spare wheel RAM CHASSIS CAB 2016 User Guide

SYSTEM  message for a minimum of five seconds and
then display dashes (- -) in place of the pressure value.
• For each subsequent ignition switch cycle, a chime will
sound, the TPM Telltale Light will flash on and off for
75 seconds and then remain on solid, and the EVIC/
DID will display a  SERVICE TPM SYSTEM  message
for a minimum of five seconds and then display
dashes (- -) in place of the pressure value.
• Once you repair or replace the original road tire and
reinstall it on the vehicle in place of the non matching
full size spare or compact spare, the TPMS will update
automatically. In addition, the TPM Telltale Light will
turn OFF and the graphic in the EVIC/DID will
display a new pressure value instead of dashes (- -), as
long as no tire pressure is below the low-pressure
warning limit in any of the four active road tires. The vehicle may need to be driven for up to 20 minutes
above 15 mph (24 km/h) in order for the TPMS to
receive this information.
Tire Pressure Information System (TPIS) Chassis
Cab — If Equipped
Your vehicle may be equipped with a Tire Pressure
Information System (TPIS).
The Tire Pressure Information System (TPIS) uses wire-
less technology with wheel rim mounted electronic sen-
sors to transmit tire pressure levels. Sensors mounted to
each wheel as part of the valve stem transmit tire
pressure readings to the receiver module.
NOTE: It is particularly important for you to check the
tire pressure in all of the tires on your vehicle monthly
and to maintain the proper pressure.496 STARTING AND OPERATING

Jacking Instructions
Instructions
WARNING!Carefully follow these tire changing warnings to
help prevent personal injury or damage to your
vehicle:
• Always park on a firm, level surface as far from the
edge of the roadway as possible before raising the
vehicle.
• Turn on the Hazard Warning flasher.
• Block the wheel diagonally opposite the wheel to
be raised.
• Set the parking brake firmly and set an automatic
transmission in PARK; a manual transmission in
REVERSE. (Continued) WARNING! (Continued)• Never start or run the engine with the vehicle on a
jack.
• Do not let anyone sit in the vehicle when it is on a
jack.
• Do not get under the vehicle when it is on a jack. If
you need to get under a raised vehicle, take it to a
service center where it can be raised on a lift.
• Only use the jack in the positions indicated and for
lifting this vehicle during a tire change.
• If working on or near a roadway, be extremely
careful of motor traffic.
• To assure that spare tires, flat or inflated, are
securely stowed, spares must be stowed with the
valve stem facing the ground.542 WHAT TO DO IN EMERGENCIES

CAUTION!Do not attempt to raise the vehicle by jacking on
locations other than those indicated in the Jacking
Instructions for this vehicle.
1. If equipped, remove the spare wheel, jack, and tools
from storage.
2. Using the wheel wrench, loosen, but do not remove,
the wheel nuts by turning them counterclockwise one
turn while the wheel is still on the ground. 3. When changing the front wheel, assemble the jack
drive tube to the jack and connect the drive tube to the
extension tube. Place the jack under the axle as close to
the tire as possible with the drive tubes extending to
the front. Connect the jack tube extension and wheel
wrench.Jack Warning Label
Front Jacking Locations 6WHAT TO DO IN EMERGENCIES 543

When changing a rear wheel, assemble the jack drive
tube to the jack and connect the drive tube to the
extension tube. Securely place the jack under the sway
bar bracket (unless both tires are flat on one side, then
place jack under shock bracket) facing forward in vehicle.
Connect the jack tube extension and lug wrench. Before raising the wheel off the ground, make sure that
the jack will not damage surrounding truck parts and
adjust the jack position as required.
NOTE: If the jack will not lower by turning the dial
(thumbwheel) by hand, it may be necessary to use the
jack drive tube in order to lower the jack.
4. By rotating the wheel wrench clockwise, raise the
vehicle until the wheel just clears the surface.
WARNING!Raising the vehicle higher than necessary can make
the vehicle unstable. It could slip off the jack and
hurt someone near it. Raise the vehicle only enough
to remove the tire.
5. Remove the wheel nuts and pull the wheel off. Install
the spare wheel and wheel nuts with the cone shaped
end of the nuts toward the wheel on single rear wheelRear Jacking Location544 WHAT TO DO IN EMERGENCIES

(SRW) models. On dual rear wheel models (DRW) the
lug nuts are a two-piece assembly with a flat face.
Lightly tighten the nuts. To avoid risk of forcing the
vehicle off the jack, do not fully tighten the nuts until
the vehicle has been lowered.
6. Using the wheel wrench, finish tightening the nuts
using a crisscross pattern. For the proper lug nut
torque specifications refer to “Wheel and Tire Torque
Specifications” in this section. If in doubt about the
correct tightness, have them checked with a torque
wrench by your authorized dealer or at a service
station.
WARNING!A loose tire or jack thrown forward in a collision or
hard stop could injure someone in the vehicle. Al-
ways stow the jack parts and the extra tire and wheel
in the places provided. 7. Install wheel center cap (if equipped) and remove
wheel blocks. Do not install chrome or aluminum
wheel center caps on the spare wheel. This may result
in cap damage.
8. Lower the jack to its fully closed position. If the jack
will not lower by turning the dial (thumbwheel) by
hand, it may be necessary to use the jack drive tube in
order to lower the jack. Stow the replaced tire, jack,
and tools as previously described.
9. Adjust the tire pressure when possible.
Hub Caps/Wheel Covers — If Equipped
The hub caps must be removed before raising the vehicle
off the ground. 6WHAT TO DO IN EMERGENCIES 545

Replace the wheel skins first using a rubber mallet. When
replacing the hub caps, tilt the cap retainer over the lug
nut bolt circle and strike the high side down with a
rubber mallet. Be sure that the hub caps and wheel skins
are firmly seated around the wheel.
Dual Rear Wheels
Slots in the wheels will assist in properly orienting the
inner and outer wheels. Align these slots when assem-
bling the wheels for best access to the tire valve on the
inner wheel. The tires of both dual wheels must be
completely off the ground when tightening to insure
wheel centering and maximum wheel clamping.
Dual wheel models require a special heavy-duty lug nut
tightening adapter (included with the vehicle) to cor-
rectly tighten the lug nuts. Also, when it is necessary to
remove and install dual rear wheels, use a proper vehicle
lifting device. NOTE: When installing a spare tire (if equipped) as part
of a dual rear wheel end combination, the tire diameter of
the two individual tires must be compared. If there is a
significant difference, the larger tire should be installed in
a front location. The correct direction of rotation for dual
tire installations must also be observed.
It is recommended that wheel stud nuts be kept torqued
to specifications at all times. Torque wheel stud nuts to
specifications at each lubrication interval.
• Retighten the wheel nuts in the same sequence to the
torques listed in the table. Go through the sequence a
second time to verify that specific torque has been
achieved. Retighten to specifications at 100 miles
(160 km) and after 500 miles (800 km).
Wheel Nuts
All wheel nuts should be tightened occasionally to elimi-
nate the possibility of wheel studs being sheared or the 6WHAT TO DO IN EMERGENCIES 547

bolt holes in the wheels becoming elongated. This is
especially important during the first few hundred miles/
kilometers of operation to allow the wheel nuts to
become properly set. All wheel nuts should first be firmly
seated against the wheel. The wheel nuts should then be
tightened to recommended torque. Tighten the wheel
nuts to final torque in increments. Progress around the
bolt circle, tightening the wheel nut opposite to the wheel
nut just previously tightened until final torque is
achieved.
To Stow The Flat Or Spare — If Equipped
Refer to Upfitters Body Builders Guide for information
on stowing your spare tire (if equipped). HOISTING
A conventional floor jack may be used at the jacking
locations. Refer to the graphics that show jacking loca-
tions. However, a floor jack or frame hoist must never be
used on any other parts of the underbody.
CAUTION!Never use a floor jack directly under the differential
housing of a loaded truck or damage to your vehicle
may result.
JUMP-STARTING PROCEDURES
If your vehicle has a discharged battery it can be jump-
started using a set of jumper cables and a battery in
another vehicle or by using a portable battery booster
pack. Jump-starting can be dangerous if done improperly
so please follow the procedures in this section carefully.548 WHAT TO DO IN EMERGENCIES

Cleaning
Wheels .............................. .603
Climate Control ...................... .351, 361
Automatic ........................... .361
Cold Weather Operation ................... .403
Compact Disc (CD) Maintenance ............. .348
Compact Spare Tire ....................... .478
Console, Overhead ....................... .208
Contract, Service ......................... .643
Coolant Pressure Cap (Radiator Cap) .......... .590
Cooling System .......................... .587
Adding Coolant (Antifreeze) .............. .589
Coolant Capacity ...................... .626
Coolant Level ..................... .587, 591
Disposal Of Used Coolant ................ .591
Drain, Flush, And Refill .................. .588
Inspection ........................... .591
Points To Remember .................... .592
Pressure Cap ......................... .590 Radiator Cap ......................... .590
Selection Of Coolant (Antifreeze) ........ .588, 627
Corrosion Protection ...................... .600
Cruise Light ......................... .266, 267
Cupholders ............................ .217
Customer Assistance ...................... .641
Customer Programmable Features ............ .329
Data Recorder, Event .......................82
Daytime Running Lights ................... .165
Dealer Service ........................... .568
Defroster, Rear Window .................... .226
Defroster, Windshield ...................119,354
Delay (Intermittent) Wipers ................. .175
Differential, Limited-Slip ................... .434
Dipsticks
Automatic Transmission ................. .598
Power Steering ........................ .438
Disabled V ehicle Towing ................... .55610 INDEX 655

Sliding Rear Window
Power .............................. .227
Snow Chains (Tire Chains) .................. .484
Snow Plow ............................. .524
Snow Tires ............................. .476
Spare Tire ....................... .477, 478, 479
Spark Plugs ............................ .627
Speed Control
Accel/Decel .......................... .186
Cancel .............................. .184
Resume ............................. .184
Speed Control (Cruise Control) ............... .182
Starting ............................. .33, 402
Automatic Transmission ................. .403
Cold Weather ......................... .403
Engine Fails To Start .................... .403
Remote ...............................33
Starting Procedures (Gas Engines) ............ .402 Steering
Power ........................... .437, 438
Wheel, Heated ........................ .181
Wheel, Tilt ........................... .178
Steering Wheel Audio Controls .............. .347
Steering Wheel Mounted Sound System Controls . . .347
Storage Compartment, Center Seat ............ .222
Storage, Vehicle ...................... .371, 617
Storing Your Vehicle ...................... .617
Supplemental Restraint System - Air Bag .........69
Supplemental Tire Pressure Information ........ .484
Sway Control, Trailer ...................... .455
Synthetic Engine Oil ...................... .571
System, Remote Starting .....................33
Temperature Control, Automatic (ATC) ......... .369
Tilt
Down .............................. .145
Up ................................ .14510 INDEX 667

Tilt Steering Column ...................... .178
Tip Start ............................... .403
Tire And Loading Information Placard . . . .466, 467, 484
Tire Markings ........................... .459
Tires.................... .120, 471, 477, 478, 647
Aging (Life Of Tires) .................... .481
Air Pressure .......................... .471
Chains .............................. .484
Compact Spare ........................ .478
Dual ......................... .487, 538, 547
General Information .............. .471, 477, 478
High Speed .......................... .474
Inflation Pressures ...................... .472
Life Of Tires .......................... .481
Load Capacity ..................... .466, 467
Pressure Monitor System (TPMS) ........... .488
Pressure Warning Light .................. .254
Quality Grading ....................... .647
Radial .............................. .475 Replacement .......................... .482
Rotation ............................. .486
Safety ........................... .459, 471
Sizes ............................... .461
Snow Tires ........................... .476
Spare Tire ..................... .477, 478, 479
Spinning ............................ .480
Tread Wear Indicators ................... .480
Wheel Nut Torque ..................... .545
Tire Safety Information .................... .459
Tongue Weight/Trailer Weight ............... .513
Torque Converter Clutch ................... .419
Tow Hooks, Emergency .................... .554
Towing ............................ .507, 556
Disabled Vehicle ....................... .556
Guide .............................. .513
Recr eational .......................... .528
W eight .............................. .513
Towing Vehicle Behind A Motorhome .......... .528668 INDEX