belt Ram 5500 Chassis Cab 2017 Repair Manual

However, cracks running along a rib (not across) are not
normal. Any belt with cracks running along a rib must be
replaced. Also have the belt replaced if it has excessive
wear, frayed cords or severe glazing.
Conditions that would require replacement:
•Rib chunking (one or more ribs has separated from belt
body)
• Rib or belt wear
• Longitudinal belt cracking (cracks between two ribs)
• Belt slips •
“Groove jumping (belt does not maintain correct posi-
tion on pulley)
• Belt broken (identify and correct problem before new
belt is installed)
• Noise (objectionable squeal, squeak, or rumble is heard
or felt while drive belt is in operation)
Some conditions can be caused by a faulty component such
as a belt pulley. Belt pulleys should be carefully inspected
for damage and proper alignment.
Belt replacement on some models requires the use of
special tools, we recommend having your vehicle serviced
at an authorized dealer.
Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic mainte-
nance required.
WARNING!
• Battery fluid is a corrosive acid solution and can
burn or even blind you. Do not allow battery fluid to
contact your eyes, skin, or clothing. Do not lean over
(Continued)
Accessory Belt (Serpentine Belt)
7
MAINTAINING YOUR VEHICLE 457

WARNING!(Continued)
a battery when attaching clamps. If acid splashes in
eyes or on skin, flush the area immediately with
large amounts of water. Refer to “Jump-Starting
Procedures” in “What To Do In Emergencies” for
further information.
• Battery gas is flammable and explosive. Keep flame
or sparks away from the battery. Do not use a booster
battery or any other booster source with an output
greater than 12 Volts. Do not allow cable clamps to
touch each other.
• Battery posts, terminals, and related accessories con-
tain lead and lead compounds. Wash hands after
handling.
CAUTION!
• It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to the
negative post. Battery posts are marked positive (+)
and negative (-) and are identified on the battery
case. Cable clamps should be tight on the terminal
posts and free of corrosion.
(Continued)
CAUTION! (Continued)
•If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables before
connecting the charger to the battery. Do not use a
“fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an authorized dealer at the
start of each warm season. This service should include
cleaning of the condenser fins and a performance test.
Drive belt tension should also be checked at this time.
WARNING!
• Use only refrigerants and compressor lubricants ap-
proved by the manufacturer for your air conditioning
system. Some unapproved refrigerants are flam-
mable and can explode, injuring you. Other unap-
proved refrigerants or lubricants can cause the sys-
tem to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD, for
further warranty information.
(Continued)
458 MAINTAINING YOUR VEHICLE

Glass Surfaces
All glass surfaces should be cleaned on a regular basis with
MOPAR Glass Cleaner, or any commercial household-type
glass cleaner. Never use an abrasive type cleaner. Use
caution when cleaning the inside rear window equipped
with electric defrosters or windows equipped with radio
antennas. Do not use scrapers or other sharp instrument
that may scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or cloth that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft cloth. A mild soap solution may beused, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
cloth.
2. Dry with a soft cloth.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical solvents
or abrasive cleaners. This will weaken the fabric. Sun
damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the vehicle
to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
NOTE: If the belts retract slowly, inspect the upper turning
loop for soiling. If soiling is present, clean with a wet soft
cloth until all residue is removed.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do not
disassemble or modify the system. Seat belt assemblies
must be replaced after a collision if they have been
damaged (i.e., bent retractor, torn webbing, etc.).
7
MAINTAINING YOUR VEHICLE 485

Fluid Type......................... .478, 502
Shifting .............................. .327
Special Additives ........................ .479
Axle Fluid ........................ .477, 478, 502
Axle Lubrication ....................... .477, 478
Back-Up Camera .......................... .161
Battery .............................. .204, 457
Charging System Light ....................204
Keyless Key Fob Replacement ................24
Belts, Seat .................................96
Body Builders Guide ..........................6
Body Mechanism Lubrication ..................465
B-Pillar Location .......................... .371
Brake Assist System ........................ .355
Brake Control System, Electronic ................353
Brake Fluid .......................... .476, 502
Brake System ......................... .352, 475
Fluid Check ........................... .476
Master Cylinder ........................ .476
Parking .............................. .350
Warning Light .......................... .202
Brake/Transmission Interlock ..................327
Bulb Replacement ......................... .494Bulbs, Light
........................... .98, 493
Cab Top Clearance Lights .....................498
Camera, Rear ............................ .161
Capacities, Antifreeze (Engine Coolant) ...........499
Capacities, Fluid .......................... .499
Caps, Filler Oil (Engine) ........................... .453
Power Steering ......................... .350
Radiator (Coolant Pressure) .................474
Carbon Monoxide Warning .................95, 399
Cargo Light ............................. .137
Car Washes .............................. .481
Center High Mounted Stop Light ...............496
Center

Seat Storage Compartment ...............182
Certification Label ......................... .401
Chart, Tire Sizing .......................... .367
Check Engine Light (Malfunction Indicator Light). . . .449
Checking Your Vehicle For Safety ................95
Checks, Safety .............................95
Child Restraint .............................70
Child Restraints Booster Seats ............................74
Child Restraints ..........................70
Child Seat Installation .................83, 84, 85
10
INDEX 517

How To Stow An Unused ALR Seat Belt.........81
Infants And Child Restraints .................72
Locating The LATCH Anchorages ..............79
Lower Anchors And Tethers For Children ........76
Older Children And Child Restraints ...........73
Seating Positions ..........................75
Cigar Lighter ............................ .177
Clean Air Gasoline ........................ .396
Cleaning Wheels ............................... .483
Climate Control ........................... .277
Cold Weather Operation ..................... .323
Compact Disc (CD) Maintenance ................275
Compact Spare Tire ........................ .381
Console, Overhead ........................ .164
Contract, Service .......................... .512
Coolant Pressure Cap (Radiator Cap) .............474
Cooling System ........................... .471
Adding Coolant (Antifreeze) .................473
Coolant Capacity ........................ .499
Coolant Level ....................... .471, 474
Disposal Of Used Coolant ..................474
Drain, Flush, And Refill ....................472
Inspection ............................. .474
Points To Remember ..................... .475Pressure Cap
........................... .474
Radiator Cap .......................... .474
Selection Of Coolant (Antifreeze) ..........472, 500
Corrosion Protection ....................... .481
Cruise Light ....................... .220, 221, 222
Cupholders .............................. .178
Customer Assistance ....................... .510
Customer Programmable Features ...............256
Daytime Running Lights .....................131
Dealer Service ............................ .451
Defroster, Rear Window ..................... .186
Defroster, Windshield ........................96
Delay

(Intermittent) Wipers ...................139
Differential, Limited-Slip .....................346
Dipsticks Automatic Transmission ....................479
Power Steering ......................... .350
Disabled Vehicle Towing .....................442
Disposal Antifreeze (Engine Coolant) .................474
Do Not Disturb ........................... .314
Door Ajar ............................... .207
Door Ajar Light ........................... .207
518 INDEX

Low Fuel............................. .214
Malfunction Indicator (Check Engine) ..........208
Park ................................. .219
Passing ............................... .138
Seat Belt Reminder ...................... .201
Security Alarm ......................... .203
Service ............................ .493, 494
Tire Pressure Monitoring (TPMS) ..........212, 389
Traction Control ........................ .360
Transfer Case .......................... .341
Turn Signal ....................98, 137, 220, 494
Warning (Instrument Cluster Description) . . . .204, 220
Limited-Slip Differential ..................346, 478
Loading Vehicle ........................... .401
Tires................................. .371
Load Shed Battery Saver Mode ...................... .236
Battery Saver On ........................ .236
Electrical Load Reduction ...................236
Intelligent Battery Sensor ...................236
Locks ....................................30
Automatic Door ..........................32
Child Protection ..........................33
Door ..................................30
Power Door .............................32 Low Tire Pressure System
.....................389
Lubrication, Body ......................... .465
Lug Nuts ......................... .427, 433, 434
Maintenance Free Battery .....................457
Maintenance Procedures ..................... .451
Maintenance Schedule ...................... .504
Malfunction Indicator Light (Check Engine) . . . .208, 449
Manual, Service ........................... .514
Manual Transmission Fluid Level Check ....................... .478
Memory Seat ............................. .124
Methanol ............................... .397
Mirrors ................................. .103
Electric

Powered .........................111
Heated ................................112
Memory .............................. .124
Outside ...............................110
Rearview ....................... .103, 104, 109
Trailer Towing ...........................113
Modifications/Alterations, Vehicle ................7
Monitor, Tire Pressure System ..................389
MOPAR Parts ......................... .450, 513
MTBE/ETBE ............................. .397
10
INDEX 523

Take-Off Adapter........................ .336
Take-Off Operation ...................... .336
Windows ...............................37
Power Seats Down .............................115,116
Forward ............................115,116
Rearward ...........................115,116
Recline ................................115
Tilt...................................116
Up................................115,116
Power Steering Fluid ....................... .502
Pregnant Women And Seat Belts .................51
Pretensioners Seat Belts ...............................52
Programmable Electronic Features ...............230
Programming Key Fobs (Remote Keyless Entry) ......21
PTO (Power Take-Off) ...................... .336
Radial Ply Tires ........................... .378
Radiator Cap (Coolant Pressure Cap) .........472, 474
Radio Frequency General Information .............17, 19, 27, 30, 37
Radio Operation .......................... .275
Radio (Sound Systems) ..................... .273
Rain Sensitive Wiper System ...................140 Rear Axle (Differential)
...................477, 478
Rear ParkSense System ...................148, 155
Rear Window Features ...................... .186
Rear Window, Sliding ...................... .187
Reclining Rear Seats ........................ .120
Recreational Towing ........................ .418
Shifting Into Transfer Case Neutral (N) .........420
Shifting Out Of Transfer Case Neutral (N) .......422
Reformulated Gasoline ...................... .396
Refrigerant .............................. .459
Reminder, Seat Belt ..........................42
Remote Control Starting System ...........................27
Remote Keyless Entry ..................... .21, 22
Programming Additional Key Fobs .............18
Remote Sound System (Radio) Controls ...........274
Remote Starting Uconnect Customer Programmable Features . .249, 266
Uconnect Settings .....................249, 266
Remote Starting System .......................27
Replacement

Keys ...........................18
Replacement Parts ......................... .450
Replacement Tires ......................... .384
Reporting Safety Defects .....................513
Restraint, Head ........................... .121
10
INDEX 525

Restraints, Child............................70
Rotation, Tires ............................ .386
Safety Checks Inside Vehicle ...................96
Safety Checks Outside Vehicle ..................98
Safety Defects, Reporting .....................513
Safety, Exhaust Gas ..........................95
Safety Information, Tire ..................... .365
Safety Tips ................................95
Schedule, Maintenance ...................... .504
Seat Belt Adjustable Upper Shoulder Belt Anchorage .......47
Automatic Locking Retractor (ALR) ............52
Lap/Shoulder Belt Operation .................45
Lap/Shoulder Belt Untwisting ................47
Pregnant Women .........................51
Seat Belt Extender .........................51
Seat Belt Pretensioner ......................52
Seat Belt Reminder ........................42
Seat Belt Maintenance ...................... .485
Seat Belt Reminder ..........................42
Seat Belts ............................. .41, 96
Adjustable Shoulder Belt ....................47
Adjustable Upper Shoulder Anchorage ..........47
Child Restraint ...........................70 Extender
...............................51
Front Seat ........................... .41, 45
Inspection ..............................96
Operating Instructions ......................45
Pregnant Women .........................51
Pretensioners ............................52
Reminder ............................. .201
Untwisting Procedure ......................47
Seats ..........................114,115,116,121
Adjustment ......................114,115,116
Easy Entry ............................ .127
Folding Floor .......................... .187
Memory .............................. .124
Power ................................115
Reclining Rear .......................... .120
Security Alarm ......................... .19, 203
Selection Of Coolant (Antifreeze) ...............500
SENTRY KEY Key Programming .........................18
Sentry Key (Immobilizer) ......................17
Sentry Key Replacement ......................18
Service

Assistance ......................... .510
Service Contract .......................... .512
Service Manuals .......................... .514
Settings, Personal ......................... .230
526 INDEX

Fluid................................ .502
Shifting .............................. .325
Transporting Pets ...........................93
Tread Wear Indicators ...................... .383
Turn Signals ....................... .137, 220, 494
Uconnect Customer Programmable Features .........249, 266
Operation ............................. .273
Uconnect Settings ....................... .239
Uconnect Settings .....................249, 266
Uconnect 8.4/8.4 NAV ...................... .314
Uconnect 8.4 Settings Customer Programmable Features — Units ......258
Uconnect Access Vehicle Health Alert ...................... .307
Uconnect Settings Customer Programmable Features .......34, 247, 264
Passive Entry Programming ...........34, 247, 264
Uconnect Settings .....................247, 264
Uconnect Voice Command ....................294
Uniform Tire Quality Grades ..................388
Universal Garage Door Opener (HomeLink) Programming HomeLink .........166, 167, 168, 169
Unleaded Gasoline ........................ .396Untwisting Procedure, Seat Belt
.................47
Vehicle Identification Number (VIN) ...............7
Vehicle Loading ....................... .373, 401
Vehicle Modifications/Alterations .................7
Vehicle Storage ........................ .292, 493
Viscosity, Engine Oil ....................... .453
Voice Recognition System (VR) .................294
Warnings And Cautions .......................6
Warranty Information ...................... .513
Washers, Windshield .....................139, 469
Washing Vehicle .......................... .481
Water Driving Through ........................ .348
Wheel And Wheel Trim ..................... .483
Wheel And Wheel Trim Care ..................483
Wheel Cover ............................. .434
Wheel

Nut Torque ..................... .433, 435
Wind Buffeting .............................40
Window Fogging .......................... .292
Windows .................................37
Power .................................37
Rear Sliding ........................... .187
Reset Auto-Up ...........................39
10
INDEX 529