oil temperature Ram 5500 Chassis Cab 2011 Owner's Manual

CAUTION!
Driving with a hot engine cooling system could damage
your vehicle. If temperature gauge reads “H” pull over
and stop the vehicle. Idle the vehicle with the air
conditioner turned off until the pointer drops back into
the normal range. If the pointer remains on the “H” and
you hear continuous chimes, turn the engine off imme-
diately, and call an authorized dealership for service.
WARNING!
A hot engine cooling system is dangerous. You or others
could be badly burned by steam or boiling coolant. You
may want to call an authorized dealership for service if
your vehicle overheats. If you decide to look under the
hood yourself, see “Maintaining Your Vehicle”. Follow
the warnings under the Cooling System Pressure Cap
paragraph.
5. Speedometer
The speedometer shows the vehicle speed in miles per
hour and/or kilometers per hour (mph/km/h).
6. 4 LOWThis light alerts the driver that the vehicle is in
the four-wheel drive LOW mode. The front and
rear driveshafts are mechanically locked to-
gether forcing the front and rear wheels to
rotate at the same speed. Low range provides a greater
gear reduction ratio to provide increased torque at the
wheels.
7. Electronic Throttle Control (ETC) Light This light informs you of a problem with the
Electronic Throttle Control (ETC) system. The
light will come on when the ignition is first
turned ON and remain on briefly as a bulb
check. If the light does not come on during starting, have
the system checked by an authorized dealer.
4
UNDERSTANDING YOUR INSTRUMENT PANEL 181

2. Fully depress the accelerator pedal slowly three
times within 10 seconds.
3. Turn the ignition switch to the OFF/LOCK position.
NOTE: If the indicator message illuminates when you
start the vehicle, the oil change indicator system did not
reset. If necessary repeat this procedure.
15. Engine Temperature Warning Light This light warns of an overheated engine condi-
tion. As temperatures rise and the gauge ap-
proaches H,this indicator will illuminate and a
single chime will sound after reaching a set threshold.
Further overheating will cause the temperature gauge to
pass H,the indicator will continuously flash and a
continuous chime will occur until the engine is allowed
to cool.
If the light turns on while driving, safely pull over and
stop the vehicle. If the A/C system is on, turn it off. Also, shift the transmission into NEUTRAL and idle the ve-
hicle. If the temperature reading does not return to
normal, turn the engine off immediately and call for
service. Refer to “If Your Engine Overheats” in “What To
Do In Emergencies” for further information.
For vehicles equipped with a premium cluster this indi-
cator will display in the Electronic Vehicle Information
Center (EVIC). Refer to ”Electronic Vehicle Information
Center (EVIC) — If Equipped” for further information.
16. Shift Lever Indicator
The Shift Lever Indicator is self-contained within the
instrument cluster. It displays the gear position of the
automatic transmission.
NOTE:
In vehicles with a 4.7L or 5.7L engine, the
highest available transmission gear is displayed in the
lower right corner of the Electronic Vehicle Information
Center (EVIC) whenever the Electronic Range Select
(ERS) feature is active. Use the +/- selector on the shift
186 UNDERSTANDING YOUR INSTRUMENT PANEL

27. Transmission Temperature Warning LightThis light indicates that there is excessive trans-
mission fluid temperature that might occur
with severe usage such as trailer towing. It may
also occur when operating the vehicle in a high
torque converter slip condition, such as 4-wheel-drive
operation (e.g., snow plowing, off- road operation). If this
light comes on, stop the vehicle and run the engine at idle
or faster, with the transmission in NEUTRAL until the
light goes off.
CAUTION!
Continuous driving with the Transmission Tempera-
ture Warning Light illuminated will eventually cause
severe transmission damage or transmission failure.
WARNING!
Continued operation with the Transmission Tem-
perature Warning Light illuminated could cause the
fluid to boil over, come in contact with hot engine or
exhaust components causing a fire that may result in
personal injury.
For vehicles equipped with a premium cluster this warn-
ing light will display in the Electronic Vehicle Informa-
tion Center (EVIC). Refer to ”Electronic Vehicle Informa-
tion Center (EVIC) — If Equipped” for further
information.
192 UNDERSTANDING YOUR INSTRUMENT PANEL

•SERV 4WDThe SERV 4WD light monitors the electric shift
4WD system. If the SERV 4WD light stays on or
comes on during driving, it means that the
4WD system is not functioning properly and
that service is required.
•Transmission Temperature Light This light indicates that there is excessive trans-
mission fluid temperature that might occur
with severe usage such as trailer towing. It may
also occur when operating the vehicle in a high
torque converter slip condition, such as 4-wheel-drive
operation (e.g., snow plowing, off- road operation). If this
light comes on, stop the vehicle and run the engine at idle
or faster, with the transmission in NEUTRAL until the
light goes off.
•Loose Gascap Message If the vehicle diagnostic system determines
that the fuel filler cap is loose, improperly
installed, or damaged, a loose gascap icon will
display in the telltale display area. Tighten the
fuel filler cap properly and press the SELECT button to
turn off the message. If the problem continues, the
message will appear the next time the vehicle is started.
A loose, improperly installed, or damaged fuel filler cap
may also turn on the Malfunction Indicator Light (MIL).
Oil Change Required
Your vehicle is equipped with an engine oil change
indicator system. The Oil Change Required message will
flash in the EVIC display for approximately 10 seconds
after a single chime has sounded to indicate the next
scheduled oil change interval. The engine oil change
4
UNDERSTANDING YOUR INSTRUMENT PANEL 199

To Reset The Display
Reset will only occur while a resettable function is being
displayed. Press and release the ODOMETER/TRIP
ODOMETER button once to clear the resettable function
being displayed.
Vehicle Info (Customer Information Features)
Press and release the UP or DOWN button until “Vehicle
Info” displays in the EVIC and press the SELECT button.
Press the UP and DOWN button to scroll through the
available information displays, then press SELECT to
display anyone of the following choices.
•Coolant Temp
Displays the actual coolant temperature.
•Oil Temperature
Displays the actual oil temperature.
•Oil Pressure
Displays the actual oil pressure.
•Trans Temperature
Displays the actual transmission temperature.
•Engine Hours
Displays the hours of engine operation.
Units
Press and release the UP or DOWN button until “Units”
displays in the EVIC and press the SELECT button. The
EVIC, odometer, and navigation system (if equipped) can
be changed between English and Metric units of mea-
sure. To make your selection, scroll up or down until the
preferred setting is highlighted, then press and release
the SELECT button until a check-mark appears next to
the setting, showing that setting has been selected.
Compass / Temperature Display
The compass readings indicate the direction the vehicle is
facing. The EVIC will display one of eight compass
readings and the outside temperature.
202 UNDERSTANDING YOUR INSTRUMENT PANEL

NOTE: Under no circumstances should oil change
intervals exceed 6,000 miles (10 000 km) or six months,
whichever occurs first.
Engine Oil Selection
For best performance and maximum protection under all
types of operating conditions, the manufacturer only
recommends engine oils that are API Certified and meet
the requirements of Chrysler Material Standard MS-6395.
American Petroleum Institute (API) Engine Oil
Identification Symbol
This symbol means that the oil has
been certified by the American
Petroleum Institute (API). The
manufacturer only recommends
API Certified engine oils.
CAUTION!
Do not use chemical flushes in your engine oil as the
chemicals can damage your engine. Such damage is
not covered by the New Vehicle Limited Warranty.
Engine Oil Viscosity (SAE Grade)
SAE 5W-20 engine oil is recommended for all operating
temperatures. This engine oil improves low temperature
starting and vehicle fuel economy. The engine oil filler
cap also shows the recommended engine oil viscosity for
your engine. For information on engine oil filler cap
location, refer to “Engine Compartment” in “Maintaining
Your Vehicle” for further information.
Lubricants which do not have both the engine oil certi-
fication mark and the correct SAE viscosity grade num-
ber should not be used.
7
MAINTAINING YOUR VEHICLE 387

transmission with an improper fluid level will greatly
reduce the life of the transmission and of the fluid. Check
the fluid level whenever the vehicle is serviced.
Fluid Level Check – 545RFE
Check the fluid level while the transmission is at normal
operating temperature 82°C (180°F). This occurs after at
least 15 miles (25 km) of driving. At normal operating
temperature the fluid cannot be held comfortably be-
tween the fingertips.
To check the automatic transmission fluid level properly,
the following procedure must be used:
1. Operate the engine at idle speed and normal operating
temperature.
2. The vehicle must be on level ground.
3. Fully apply the parking brake and press the brake
pedal.4. Place the shift lever momentarily into each gear posi-
tion ending with the lever in PARK.
5. Remove the dipstick, wipe it clean and reinsert it until
seated.
6. Remove the dipstick again and note the fluid level on
both sides. The fluid level should be between the “HOT”
(upper) reference holes on the dipstick at normal operat-
ing temperature. Verify that solid coating of oil is seen on
both sides of the dipstick. If the fluid is low, add as
required into the dipstick tube.
Do not overfill.After
adding any quantity of oil through the oil fill tube, wait
a minimum of two minutes for the oil to fully drain into
the transmission before rechecking the fluid level.
NOTE: If it is necessary to check the transmission below
the operating temperature, the fluid level should be
between the two “COLD” (lower) holes on the dipstick
with the fluid at approximately 70°F (21°C) (room tem-
perature). If the fluid level is correctly established at
7
MAINTAINING YOUR VEHICLE 407

Break-In Recommendations................ 72
Compartment Identification ............... 381
Coolant (Antifreeze) .................... 427
Exhaust Gas Caution .................. 74,325
Flooded, Starting ...................... 266
Jump Starting ......................... 370
Oil .............................. 386,427
Oil Filler Cap ......................... 387
Oil Selection .......................... 387
Oil Synthetic ......................... 388
Temperature Gauge .................... 180
Enhanced Accident Response Feature .......... 56
Exhaust Gas Caution ................74,325,394
Exhaust System ....................... 74,394
Exterior Lighting ........................ 139
Exterior Lights .......................... 75
Filters Air Cleaner .......................... 388 Engine Fuel
.......................... 427
Engine Oil ........................ 388,427
Engine Oil Disposal .................... 388
Flashers Turn Signal ...................... 75,144,180
Flat Tire Stowage ........................ 369
Flooded Engine Starting ................... 266
Fluid, Brake ........................... 428
Fluid Capacities ......................... 426
Fluid Leaks ............................. 76
Fluid Level Checks Automatic Transmission ................. 407
Brake .............................. 402
Power Steering ........................ 292
Fluids, Lubricants and Genuine Parts .......... 427
Fog Lights ....................... 140,191,422
Four Wheel Drive ....................... 277
Four-Way Hazard Flasher .................. 358
Freeing A Stuck Vehicle ................... 374
462 INDEX

Front Axle (Differential)................... 404
Fuel ................................. 321
Adding ............................. 326
Diesel .............................. 427
Filler Cap (Gas Cap) .................... 327
Filter ............................... 427
Gauge .............................. 180
Light ............................... 187
Octane Rating ........................ 321
Requirements ......................... 321
Tank Capacity ........................ 426
Fuses ................................ 414
Gas Cap (Fuel Filler Cap) ...............327,382
Gasoline (Fuel) ......................... 321
Gasoline, Reformulated ................... 322
Gauges Coolant Temperature ................... 180
Fuel ............................... 180 Oil Pressure
.......................... 183
Speedometer ......................... 181
Tachometer .......................... 180
Voltmeter ............................ 187
Gear Ranges ........................... 272
General Information .................. 17,25,116
Glass Cleaning .......................... 413
Grocery Bag Retainer ..................... 170
Gross Axle Weight Rating .................. 331
Gross Vehicle Weight Rating ................ 330
Guide, Body Builders ...................... 6
GVWR ............................... 328
Hands-Free Phone (Uconnect™) .............. 87
Hazard Driving Through Flowing, Rising, or Shallow
Standing Water ........................ 288
Hazard Warning Flasher ................... 358
Head Restraints ......................... 124
10
INDEX 463

Spark Plugs............................ 427
Speed Control (Cruise Control) .............. 150
Speedometer ........................... 181
Starting ............................. 25,265
Automatic Transmission ................. 265
Engine Fails to Start .................... 266
Remote .............................. 25
Starting Procedures (Gas Engines) ............ 265
Steel Carcass Ply Tires .................... 310
Steering Power ........................... 291,292
Wheel, Heated ........................ 149
Wheel, Tilt ........................... 147
Steering Wheel Mounted Sound
System Controls ......................... 246
Storage Compartment, Center Seat ........... 166
Storage, Vehicle ...................... 259,419
Storing Your Vehicle ...................... 419
Supplemental Tire Pressure Information ........ 317Synthetic Engine Oil
...................... 388
System, Remote Starting .................... 25
Tachometer ............................ 180
Temperature Control, Automatic (ATC) ........ 253
Temperature Gauge, Engine Coolant .......... 180
Tether Anchor, Child Restraint .............64,68
Tilt Steering Column ..................... 147
Tip Start .............................. 266
Tire and Loading Information Placard ......303,317
Tire Identification Number (TIN) ............. 301
Tire Markings .......................... 297
Tire Safety Information .................... 297
Tires ............................ 75,307,454
Aging (Life of Tires) .................... 314
Air Pressure .......................... 307
Chains .............................. 317
Dual ............................ 320,366
General Information .................... 307
10
INDEX 471