cooling RAM CHASSIS CAB 2016 Owner's Manual

The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!• Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is
overheated. Do not loosen or remove the cap to cool
an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scalding
or injury, do not remove the pressure cap while the
system is hot or under pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Checking Coolant Level — 6.4L Engine
The level of the coolant in the pressurized coolant bottle
should be between the “MIN” and “MAX” range on the
bottle when the engine is cold.
The radiator normally remains completely full, so there is
no need to remove the cap unless checking for coolant
freeze point or replacing engine coolant (antifreeze).
Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant 7MAINTAINING YOUR VEHICLE 591

bottle need only be checked once a month. When addi-
tional engine coolant (antifreeze) is needed to maintain
the proper level, it should be added to the coolant bottle.
Do not overfill.
Points To Remember
NOTE: When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle. • Check the coolant freeze point in the radiator and in
the coolant expansion bottle. If engine coolant (anti-
freeze) needs to be added, the contents of the coolant
expansion bottle must also be protected against freez-
ing.
• If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
• Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to
MS.90032) and distilled water for proper corrosion
protection of your engine which contains aluminum
components.
• Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.592 MAINTAINING YOUR VEHICLE

FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)
Standard Rear Tank 52 Gallons 197 Liters
Optional Midship Tank 22 Gallons 83 Liters
Engine Oil With Filter
6.4L Engine (We recommend you use SAE 0W-40, Synthetic API
Certified) 7 Quarts 6.6 Liters
Cooling System
6.4L Engine (We recommend you use MOPAR Antifreeze/Coolant
10 Year/150,000 Mile Formula). 16.6 Quarts 15.7 Liters626 MAINTAINING YOUR VEHICLE

CAUTION!• Mixing of engine coolant (antifreeze) other than
specified Organic Additive Technology (OAT) en-
gine coolant (antifreeze), may result in engine
damage and may decrease corrosion protection.
Organic Additive Technology (OAT) engine cool-
ant is different and should not be mixed with
Hybrid Organic Additive Technology (HOAT) en-
gine coolant (antifreeze) or any “globally compat-
ible” coolant (antifreeze). If a non-OAT engine
coolant (antifreeze) is introduced into the cooling
system in an emergency, the cooling system will
need to be drained, flushed, and refilled with fresh
OAT coolant (conforming to MS.90032), by an au-
thorized dealer as soon as possible. (Continued) CAUTION! (Continued)• Do not use water alone or alcohol-based engine
coolant (antifreeze) products. Do not use additional
rust inhibitors or antirust products, as they may not
be compatible with the radiator engine coolant and
may plug the radiator.
• This vehicle has not been designed for use with
propylene glycol-based engine coolant (antifreeze).
Use of propylene glycol-based engine coolant (an-
tifreeze) is not recommended.628 MAINTAINING YOUR VEHICLE

Once A Month Or Before A Long Trip:
• Check engine oil level
• Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and automatic trans-
mission and fill as needed.
• Check function of all interior and exterior lights
Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance. At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
• Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
• Lube the front drive shaft fitting. 8MAINTENANCE SCHEDULES 633

Cleaning
Wheels .............................. .603
Climate Control ...................... .351, 361
Automatic ........................... .361
Cold Weather Operation ................... .403
Compact Disc (CD) Maintenance ............. .348
Compact Spare Tire ....................... .478
Console, Overhead ....................... .208
Contract, Service ......................... .643
Coolant Pressure Cap (Radiator Cap) .......... .590
Cooling System .......................... .587
Adding Coolant (Antifreeze) .............. .589
Coolant Capacity ...................... .626
Coolant Level ..................... .587, 591
Disposal Of Used Coolant ................ .591
Drain, Flush, And Refill .................. .588
Inspection ........................... .591
Points To Remember .................... .592
Pressure Cap ......................... .590 Radiator Cap ......................... .590
Selection Of Coolant (Antifreeze) ........ .588, 627
Corrosion Protection ...................... .600
Cruise Light ......................... .266, 267
Cupholders ............................ .217
Customer Assistance ...................... .641
Customer Programmable Features ............ .329
Data Recorder, Event .......................82
Daytime Running Lights ................... .165
Dealer Service ........................... .568
Defroster, Rear Window .................... .226
Defroster, Windshield ...................119,354
Delay (Intermittent) Wipers ................. .175
Differential, Limited-Slip ................... .434
Dipsticks
Automatic Transmission ................. .598
Power Steering ........................ .438
Disabled V ehicle Towing ................... .55610 INDEX 655

Traction ............................... .434
Traction Control ......................... .449
Trailer Sway Control (TSC) ................. .455
Trailer Towing .......................... .507
Cooling System Tips .................... .524
Hitches ............................. .512
Minimum Requirements ................. .514
Mirrors ............................. .141
Trailer And Tongue Weight ............... .513
Wiring .............................. .522
Trailer Towing Guide ...................... .513
Trailer Weight ........................... .513
Transfer Case ........................... .596
Electronically Shifted .................... .427
Fluid ............................... .629
Transmission ........................... .596
Automatic ........................ .408, 596
Fluid ............................... .629
Shifting ............................. .405 Transmitter Battery Service (Remote Keyless Entry) . .30
Transmitter Programming (Remote Keyless Entry) . . .25
Transmitter, Remote Keyless Entry (RKE) .........25
Transporting Pets .........................114
Tread Wear Indicators ..................... .480
Turn Signals ..................... .173, 265, 619
Uconnect
Customer Programmable Features ....... .323, 341
Operation ............................ .346
Uconnect Settings ...................... .312
Uconnect Settings ................... .323, 341
Uconnect 8.4A/8.4AN Voice Recognition
Additional Information .................. .396
Do Not Disturb ....................... .394
Siri Eyes Free ......................... .394
Uconnect 8.4 Settings
Customer Programmable Features — Units .... .33210 INDEX 669