do
not substitute with chrome plated wheel nuts.To Stow The Flat Or Spare
NOTE: Have the flat tire repaired or replaced immedi-
ately.
WARNING!
A loose tire thrown forward in a collision or hard
stop could injure the occupants in the vehicle. Have
the deflated (flat) tire repaired or replaced immedi-
ately.
6
WHAT TO DO IN EMERGENCIES 719

1. Turn the wheel so that the valve stem is facing theground and toward the rear of the vehicle for conve-
nience in checking the spare tire inflation. Slide the
wheel retainer through the center of the wheel. 2. Lift the spare tire with one hand to give clearance to
tilt the retainer at the end of the cable and position it
properly across the wheel opening.
Reinstalling The Retainer
Pushing The Retainer Through The Center Of The
Wheel And Positioning It
720 WHAT TO DO IN EMERGENCIES

You must use the flat end of the lug wrench to pull off the
wheel skins. Locate the hub cap pull notches (2 notches
on each cap). Insert the flat tip completely and using a
back and forth motion, loosen the wheel skin. Repeat this
procedure around the tire until the skin pops off.
Replace the wheel skins first using a rubber mallet. When
replacing the hub caps, tilt the cap retainer over the lug
nut bolt circle and strike the high side down with a
rubber mallet. Be sure that the hub caps and wheel skins
are firmly seated around the wheel.
HOISTING
A conventional floor jack may be used at the jacking
locations. Refer to the graphics that show jacking loca-
tions. However, a floor jack or frame hoist must never be
used on any other parts of the underbody.
CAUTION!
Never use a floor jack directly under the differential
housing of a loaded truck or damage to your vehicle
may result.
JUMP-STARTING PROCEDURES
If your vehicle has a discharged battery it can be jump-
started using a set of jumper cables and a battery in
another vehicle or by using a portable battery booster
pack. Jump-starting can be dangerous if done improperly
so please follow the procedures in this section carefully.
NOTE:When using a portable battery booster pack
follow the manufacturer ’s operating instructions and
precautions.
6
WHAT TO DO IN EMERGENCIES 725

Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel, than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
840 IF YOU NEED CONSUMER ASSISTANCE

Break-In Recommendations................113
Compartment ......................... .744
Compartment Identification .........744, 745, 746
Coolant (Antifreeze) .....................817
Exhaust Gas Caution .................114,632
Flooded, Starting ...................... .445
Fuel Requirements ...................627, 815
Jump Starting ......................... .725
Oil .......................... .751, 815, 817
Oil Filler Cap ...................... .753, 754
Oil Selection ...................... .752, 815
Oil Synthetic ......................... .754
Overheating .......................... .679
Engine Oil Viscosity ....................753, 754
Engine Oil Viscosity Chart ...................753
Enhanced Accident Response Feature ............78
Entry System, Illuminated ....................24
Ethanol ............................... .629
Event Data Recorder ........................81 Exhaust Gas Caution
....................114,632
Exhaust System .......................114,768
Exterior Lighting ......................... .165
Exterior Lights ...........................117
Filters Air Cleaner .......................... .755
Engine Oil ........................ .754, 817
Engine Oil Disposal .....................754
Flashers Turn Signal .....................117, 175, 285
Flat Tire Stowage ..................... .698, 719
Flexible Fuel Vehicles Cruising Range ........................ .635
Engine Oil ........................... .634
Fuel Requirements ...................633, 634
Maintenance .......................... .636
Replacement Parts ...................... .635
Starting ............................. .635
10
INDEX 847

Glass Cleaning.......................... .791
Grocery Bag Retainer ...................... .242
Gross Axle Weight Rating ...................642
Gross Vehicle Weight Rating ..................641
Guide, Body Builders ........................6
GVWR ................................ .639
Hazard Driving Through Flowing, Rising, or Shallow
Standing Water ........................ .547
Hazard Warning Flasher ....................679
Headlights ............................. .806
Automatic ........................... .166
Cleaning ............................ .791
High Beam ........................... .176
High Beam/Low Beam Select Switch .........176
Passing ............................. .176
Switch .............................. .165
Head Restraints ......................... .154Heated Mirrors
...................... .139, 242
Heater ............................. .395, 400
Heater, Engine Block ...................... .451
High Beam/Low Beam Select (Dimmer) Switch . . . .176
Hill Descent Control ...................... .587
Hill Descent Control Indicator ................587
Hitches Trailer Towing ........................ .648
Hoisting ............................... .725
HomeLink® (Garage Door Opener) .............211
Hood Release ........................... .163
Hub Caps .............................. .724
Ignition .................................16
Key .............................. .12, 16
Ignition Key Removal .......................16
Illuminated Entry ..........................24
Immobilizer (Sentry Key) ....................19
Inflation Pressure Tires .....................613
10
INDEX 849

Tachometer............................. .285
Tailgate ............................... .265
Temperature Control, Automatic (ATC) ..........413
Tilt Steering Column ...................... .180
Tip Start ............................... .443
Tire and Loading Information Placard . . . .597, 598, 613
Tire Markings ........................... .591
Tires............................117, 601, 839
Aging (Life of Tires) .....................611
Air Pressure .......................... .601
Chains .............................. .613
Compact Spare ........................ .608
Dual ............................ .617, 680
General Information .....................601
High Speed .......................... .604
Inflation Pressures ...................... .602
Life of Tires ...........................611
Load Capacity ..................... .597, 598
Pressure Monitor System (TPMS) ............619Pressure Warning Light
...................285
Quality Grading ....................... .839
Radial .............................. .604
Replacement ...........................611
Rotation ............................. .616
Safety ........................... .591, 601
Sizes ............................... .592
Snow Tires ........................... .606
Spinning ............................ .610
Tread Wear Indicators ....................610
Tire Safety Information .....................591
Tongue Weight/Trailer Weight ................650
Tonneau Cover .......................... .792
Tonneau Cover Cleaning ....................792
Torque Converter Clutch .................475, 486
Tow Hooks, Emergency .....................732
Towing ............................ .641,
737
Disabled Vehicle ....................... .737
Guide .............................. .649
858 INDEX