belt RAM CHASSIS CAB 2011 Service Manual

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust both
inside and outside mirrors, and fasten your seat belt.
The starter should not be operated for more than 15-
second intervals. Waiting a few seconds between such
intervals will protect the starter from overheating.
WARNING!Never leave children alone in a vehicle. Leaving
unattended children in a vehicle is dangerous for a
number of reasons. A child or others could be seri-
ously or fatally injured. Do not leave the key fob in
the ignition. A child could operate power windows,
other controls, or move the vehicle.
Normal Starting
Normal starting of either a warm or cold engine is
obtained without pumping or pressing the accelerator pedal. Turn the key fob to the START position and release
when the engine starts. If the engine fails to start within
10 seconds, turn the key fob to the OFF position, wait five
seconds, then repeat the “Normal Starting” procedure.
Automatic Transmission
Start the engine with the shift lever in the NEUTRAL or
PARK position. Apply the brake before shifting into any
driving range.
NOTE: This vehicle is equipped with a transmission
shift interlocking system. The brake pedal must be
pressed to shift out of PARK.
Tip Start Feature
Do not press the accelerator. Turn the ignition switch
briefly to the START position and release it. The starter
motor will continue to run but will automatically disen-
gage when the engine is running.
5 STARTING AND OPERATING 263

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
CAUTION!Do not use chemical flushes in your air conditioning
system as the chemicals can damage your air condi-
tioning components. Such damage is not covered by
the New Vehicle Limited Warranty. WARNING!• Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Section 3 of the Warranty Information Book, lo-
cated on the DVD, for further warranty informa-
tion.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced repairman.
7 MAINTAINING YOUR VEHICLE 387

Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MOPAR  Glass Cleaner or any commercial house-
hold-type glass cleaner. Never use an abrasive type
cleaner. Use caution when cleaning the inside rear win-
dow equipped with electric defrosters or the right rear
quarter window equipped with the radio antenna. Do
not use scrapers or other sharp instruments which may scratch the elements. When cleaning the rearview mirror,
spray cleaner on the towel or rag that you are using. Do
not spray cleaner directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
7 MAINTAINING YOUR VEHICLE 409

If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Dry with a soft tissue.
FUSES
Totally Integrated Power Module
The totally integrated power module (TIPM) is located in
the engine compartment near the battery. This center
contains cartridge fuses and mini fuses. A description of
each fuse and component may be stamped on the inside
cover, otherwise the cavity number of each fuse is
stamped on the inside cover that corresponds to the
following chart. Cavity Cartridge
Fuse Mini
Fuse Description
J01 30 Amp
Pink Bat – Presafe #1/
CM2200
J02 30 Amp
Pink Bat – Trailer Tow
MainTotally Integrated Power Module (TIPM)410 MAINTAINING YOUR VEHICLE

120,000 Miles (199,000 km) or 90 Months Maintenance Service
Schedule ❏ Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
120,000 miles (199 000 km).
❏ Lube the front drive shaft fitting (4x4 only).
❏ Inspect the CV joints.
❏ Inspect exhaust system.
❏ Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
❏ Change the automatic transmission fluid and filter(s).
❏ Replace the accessory drive belt(s).
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S 438 MAINTENANCE SCHEDULES

Automatic Transmission
Adding Fluid ......................... 403
Fluid and Filter Changes ................. 404
Fluid Level Check ................... 402,403
Fluid Type ........................ 402,424
Shifting ............................. 268
Special Additives ...................... 404
Axle Fluid ....................... 400,401,424
Axle Lubrication (Axle Fluid) ............ 400,401
Battery ............................... 385
Keyless Transmitter Replacement (RKE) ....... 24
Saving Feature (Protection) ............... 144
Belts, Seat ............................ 38,73
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 388
B-Pillar Location ........................ 300
Brake Fluid ......................... 398,424 Brake System ........................ 292,398
Anti-Lock (ABS) ....................... 292
Fluid Check .......................... 398
Master Cylinder ....................... 398
Parking ............................. 289
Warning Light ........................ 187
Brake/Transmission Interlock ............... 267
Bulb Replacement ....................... 416
Bulbs, Light .......................... 76,415
Cab Top Clearance Lights .................. 420
Calibration, Compass ..................... 204
Capacities, Antifreeze (Engine Coolant) ........ 422
Capacities, Fluid ........................ 422
Caps, Filler
Oil (Engine) .......................... 383
Power Steering ........................ 289
Radiator (Coolant Pressure) ............... 395
Car Washes ............................ 405
10 INDEX 455

Carbon Monoxide Warning ............... 73,321
Cargo Light ............................ 144
Cellular Phone ........................ 88,247
Center High Mounted Stop Light ............ 419
Center Lap Belts ......................... 46
Center Seat Storage Compartment ............ 166
Certification Label ....................... 324
Chart, Tire Sizing ........................ 296
Check Engine Light
(Malfunction Indicator Light) ............. 189,379
Checking Your Vehicle For Safety ............. 72
Checks, Safety ........................... 72
Child Restraint ........................ 60,61
Child Restraint Tether Anchors ............. 64,67
Child Seat ............................ 61,65
Cigar Lighter ........................... 160
Cleaning
Wheels ............................. 407
Climate Control ......................... 247 Clock ............................. 212,221
Compact Disc (CD) Maintenance ............. 246
Compass .............................. 203
Compass Calibration ..................... 204
Compass Variance ....................... 204
Computer, Trip/Travel .................... 201
Connector
UCI ................................ 235
Universal Consumer Interface (UCI) ......... 235
Console, Overhead ....................... 155
Contract, Service ........................ 447
Coolant Pressure Cap (Radiator Cap) .......... 395
Cooling System ......................... 392
Adding Coolant (Antifreeze) .............. 394
Coolant Capacity ...................... 422
Coolant Level ...................... 393,396
Disposal of Used Coolant ................ 396
Drain, Flush, and Refill .................. 393
Inspection ........................... 396456 INDEX

Instrument Panel and Controls .............. 176
Instrument Panel Lens Cleaning ............. 409
Integrated Power Module (Fuses) ............ 410
Integrated Trailer Brake Controls ............. 334
Interior Appearance Care .................. 408
Interior Lights .......................... 143
Intermittent Wipers (Delay Wipers) ........... 147
Introduction ............................. 4
Inverter Outlet (115V) ..................... 160
Jack Location ........................... 356
Jump Starting .......................... 366
Key, Programming ........................ 17
Key, Replacement ........................ 17
Key, Sentry (Immobilizer) ................... 16
Key-In Reminder ......................... 15
Keyless Entry System ...................... 20
Keys ................................. 12 Lane Change and Turn Signals .............. 145
Lane Change Assist ...................... 146
Lap Belts .............................. 46
Lap/Shoulder Belts ....................... 38
LATCH
(Lower Anchors and Tether for CHildren) ....... 64
Latches ................................ 76
Leaks, Fluid ............................ 76
Life of Tires ............................ 310
Light Bulbs ............................. 76
Lights .............................. 76,140
Airbag ........................ 55,59,74,190
Alarm .............................. 182
Anti-Lock ........................... 190
Anti-Lock Warning ..................... 293
Automatic Headlights ................... 141
Brake Warning ........................ 187
Bulb Replacement ................... 415,416
Cap Top Clearance ..................... 420
10 INDEX 461

Cargo .............................. 144
Center Mounted Stop ................... 419
Check Engine (Malfunction Indicator) ........ 189
Courtesy/Reading ..................... 155
Daytime Running ...................... 145
Exterior .............................. 76
Fog .......................... 142,190,418
Four-Wheel Drive Indicator ............... 278
Hazard Warning Flasher ................. 356
Headlights ........................... 141
High Beam ........................ 146,186
High Beam Indicator .................... 186
High Beam/Low Beam Select ............. 146
Illuminated Entry ....................... 19
Instrument Cluster ..................... 179
Interior .......................... 143,155
Lights On Reminder .................... 144
Low Fuel ............................ 186
Oil Pressure .......................... 188 Passing ............................. 146
Seat Belt Reminder ..................... 191
Security Alarm (Theft Alarm) .............. 182
Service ........................... 415,416
Theft Alarm (Security Alarm) .............. 182
Transfer Case ......................... 278
Turn Signal ...................... 76,145,416
Warning (Instrument Cluster Description) ..... 179
Limited-Slip Differential ................ 284,401
Loading Vehicle ......................... 324
Tires ............................... 300
Locks ................................. 29
Child Protection ........................ 32
Door ................................ 29
Power Door ........................... 30
Lower Anchors and Tether for CHildren
(LATCH) .............................. 64
Lubrication, Body ....................... 388
Lug Nuts ........................... 361,363462 INDEX

Identification Logo ..................... 383
Materials Added to ..................... 384
Pressure Gauge ....................... 182
Recommendation ...................... 383
Synthetic ............................ 384
Viscosity ............................ 383
Onboard Diagnostic System .............. 378,379
Operating Precautions .................... 378
Operator Manual (Owner’s Manual) ............ 4
Outside Rearview Mirrors .................. 82
Overdrive ............................. 272
Overdrive OFF Switch .................... 272
Overhead Console ....................... 155
Overheating, Engine ...................... 180
Owner’s Manual (Operator Manual) ......... 4,449
Panic Alarm ............................ 24
Parking Brake .......................... 289
Passing Light ........................... 146 Pedals, Adjustable ....................... 149
Personal Settings ........................ 205
Pets .................................. 71
Pets, Transporting ........................ 71
Phone, Cellular .......................... 88
Phone, Hands-Free (Uconnect™) .............. 88
Placard, Tire and Loading Information ......... 300
Power
Door Locks ........................... 30
Mirrors .............................. 84
Outlet (Auxiliary Electrical Outlet) ....... 157,160
Seats ............................... 127
Sliding Rear Window ................... 172
Steering .......................... 288,289
Windows ............................. 34
Power Steering Fluid ..................... 424
Pregnant Women and Seat Belts .............. 49
Programmable Electronic Features ............ 205464 INDEX