fuel filter Ram 3500 2016 Owner's Manual

When towing a loaded trailer up steep grades at low
speeds (20 mph [32 km/h] or below), holding your
vehicle in first gear (using the ERS shift control) can help
to avoid transmission overheating.
If you regularly tow a trailer for more than 45 minutes of
continuous operation, then change the automatic trans-
mission fluid and filter(s) as specified forpolice, taxi,
fleet, or frequent trailer towing. Refer to the “Mainte-
nance Schedule” for the proper maintenance intervals.
NOTE: Check the automatic transmission fluid level
before towing (6-speed automatic only).
Tow/Haul Mode
To reduce potential for automatic transmission overheat-
ing, activate TOW/HAUL mode when driving in hilly
areas, or select a lower gear range (using the Electronic
Range Select (ERS) shift control) on more severe grades.
Electronic Speed Control — If Equipped
• Do not use in hilly terrain or with heavy loads.
• When using the speed control, if you experience speed
drops greater than 10 mph (16 km/h), disengage until
you can get back to cruising speed.
• Use speed control in flat terrain and with light loads to
maximize fuel efficiency.
Cooling System
To reduce potential for engine and transmission over-
heating, take the following actions:
City Driving
When stopped for short periods of time, shift the trans-
mission into NEUTRAL and increase engine idle speed.
Highway Driving
Reduce speed.
710 STARTING AND OPERATING

MAINTAINING YOUR VEHICLE
CONTENTS
ENGINE COMPARTMENT — 3.6L ..........790
 ENGINE COMPARTMENT — 5.7L ..........791
 ENGINE COMPARTMENT — 6.4L ..........792
 ONBOARD DIAGNOSTIC SYSTEM (OBD II) . . .793
▫ Onboard Diagnostic System (OBD II)
Cybersecurity ....................... .793
▫ Loose Fuel Filler Cap Message ............794
 EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS ......................... .795
 REPLACEMENT PARTS ..................796 
DEALER SERVICE ..................... .797
 MAINTENANCE PROCEDURES ...........797
▫ Engine Oil ......................... .798
▫ Engine Oil Filter ..................... .802
▫ Engine Air Cleaner Filter ................802
▫ Accessory Drive Belt Inspection ...........806
▫ Maintenance-Free Battery ...............808
▫ Air Conditioner Maintenance .............809
▫ Front Driveshaft Lubrication — 2500/3500
(Four-Wheel Drive Models Only) ..........810
7

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
1500 Regular Cab Shortbed/Crew Quad Cab Models 26 Gallons98 Liters
1500 Regular Cab Longbed/Crew Quad Cab Models (Optional) 32 Gallons 121 Liters
2500/3500 Shortbed Models 31 Gallons117 Liters
2500/3500 Longbed Models 32 Gallons121 Liters
Engine Oil With Filter
3.6L Engine (We recommend you use SAE 5W-20, API Certified) 6 Quarts5.6 Liters
5.7L Engines (We recommend you use SAE 5W-20, API Certified) 7 Quarts 6.6 Liters
5.7L Engine (We recommend you use SAE 5W-30, API Certified),
for 2500/3500 trucks operating under a gross combined weight
rating greater than 14,000 lbs (6 350 kg). 7 Quarts
6.6 Liters
6.4L Engines (We recommend you use SAE 0W-40 engine oil
meeting the requirements of FCA Material Standard MS-12633 for
use in all operating temperatures.) 7 Quarts
6.6 Liters
864 MAINTAINING YOUR VEHICLE

ComponentFluid, Lubricant, or Genuine Part
Engine Oil Filter We recommend you use MOPAR brand Engine Oil
Filters.
Spark Plugs We recommend you use MOPAR Spark Plugs.
Fuel Selection – 3.6L Engine 87 Octane, 0-15% Ethanol.
Fuel Selection – 3.6L Flex Fuel (E-85) Engine – If
Equipped 87 Octane, Up To 85% Ethanol.
Fuel Selection – 5.7L/6.4L Engines 89 Octane Recommended - 87 Octane Acceptable, 0-15%
Ethanol.
868 MAINTAINING YOUR VEHICLE

Adding Engine Coolant (Antifreeze)............820
Adding Fuel ............................ .684
Additives, Fuel .......................... .679
Adjust Down .............................. .148
Forward ......................... .148, 150
Rearward ........................ .148, 150
Up ................................ .148
Adjustable Pedals ........................ .189
AirBag.................................71 Advance Front Air Bag ....................73
Air Bag Operation .......................74
Air Bag Warning Light ....................82
Enhanced Accident Response ................81
Event Data Recorder (EDR) .................84
FrontAirBag...........................71
If A Deployment Occurs ...................80
Knee Impact Bolsters .....................75
Maintaining Your Air Bag System ............83Side Air Bags
...........................75
Transporting Pets .......................117
Air Bag Deployment ........................71
Air Bag Light ..................... .82, 120, 297
Air Bag Maintenance .......................83
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .802
Air Conditioner Maintenance .................809
Air Conditioning ..................... .421, 426
Air Conditioning Controls ................421, 426
Air Conditioning, Operating Tips ...........441, 443
Air Conditioning Refrigerant ..............809, 810
Air Conditioning System ..........421, 426, 439, 809
Air Pressure, Tires .....................649, 660
Air Suspension ....................... .545, 558
Alarm, Panic .............................29
Alarm (Security Alarm) ..................22, 300
Alarm System (Security Alarm) ................22
Alterations/Modifications, Vehicle ...............7
Antifreeze (Engine Coolant) ...............819, 864
896 INDEX

Hazard Warning Flasher..................727
Jump Starting ......................... .771
Tow Hooks ........................... .777
Emission Control System Maintenance ..........795
Engine ............................. .791, 792
Air Cleaner .......................... .802
Block Heater ......................... .486
Break-In Recommendations ................117
Compartment ......................... .790
Compartment Identification .........790, 791, 792
Coolant (Antifreeze) .....................866
Exhaust Gas Caution .................119,680
Flooded, Starting ...................... .480
Fuel Requirements ...................675, 864
Jump Starting ......................... .771
Oil .......................... .798, 864, 866
Oil Filler Cap ......................... .801
Oil Filter ............................ .802
Oil Selection ...................... .799, 864Oil Synthetic
......................... .802
Overheating .......................... .727
Engine Oil Viscosity ....................800, 801
Engine Oil Viscosity Chart ...................800
Enhanced Accident Response Feature ............81
Entry System, Illuminated ....................24
Ethanol ............................ .677, 681
Event Data Recorder ........................84
Exhaust Gas Caution ....................119,680
Exhaust System .......................119,816
Exterior Lighting ......................... .171
Exterior Lights .......................... .122
Filters Air Cleaner .......................... .802
Engine Oil ........................ .802, 866
Engine Oil Disposal .....................802
Flashers Turn Signal .....................122, 181, 326
10
INDEX 901

Multi-Function Control Lever.................181
Navigation System (Uconnect GPS) .............212
New Vehicle Break-In Period .................117
Occupant Restraints ........................52
Octane Rating, Gasoline (Fuel) ................675
Off-Pavement Driving (Off-Road) ...........570, 593
Off-Road Driving (Off-Pavement) ...........570, 593
Oil, Engine ......................... .798, 866
Capacity ............................ .864
Change Interval ....................... .799
Dipstick ............................. .798
Disposal ............................. .802
Filter ............................ .802, 866
Filter Disposal ........................ .802
Identification Logo ..................... .800
Pressure Warning Light ................302, 305
Recommendation ....................799, 864 Synthetic
............................ .802
Viscosity ...................... .800, 801, 864
Oil Filter, Change ........................ .802
Oil Filter, Selection ....................... .802
Oil Pressure Light ..................... .302, 305
Onboard Diagnostic System ..................793
Operating Precautions ..................... .793
Operator Manual (Owner’s Manual) .............4
Outside Rearview Mirrors ...................138
Overdrive .......................... .509, 520
Overdrive OFF Switch ..................509, 520
Overhead Console ........................ .215
Overheating, Engine ...................... .727
Owner’s Manual (Operator Manual) ..........4,890
Paint Care ............................. .833
Panic Alarm ..............................29
Parking Brake ........................... .616
ParkSense System, Rear ..................194, 203
10
INDEX 907