battery RAM CHASSIS CAB 2016 Service Manual

Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic main-
tenance required.
WARNING!• Battery fluid is a corrosive acid solution and can
burn or even blind you. Do not allow battery fluid
to contact your eyes, skin, or clothing. Do not lean
over a battery when attaching clamps. If acid
splashes in eyes or on skin, flush the area imme-
diately with large amounts of water. Refer to
“Jump-Starting Procedures” in “What To Do In
Emergencies” for further information.
• Battery gas is flammable and explosive. Keep
flame or sparks away from the battery. Do not use
a booster battery or any other booster source with (Continued) WARNING! (Continued)an output greater than 12 Volts. Do not allow cable
clamps to touch each other.
• Battery posts, terminals, and related accessories
contain lead and lead compounds. Wash hands
after handling.
CAUTION!• It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked positive
(+) and negative (-) and are identified on the
battery case. Cable clamps should be tight on the
terminal posts and free of corrosion. (Continued) 7MAINTAINING YOUR VEHICLE 577

CAUTION! (Continued)• If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables be-
fore connecting the charger to the battery. Do not
use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time. WARNING!• Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.578 MAINTAINING YOUR VEHICLE

Power Distribution Center
The Power Distribution Center is located in the engine
compartment near the battery. This center contains car-
tridge fuses, micro fuses, relays, and circuit breakers. A
description of each fuse and component may be stamped
on the inside cover, otherwise the cavity number of each
fuse is stamped on the inside cover that corresponds to
the following chart.
Cavity Cartridge Fuse Micro Fuse Description
F01 80 Amp Black – Rad Fan Control Module – If Equipped
F03 60 Amp Yellow – Rad Fan – If Equipped
F05 40 Amp Green – Compressor for Air Suspension – If
EquippedPower Distribution Center Location608 MAINTAINING YOUR VEHICLE

Cavity Cartridge Fuse Micro Fuse Description
F37 30 Amp Pink – Cummins Diesel Fuel Heater #2 – If
Equipped
F38 30 Amp Pink – Power Inverter 115V AC – If Equipped
F39 20 Amp Blue – Power Outlet – Special Services Only
F41 – 10 Amp Red Active Grill Shutter – If Equipped
F42 – 20 Amp Yellow Horn
F44 – 10 Amp Red Diagnostic Port
F46 – 10 Amp Red Upfitter – If Equipped
F49 – 10 Amp Red Instrument Panel Cluster
F50 – 20 Amp Yellow Air Suspension Control Module – If
Equipped
F51 – 10 Amp Red Ignition Node Module / Keyless Ignition
F52 – 5 Amp Tan Battery Sensor
F53 – 20 Amp Yellow Trailer Tow – Left Turn/Stop Lights
F54 – 20 Amp Yellow Adjustable Pedals612 MAINTAINING YOUR VEHICLE

CAUTION!• When installing the power distribution center
cover, it is important to ensure the cover is properly
positioned and fully latched. Failure to do so may
allow water to get into the power distribution
center and possibly result in an electrical system
failure.
• When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If
a properly rated fuse continues to blow, it indicates
a problem in the circuit that must be corrected.
VEHICLE STORAGE
If you are storing your vehicle for more than 21 days, we
recommend that you take the following steps to mini-
mize the drain on your vehicle’s battery: • Disconnect the negative cable from battery.
• Any time you store your vehicle or keep it out of
service (i.e., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
REPLACEMENT BULBS
LIGHT BULBS — Interior
Bulb Number
Overhead Console
Lamps TS 212-2
Dome Lamp 7679
For lighted switches, see your authorized dealer for
replacement instructions. 7MAINTAINING YOUR VEHICLE 617

Base Quad / Premium Bi-Halogen: Low Beam
Headlamp, High Beam Headlamp, Front Park And
Turn — If Equipped
1. Open the hood.
2. Disconnect and isolate the negative battery cable.
3. Remove the six plastic push-in fasteners that secure
the upper radiator seal to the grille support and both
fender ledges.
4. Remove the two plastic push-in rivets that secure the
upper radiator seal to the radiator.
5. Remove the upper radiator seal from the vehicle.
6. Remove the two headlamp assembly attachment
screws. 7. Reach into the front wheel house ahead of the front
wheel, remove the fastener, and lift the cover over the
access hole in the front of the wheel house splash
shield. Access to the rear of the lamp can be gained
through this access hole. Headlamp Assembly Attachment Screw Locations
7MAINTAINING YOUR VEHICLE 619

Once A Month Or Before A Long Trip:
• Check engine oil level
• Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and automatic trans-
mission and fill as needed.
• Check function of all interior and exterior lights
Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance. At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
• Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
• Lube the front drive shaft fitting. 8MAINTENANCE SCHEDULES 633

Disposal ............................. .591
Anti-Lock Brake System (ABS) ............... .443
Appearance Care ........................ .600
Ashtray ............................... .215
Assist, Hill Start ......................... .446
Auto Down Power Windows ..................47
Automatic Door Locks ......................39
Automatic Headlights ..................... .163
Automatic High Beams .................... .166
Automatic Temperature Control (ATC) ......... .369
Automatic Transmission ................... .596
Adding Fluid ......................... .599
Fluid And Filter Changes ................. .600
Fluid Level Check ...................... .598
Fluid Type ........................ .596, 629
Shifting ............................. .408
Special Additives ...................... .597
Axle Fluid ....................... .595, 596, 629 Axle Lubrication ..................... .595, 596
Back-Up Camera ......................... .205
Battery ............................ .245, 577
Charging System Light .................. .245
Keyless Transmitter Replacement (RKE) ........30
Belts, Seat ...............................118
Body Builders Guide ........................6
Body Mechanism Lubrication ................ .580
B-Pillar Location ......................... .466
Brake Assist System ...................... .445
Brake Control System, Electronic ............. .442
Brake Fluid ......................... .593, 629
Brake System ........................ .442, 593
Fluid Check .......................... .593
Master Cylinder ....................... .593
Parking ............................. .439
Warning Light ........................ .242
Brake/Transmission Interlock ................ .40810 INDEX 653

Lug Nuts .................... .537, 538, 545, 547
Maintenance Free Battery ................... .577
Maintenance Procedures ................... .568
Maintenance Schedule ..................... .632
Malfunction Indicator Light (Check Engine) . . .250, 566
Manual, Service ......................... .646
Manual Transmission
Fluid Level Check ...................... .596
Memory Seat ........................... .156
Methanol .............................. .499
Mirrors ............................... .128
Electric Powered ....................... .138
Heated .............................. .140
Memory ............................. .156
Outside ............................. .136
Rearview ..................... .128, 129, 136
Trailer Towing ........................ .141
Modifications/Alterations, Vehicle ...............7 Monitor, Tire Pressure System ............... .488
MOPAR Parts ........................ .567, 645
MTBE/ETBE ........................... .499
Multi-Function Control Lever ................ .173
Navigation System (Uconnect GPS) ............ .205
New Vehicle Break-In Period .................115
Occupant Restraints ........................50
Octane Rating, Gasoline (Fuel) ............... .498
Oil, Engine ......................... .569, 627
Capacity ............................ .626
Change Interval ....................... .570
Dipstick ............................. .569
Disposal ............................. .571
Filter ............................ .572, 627
Filter Disposal ........................ .571
Identification Logo ..................... .570
Pressure Warning Light .................. .246662 INDEX

Traction ............................... .434
Traction Control ......................... .449
Trailer Sway Control (TSC) ................. .455
Trailer Towing .......................... .507
Cooling System Tips .................... .524
Hitches ............................. .512
Minimum Requirements ................. .514
Mirrors ............................. .141
Trailer And Tongue Weight ............... .513
Wiring .............................. .522
Trailer Towing Guide ...................... .513
Trailer Weight ........................... .513
Transfer Case ........................... .596
Electronically Shifted .................... .427
Fluid ............................... .629
Transmission ........................... .596
Automatic ........................ .408, 596
Fluid ............................... .629
Shifting ............................. .405 Transmitter Battery Service (Remote Keyless Entry) . .30
Transmitter Programming (Remote Keyless Entry) . . .25
Transmitter, Remote Keyless Entry (RKE) .........25
Transporting Pets .........................114
Tread Wear Indicators ..................... .480
Turn Signals ..................... .173, 265, 619
Uconnect
Customer Programmable Features ....... .323, 341
Operation ............................ .346
Uconnect Settings ...................... .312
Uconnect Settings ................... .323, 341
Uconnect 8.4A/8.4AN Voice Recognition
Additional Information .................. .396
Do Not Disturb ....................... .394
Siri Eyes Free ......................... .394
Uconnect 8.4 Settings
Customer Programmable Features — Units .... .33210 INDEX 669