ECU Ram Cargo Van 2014 Workshop Manual

NOTE:In some situations the jack may need to be
placed on its side in order to be pushed under the vehicle.
Return the jack to its correct orientation once it is under
the vehicle.
WARNING!
Being under a jacked-up vehicle is dangerous. The
vehicle could slip off the jack and fall on you. You
could be crushed. Never get any part of your body
under a vehicle that is on a jack. If you need to get
under a raised vehicle, take it to a service center
where it can be raised on a lift.
3. Place the wrench on the jack screw and turn to the right until the jack head is properly engaged in the
described location. Do not raise the vehicle until you
are sure the jack is securely engaged.
Front Jack Engaged
556 WHAT TO DO IN EMERGENCIES

Securing The Compact Spare Tire
1. Assemble the winch handle extensions to form aT-handle and fit the winch T-handle over the drive
nut. Rotate the nut to the left until the winch mecha-
nism stops turning freely. This will allow enough slack
in the cable to allow you to pull the wheel spacer out
from under the vehicle.
WARNING!
A loose compact spare tire/cover assembly, thrown
forward in a collision or hard stop could endanger
the occupants of the vehicle. Always stow the com-
pact spare tire with the cover assembly in the place
provided.
CAUTION!
The winch mechanism is designed for use with the
winch T-handle only. Use of an air wrench or other
power tools is not recommended and can damage the
winch.
2. Assemble the winch handle extensions to form the spare tire hook, and pull the wheel spacer from under
the vehicle.
3. Turn the compact spare tire so that the valve stem is down, and place the tire into the compact spare
tire/cover assembly. Slide the wheel spacer through
the center of the wheel and compact spare tire/cover
assembly, so that the two retainer tabs snap out and
engage the compact spare tire cover on the opposite
side.
560 WHAT TO DO IN EMERGENCIES

CAUTION!
The compact spare tire/cover assembly must be used
when the compact spare tire is stored. Failure to use
this cover could drastically reduce the life of the
compact spare tire.
WARNING!
Verify that both retainer tabs of the wheel spacer
have been properly extended through the center of
the wheel and compact spare tire/cover assembly.
Failure to properly engage both retainer tabs could
result in loss of the compact spare tire and cover
assembly, which will cause vehicle damage and may
cause loss of vehicle control and serious personal
injury.4. Using the winch T-handle, rotate the drive nut to the
right until the compact spare tire/cover assembly is
drawn into place against the underside of the vehicle.
5. Continue to rotate the nut to the right until you hear the winch mechanism click three times. It cannot be
overtightened. Check under the vehicle to ensure the
compact spare tire/cover assembly is positioned cor-
rectly against the underside of the vehicle.CAUTION!
The winch mechanism is designed specifically to
stow a compact spare tire only. Do not attempt to use
the winch to stow the full size deflated tire, or any
other full-size tire, as the tire may not be held
securely. Vehicle damage may result.6
WHAT TO DO IN EMERGENCIES 561

CAUTION!
•Do not use sling type equipment when towing.
Damage to the fascia will occur.
•
When securing the vehicle to a flatbed truck, do not
attach to front or rear suspension components. Dam-
age to your vehicle may result from improper towing.
• Do not push or tow this vehicle with another
vehicle as damage to the bumper fascia and trans-
mission may result.
The manufacturer recommends towing your vehicle with
all four wheels OFF the ground using a flatbed. If flatbed
equipment is not available, and the transmission is
operable, the vehicle may be flat towed (with all four
wheels on the ground) under the following conditions:
• The transmission must be in NEUTRAL.
• The towing distance must not exceed 15 miles (24 km).
• The towing speed must not exceed 25 mph (40 km/h). If the transmission is not operable, or the vehicle must
be towed faster than 25 mph (40 km/h) or farther than 15
miles (24 km), it must be towed with the front wheels
OFF the ground (using a flatbed truck, or wheel lift
equipment with the front wheels raised).CAUTION!
Towing faster than 25 mph (40 km/h) or farther than
15 mi (24 km) with front wheels on the ground can
cause severe transmission damage. Such damage is
not covered by the New Vehicle Limited Warranty.
CAUTION!
Towing this vehicle in violation of the above require-
ments can cause severe transmission damage. Dam-
age from improper towing is not covered under the
New Vehicle Limited Warranty.
572 WHAT TO DO IN EMERGENCIES

The A/C air filter is located in the fresh air inlet behind
the glove box. Perform the following procedure to re-
place the filter:
1. Open the glove compartment and remove all contents.
2. Push in on the sides of the glove compartment andlower the door.
3. Pivot the glove compartment downward.
4. Disengage the two retaining tabs that secure the filter cover to the HVAC housing, and remove the cover.
5. Remove the A/C air filter by pulling it straight out ofthe housing.
6. Install the A/C air filter with the arrow on the filter pointing toward the floor. When installing the filter
cover, make sure the retaining tabs fully engage the
cover.
A/C Air Filter Replacement
7
MAINTAINING YOUR VEHICLE 589

WARNING!(Continued)
•To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that has
been in a tightly closed container. Keep the master
cylinder reservoir cap secured at all times. Brake
fluid in a open container absorbs moisture from the
air resulting in a lower boiling point. This may
cause it to boil unexpectedly during hard or pro-
longed braking, resulting in sudden brake failure.
This could result in a collision.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.
(Continued)
WARNING! (Continued)
•Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Automatic Transmission
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
only the manufacturer’s specified transmission fluid.
Refer to “Fluids, Lubricants, and Genuine Parts” in this
section for fluid specifications. It is important to maintain
the transmission fluid at the correct level using the
recommended fluid. No chemical flushes should be used
in any transmission; only the approved lubricant should
be used.
600 MAINTAINING YOUR VEHICLE

3. Twist the socket and remove from the lamp assembly.
4. Pull the bulb to remove it from the socket.
5. Replace the bulb, reinstall the socket, and reattach thelamp assembly.
Center High-Mounted Stop Lamp (CHMSL)
The CHMSL uses LED lamps that are not serviceable
separately. The CHMSL must be replaced as an assembly.
See your authorized dealer.
License Lamp
The license plate lamp is located under the tailgate light
bar and above the license plate. 1. Using a small screwdriver, press inward the locking
tab on the outboard side of the lamp assembly and
pull down on the lamp assembly for removal.
2. Twist and remove the socket from the lamp assembly and pull the bulb out to remove.
3. Push the bulb into the socket, twist the socket into the lamp assembly and reinstall the lamp assembly into
place ensuring the locking tab is secure.
7
MAINTAINING YOUR VEHICLE 623

Adding Engine Coolant (Antifreeze)............594
Adding Fuel ............................ .518
Adding Washer Fluid ..................... .591
Additives, Fuel .......................... .513
Adjustable Pedals ........................ .217
Airbag ..................................72
Airbag Deployment ........................82
Airbag Light .............................79
Airbag Maintenance ........................83
Airbag, Side ..............................76
Airbag, Window (Side Curtain) ................78
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .583
Air Conditioner Maintenance .................587
Air Conditioning ......................... .415
Air Conditioning Controls ...................415
Air Conditioning Filter .....................434
Air Conditioning, Rear Zone .................421
Air Conditioning Refrigerant .................587
Air Conditioning System ....................415 Air Conditioning System, Zone Control
..........415
Air Pressure, Tires ........................ .488
Alarm Light ............................ .303
Alarm (Security Alarm) ......................17
Alterations/Modifications, Vehicle ...............7
Antenna, Satellite Radio .....................355
Antifreeze (Engine Coolant) ..................593
Disposal ............................. .596
Anti-Lock Warning Light ....................298
Appearance Care ........................ .602
Ashtray ............................... .261
Assistance Towing ........................ .143
Assist, Hill Start ......................... .473
Auto Down Power Windows ..................41
Automatic Dimming Mirror ..................114
Automatic Door Locks ......................37
Automatic Headlights ..................... .204
Automatic Temperature Control (ATC) ..........423
644 INDEX

Battery Saver......................... .210
Brake Assist Warning ....................471
Brake Warning ........................ .303
Bulb Replacement ...................... .619
Center Mounted Stop ....................623
Daytime Running ...................... .206
Dimmer Switch, Headlight .................206
Electronic Stability Program (ESP) Indicator .....471
Engine Temperature Warning ...............307
Exterior ............................. .105
Fog ................................ .206
Hazard Warning Flasher ..................541
Headlights ........................... .620
Headlights On Reminder ..................206
High Beam Indicator .....................295
High Beam/Low Beam Select ...............210
Illuminated Entry ........................19
Interior ............................. .206
License ............................. .623Lights On Reminder
.....................206
Low Fuel ............................ .306
Malfunction Indicator (Check Engine) .........300
Oil Pressure .......................... .306
Park ............................... .621
Passing ............................. .210
Reading ............................. .235
Rear Servicing ........................ .622
Rear Tail ............................ .622
Seat Belt Reminder ..................... .305
Security Alarm ........................ .303
Service .............................. .619
Service Engine Soon (Malfunction Indicator) . . . .300
Side Marker .......................... .622
Tire Pressure Monitoring (TPMS) ............299
Traction Control ....................... .471
T

urn Signal .......................... .105
Voltage ............................. .306
Warning (Instrument Cluster Description) ......295
10
INDEX 653

Reclining............................ .173
Stow n Go (Fold in Floor) .................178
Security Alarm ............................17
Selection of Coolant (Antifreeze) ...............625
Sentry Key (Immobilizer) ....................15
Sentry Key Programming ....................17
Sentry Key Replacement .....................16
Service Assistance ........................ .635
Service Contract ......................... .637
Service Engine Soon Light (Malfunction Indicator) . .300
Service Manuals ......................... .640
Settings, Personal ........................ .325
Setting the Clock ......................... .333
Shift Lever Override ...................... .569
Shoulder Belts ............................58
Side Airbag ..............................80
Signals, Turn ........................... .105
Sliding Door .............................43
Snow Chains (Tire Chains) ...................498 Snow Tires
............................. .491
Spare Tire .............................. .493
Speed Control (Cruise Control) ................219
Speedometer ............................ .302
Starting ............................... .441
Automatic Transmission ..................441
Cold Weather ......................... .442
Engine Fails to Start .....................442
Remote ...............................30
Starting and Operating .....................441
Starting Procedures ....................... .441
Steering Power .............................. .460
Tilt Column .......................... .215
Wheel, Heated ........................ .216
Wheel, Tilt ........................... .215
Steering Wheel Audio Controls ...............412
Steering Wheel Mounted Sound System Controls . . .412
Storage ............................... .618
658 INDEX