bulb Ram 5500 Chassis Cab 2011 User Guide

▫Exhaust System ..................... 394
▫ Cooling System ..................... 396
▫ Brake System ....................... 401
▫ Rear Axle And 4X4 Front Driving Axle Fluid
Level ............................. 404
▫ Transfer Case ....................... 405
▫ Automatic Transmission ............... 405
▫ Appearance Care And Protection From
Corrosion .......................... 409
 Fuses .............................. 414
▫ Totally Integrated Power Module ......... 414
 Vehicle Storage ....................... 419 
Replacement Bulbs .................... 420
 Bulb Replacement ..................... 420
▫ Dual Or Quad Headlamp/Front Park And
Turn Signal – If Equipped .............. 420
▫ Fog Lamps – If Equipped .............. 422
▫ Center High-Mounted Stoplamp (CHMSL)
With Cargo Lamp .................... 423
▫ Cab Top Clearance Lamps – If Equipped .... 424
 Fluid Capacities ...................... 426
 Fluids, Lubricants And Genuine Parts ....... 427
▫ Engine ............................ 427
▫ Chassis ........................... 428
380 MAINTAINING YOUR VEHICLE

the SELECT button to turn off the message. If the
problem continues, the message will appear the next time
the vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the Malfunction Indicator Light (MIL).
EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS
In some localities, it may be a legal requirement to pass
an inspection of your vehicle’s emissions control system.
Failure to pass could prevent vehicle registration.For states that require an Inspection and Mainte-
nance (I/M), this check verifies the “Malfunction
Indicator Light (MIL)” is functioning and is not
on when the engine is running, and that the OBD II
system is ready for testing. Normally, the OBD II system will be ready. The OBD II
system may
notbe ready if your vehicle was recently
serviced, recently had a dead battery or a battery replace-
ment. If the OBD II system should be determined not
ready for the I/M test, your vehicle may fail the test.
Your vehicle has a simple ignition key-actuated test,
which you can use prior to going to the test station. To
check if your vehicle’s OBD II system is ready, you must
do the following:
1. Turn the ignition switch to the ON position, but do not
crank or start the engine.
2. If you crank or start the engine, you will have to start
this test over.
3. As soon as you turn the ignition switch to the ON
position, you will see the MIL symbol come on as part of
a normal bulb check.
7
MAINTAINING YOUR VEHICLE 383

REPLACEMENT BULBS
LIGHT BULBS – InteriorBulb No.
Overhead Console Lamps ............... TS212-2
Dome Lamp ........................... 7679
NOTE: For lighted switches, see your authorized dealer
for replacement instructions.
All of the inside bulbs are brass or glass-wedge base.
Aluminum base bulbs are not approved.
LIGHT BULBS – Exterior Bulb No.
Center High Mounted Stop Lamp (CHMSL) ..... 921
Fog Lamp ............................. 9145
Dual Headlamp ......................... H13
Quad Headlamp – Low Beam ............... H11
Quad Headlamp – High Beam ..............9005
Side Marker (Dual Headlamp) .............3157K
Side Marker (Quad Headlamp) ............3157NA
Rear Cargo Lamp ........................ 921
Cab Roof Marker Lamps .................194NA
BULB REPLACEMENT
Dual or Quad Headlamp/Front Park and Turn
Signal – If Equipped
1. Open the hood.
2. Disconnect and isolate the negative battery cable.
3. Remove the four plastic push-in fasteners that secure
the upper radiator seal to the grille support and both
fender ledges.
4. Remove the two plastic push-in rivets that secure the
upper radiator seal to the radiator.
5. Remove the upper radiator seal from the vehicle.
6. Remove the two headlamp assembly attachment
screws.
420 MAINTAINING YOUR VEHICLE

10. Disconnect electrical connectors.
11. Replace bulb(s) as necessary.
CAUTION!
•Do not contaminate the bulb glass by touching it
with your fingers or by allowing it to contact other
oily surfaces. Shortened bulb life will result.
•Always use the correct bulb size and type for
replacement. An incorrect bulb size or type may
overheat and cause damage to the lamp, the bulb
socket, or the lamp wiring.
NOTE: There are access covers over both headlamp
bulb access holes in the quad front lamp unit housing (if
equipped). These covers MUST be reinstalled after the
bulb has been replaced.
Fog Lamps – If Equipped
1. Reach under and behind the front bumper to access
the back of the front fog lamp housing.
2. Disconnect the fog lamp wiring harness connector
from the fog lamp bulb.
3. Rotate the bulb counterclockwise
14turn to unlock the
bulb from the housing.
4. Pull the bulb straight out from the housing.
CAUTION!
Do not contaminate the bulb glass by touching it
with your fingers or by allowing it to contact other
oily surfaces. Shortened bulb life will result.
422 MAINTAINING YOUR VEHICLE

Center High-Mounted Stoplamp (CHMSL) With
Cargo Lamp
1. Remove the two screws holding the housing/lens to
the body as shown.2. Separate the connector holding the housing and wir-
ing harness to the body.
3. Turn the desired bulb socket
14turn and remove the
socket and bulb from housing.
7
MAINTAINING YOUR VEHICLE 423

4. Pull the desired bulb straight from the socket.
CAUTION!
Do not contaminate the bulb glass by touching it
with your fingers or by allowing it to contact other
oily surfaces. Shortened bulb life will result.
•Outside Bulbs: Cargo Lamps
•Inside Bulb: Center High-Mounted Stop Lamp
5. Reverse the procedure for installation of bulbs and
housing.
Cab Top Clearance Lamps – If Equipped
1. Remove the two screws from the top of the lamp.
424 MAINTAINING YOUR VEHICLE

2. Rotate the socket14turn and pull it from the lamp
assembly. 3. Pull the bulb straight from it’s socket and replace.
7
MAINTAINING YOUR VEHICLE 425

Fluid Level Check................ 405,406,407
Fluid Type ........................ 405,428
Shifting ............................. 270
Special Additives ...................... 408
Axle Fluid ....................... 404,405,428
Axle Lubrication (Axle Fluid) ............404,405
Battery ............................... 389
Keyless Transmitter Replacement (RKE) ....... 24
Saving Feature (Protection) ............... 143
Belts, Seat ............................ 38,74
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 392
B-Pillar Location ........................ 303
Brake Fluid ......................... 402,428
Brake System ........................ 295,401
Anti-Lock (ABS) ....................... 295
Fluid Check .......................... 402
Master Cylinder ....................... 402 Parking
............................. 292
Warning Light ........................ 188
Brake/Transmission Interlock ............... 269
Bulb Replacement ....................... 420
Bulbs, Light .......................... 75,420
Cab Top Clearance Lights .................. 424
Calibration, Compass ..................... 204
Capacities, Antifreeze (Engine Coolant) ........ 426
Capacities, Fluid ........................ 426
Caps, Filler Oil (Engine) .......................... 387
Power Steering ........................ 292
Radiator (Coolant Pressure) ............... 399
Car Washes ............................ 409
Carbon Monoxide Warning ...............74,325
Cargo Light ............................ 142
Cellular Phone .......................... 87
Center High Mounted Stop Light ............ 423
10
INDEX 459

Jack Location........................... 358
Jump Starting .......................... 370
Key, Programming ........................ 17
Key, Replacement ........................ 16
Key, Sentry (Immobilizer) ................... 15
Key-In Reminder ......................... 15
Keyless Entry System ...................... 20
Keys ................................. 12
Knee Bolster ............................ 51
Lane Change and Turn Signals .............. 144
Lane Change Assist ...................... 144
Lap Belts .............................. 47
Lap/Shoulder Belts ....................... 38
LATCH (Lower Anchors and Tether for
CHildren) .............................. 64
Latches ................................ 75
Leaks, Fluid ............................ 76 Life of Tires
............................ 314
Light Bulbs ............................. 75
Lights .............................. 75,138
Airbag ...................... 51,55,59,75,191
Alarm .............................. 183
Anti-Lock ........................... 191
Anti-Lock Warning ..................... 296
Automatic Headlights ................... 139
Brake Warning ........................ 188
Bulb Replacement ...................... 420
Cap Top Clearance ..................... 424
Cargo .............................. 142
Center Mounted Stop ................... 423
Check Engine (Malfunction Indicator) ........ 190
Courtesy/Reading ..................... 154
Daytime Running ...................... 143
Exterior .............................. 75
Fog .......................... 140,191,422
Four-Wheel Drive Indicator ............... 280
10
INDEX 465