steering RAM CHASSIS CAB 2012 Service Manual
[x] Cancel search | Manufacturer: RAM, Model Year: 2012, Model line: CHASSIS CAB, Model: RAM CHASSIS CAB 2012Pages: 502, PDF Size: 3.96 MB
Page 441 of 502
Cavity Cartridge
Fuse Mini
Fuse Description
M16 10 Amp
Red Airbag Module
M18 15 Amp
Blue Center Stop Lamp
M19 25 Amp
Natural Automatic Shutdown
1 and 2
M20 15 Amp
Blue Instrument Cluster
Interior Lighting /Sw
Steering Wheel/Sw
Bank
M21 20 Amp
Yellow Automatic Shutdown
3
M22 10 Amp
Red Horns (Low/High) –
Right
M23 10 Amp
Red Horns (Low/High) –
Left Cavity Cartridge
Fuse Mini
Fuse Description
M25 20 Amp
Yellow Fuel Pump Motor/
Diesel Lift Pump – If
Equipped
M26 10 Amp
Red Driver’s Door Switch
M27 10 Amp
Red Ignition Switch
M28 15 Amp
Blue Powertrain Control
Module
M29 10 Amp
Red Tire Pressure Monitor
M30 15 Amp
Blue J1962 Diag Connector
M31 20 Amp
Yellow Back-Up Lamps
M32 10 Amp
Red Airbag Module
7 MAINTAINING YOUR VEHICLE 439
Page 453 of 502
Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission
(5.7L Engine Only) MOPAR ATF+4 Automatic Transmission Fluid or equivalent licensed
ATF+4 product.
Transfer Case MOPAR ATF+4 Automatic Transmission Fluid or equivalent licensed
ATF+4 product.
Front and Rear Axle Fluid
(4500/5500) GL-5 SAE 75W-90 Synthetic (MS-9763) or equivalent.
Brake Master Cylinder MOPAR DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPAR Power Steering Fluid +4, MOPAR ATF+4 Automatic Trans-
mission Fluid or equivalent licensed ATF+4 product.
7 MAINTAINING YOUR VEHICLE 451
Page 458 of 502
Once A Month
• Check tire pressure and look for unusual wear or
damage.
• Inspect the battery and clean and tighten the terminals
as required.
• Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
• Check all lights and other electrical items for correct
operation. At Each Oil Change
• Change the engine oil filter.
• Inspect the brake hoses and lines.
CAUTION!Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S 456 MAINTENANCE SCHEDULES
Page 467 of 502
104,000 Miles (169,000 km) or
78 Months Maintenance
Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
104,000 miles (169 000 km).
❏ Lube the front drive shaft fitting (4x4
only).
❏ Flush and replace the engine coolant at
104,000 miles (169 000 km) or 60 months
whichever comes first.
❏ Flush and replace power steering fluid. Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center 112,000 Miles (182,000 km) or 84 Months Maintenance Service
Schedule ❏ Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
112,000 miles (182 000 km).
❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter; replace if necessary.
❏ Lube the front drive shaft fitting (4x4 only).
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 465
Page 485 of 502
Automatic Transmission
Adding Fluid ....................... 429
Fluid and Filter Changes ............... 430
Fluid Level Check ................. 427,428
Fluid Type ...................... 427,451
Shifting ........................... 278
Special Additives ..................... 428
Axle Fluid ....................... 425,426,451
Axle Lubrication (Axle Fluid) ............ 425,426
B-Pillar Location ........................ 314
Battery ............................... 409
Keyless Transmitter Replacement (RKE) ..... 25
Saving Feature (Protection) .............. 152
Belts, Seat ............................ 39,79
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 412
Brake Fluid ......................... 423,451 Brake System ........................ 306,423
Anti-Lock (ABS) ..................... 307
Fluid Check ........................ 423
Master Cylinder ..................... 423
Parking ........................... 304
Warning Light ....................... 197
Brake/Transmission Interlock ............... 278
Bulb Replacement ....................... 443
Bulbs, Light .......................... 81,442
Cab Top Clearance Lights .................. 447
Calibration, Compass ..................... 215
Capacities, Antifreeze (Engine Coolant) ........ 449
Capacities, Fluid ........................ 449
Caps, Filler
Oil (Engine) ........................ 407
Power Steering ...................... 303
Radiator (Coolant Pressure) ............. 419
Car Washes ............................ 431
10 INDEX 483
Page 487 of 502
Drain, Flush, and Refill ................ 417
Inspection .......................... 420
Points to Remember .................. 422
Pressure Cap ........................ 419
Radiator Cap ....................... 419
Selection of Coolant (Antifreeze) ....... 418,450
Cupholders ............................ 172
Customer Assistance ..................... 473
Data Recorder, Event ...................... 63
Daytime Running Lights ................... 153
Dealer Service .......................... 405
Defroster, Rear Window ................... 180
Defroster, Windshield ................ 80,258,264
Delay (Intermittent) Wipers ................. 155
Differential, Limited-Slip .................. 298
Dipsticks
Automatic Transmission ................ 428
Power Steering ...................... 303 Disabled Vehicle Towing ................... 395
Disposal
Antifreeze (Engine Coolant) ............. 420
Door Locks ............................. 30
Door Locks, Automatic .................... 32
Driving
Through Flowing, Rising, or Shallow
Standing Water ...................... 300
Dual Rear Wheels ..................... 334,384
Electric Rear Window Defrost ............... 180
Electrical Power Outlets ................... 165
Electronic Range Select (ERS) ............... 284
Electronic Speed Control (Cruise Control) ...... 160
Electronic Vehicle Information Center (EVIC) .... 203
Electronically Shifted Transfer Case ........... 292
Emergency Brake ........................ 304
10 INDEX 485
Page 489 of 502
Fluid Leaks ............................. 81
Fluid Level Checks
Automatic Transmission ................ 428
Brake ............................. 423
Power Steering ...................... 303
Fluid, Brake ........................... 451
Fluids, Lubricants and Genuine Parts .......... 450
Fog Lights ....................... 150,200,445
Four Wheel Drive ....................... 288
Four-Way Hazard Flasher .................. 376
Freeing A Stuck Vehicle ................... 392
Front Axle (Differential) ................... 425
Fuel ................................. 335
Adding ........................... 340
Diesel ............................. 450
Filler Cap (Gas Cap) .................. 341
Filter ............................. 450
Gauge ............................ 189
Light ............................. 196 Octane Rating ....................... 335
Requirements ....................... 335
Tank Capacity ....................... 449
Fuses ................................ 435
Gas Cap (Fuel Filler Cap) ............... 341,402
Gasoline (Fuel) ......................... 335
Gasoline, Reformulated ................... 336
Gauges
Coolant Temperature .................. 189
Fuel .............................. 189
Oil Pressure ........................ 192
Speedometer ........................ 190
Tachometer ......................... 189
Voltmeter .......................... 196
Gear Ranges ........................... 279
Gear Select Lever Override ................. 394
General Information .................. 18,26,123
Glass Cleaning .......................... 435
10 INDEX 487
Page 495 of 502
Sliding Rear Window .................. 181
Steering ........................ 302,303
Windows ........................... 34
Power Steering Fluid ..................... 451
Pregnant Women and Seat Belts .............. 52
Programmable Electronic Features ............ 216
Programming Transmitters
(Remote Keyless Entry) .................... 21
Radial Ply Tires ......................... 324
Radiator Cap (Coolant Pressure Cap) ....... 417,419
Radio Operation ........................ 255
Rear Axle (Differential) ................. 425,426
Rear Window Features .................... 180
Rear Window, Sliding ..................... 181
Reclining Front Seats ..................... 137
Recorder, Event Data ...................... 63
Recreational Towing ...................... 365
Shifting into Transfer Case Neutral (N) . . 368,370 Shifting out of Transfer
Case Neutral (N) .................. 369,373
Reformulated Gasoline .................... 336
Refrigerant ............................ 412
Reminder, Seat Belt ....................... 51
Remote Control
Starting System ....................... 26
Remote Keyless Entry (RKE) ................. 21
Remote Sound System (Radio) Controls ........ 253
Remote Starting System .................... 26
Replacement Keys ........................ 17
Replacement Parts ....................... 404
Replacement Tires ....................... 328
Reporting Safety Defects ................... 476
Resetting Oil Change Indicator ........... 194,210
Restraint, Head ......................... 138
Restraints, Child ....................... 64,70
Restraints, Occupant ...................... 38
Rotation, Tires .......................... 333
10 INDEX 493
Page 497 of 502
Shifting ............................... 276
Automatic Transmission ................ 278
Transfer Case ....................... 290
Transfer Case, Shifting into Transfer
Case Neutral (N) .................. 368,370
Transfer Case, Shifting out of Transfer
Case Neutral (N) .................. 369,373
Short Message Service (SMS) ................ 115
Shoulder Belt Upper Anchorage .............. 48
Shoulder Belts ........................... 39
Signals, Turn ...................... 81,153,189
Sliding Rear Window
Power ............................ 181
Snow Chains (Tire Chains) ................. 330
Snow Plow ............................ 361
Snow Tires ............................ 332
Spare Tire .......................... 325,326
Spark Plugs ............................ 450
Speed Control (Cruise Control) .............. 160 Speedometer ........................... 190
Starting ............................. 26,273
Automatic Transmission ................ 273
Cold Weather ....................... 274
Engine Fails to Start .................. 274
Remote ............................ 26
Starting Procedures (Gas Engines) ............ 273
Steel Carcass Ply Tires .................... 321
Steering
Power .......................... 302,303
Wheel, Heated ...................... 159
Wheel, Tilt ......................... 157
Steering Wheel Audio Controls .............. 253
Steering Wheel Mounted Sound
System Controls ......................... 253
Storage Compartment, Center Seat ........... 176
Storage, Vehicle ...................... 266,441
Storing Your Vehicle ...................... 441
Supplemental Tire Pressure Information ........ 330
10 INDEX 495
Page 498 of 502
Synthetic Engine Oil ...................... 408
System, Remote Starting .................... 26
Tachometer ............................ 189
Temperature Control, Automatic (ATC) ........ 260
Temperature Gauge, Engine Coolant .......... 189
Tether Anchor, Child Restraint ............. 68,73
Text Messaging ......................... 115
Tilt Steering Column ..................... 157
Tip Start .............................. 274
Tire and Loading Information Placard ...... 314,330
Tire Identification Number (TIN) ............. 312
Tire Markings .......................... 309
Tire Safety Information .................... 309
Tires ............................ 81,318,479
Aging (Life of Tires) .................. 328
Air Pressure ........................ 318
Chains ............................ 330
Compact Spare ...................... 325 Dual ........................... 334,384
General Information .................. 318
High Speed ......................... 323
Inflation Pressures .................... 319
Life of Tires ........................ 328
Load Capacity .................... 314,315
Quality Grading ..................... 479
Radial ............................ 324
Replacement ........................ 328
Rotation ........................... 333
Safety .......................... 309,318
Sizes ............................. 310
Snow Tires ......................... 332
Spinning ........................... 327
Steel Carcass Ply ..................... 321
Tread Wear Indicators ................. 327
Wheel Nut Torque .................... 382
Tongue Weight/Trailer Weight .............. 349
Torque Converter Clutch .................. 287496 INDEX