oil filter RAM CHASSIS CAB 2016 Owners Manual

MAINTAINING YOUR VEHICLECONTENTS  ENGINE COMPARTMENT — 6.4L ......... .563
 ONBOARD DIAGNOSTIC SYSTEM (OBD II) . . .564
▫ Onboard Diagnostic System (OBD II)
Cybersecurity ....................... .564
▫ Loose Fuel Filler Cap Message ........... .565
 EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS ......................... .566
 REPLACEMENT PARTS ................. .567
 DEALER SERVICE ..................... .568
 MAINTENANCE PROCEDURES .......... .568 ▫ Engine Oil ......................... .569
▫ Engine Oil Filter ..................... .572
▫ Engine Air Cleaner Filter ............... .572
▫ Accessory Drive Belt Inspection .......... .575
▫ Maintenance-Free Battery .............. .577
▫ Air Conditioner Maintenance ............ .578
▫ Front Prop Shaft Lubrication — Four-Wheel Drive
Models ............................ .579
▫ Body Lubrication .................... .580
▫ Windshield Wiper Blades .............. .5817

ENGINE COMPARTMENT — 6.4L
1 — Coolant Pressure Bottle 6 — Battery
2 — Transmission Dipstick 7 — Power Distribution Center (Fuses)
3 — Engine Oil Fill 8 — Washer Solvent
4 — Engine Oil Dipstick 9 — Power Steering Fluid Reservoir
5 — Brake Fluid Reservoir 10 — Air Cleaner Filter 7MAINTAINING YOUR VEHICLE 563

CAUTION!Do not use chemical flushes in your engine oil as the
chemicals can damage your engine. Such damage is
not covered by the New Vehicle Limited Warranty.
Engine Oil Viscosity (SAE Grade) — 6.4L Engine
Use MOPAR SAE 0W-40 engine oil approved to FCA
Material Standard MS-12633 such as Pennzoil Ultra
equivalent is recommended for all operating tempera-
tures.
The engine oil filler cap also shows the recommended
engine oil viscosity for your engine. For information on
engine oil filler cap location, refer to the “Engine Com-
partment” in this section.
Lubricants which do not have both the engine oil certi-
fication mark and the correct SAE viscosity grade num-
ber should not be used. Synthetic Engine Oils
You may use synthetic engine oils provided the recom-
mended oil quality requirements are met, and the recom-
mended maintenance intervals for oil and filter changes
are followed.
Synthetic engine oils which do not have both the engine
oil certification mark and the correct SAE viscosity grade
number should not be used.
Disposing Of Used Engine Oil And Oil Filters
Care should be taken in disposing of used engine oil and
oil filters from your vehicle. Used oil and oil filters,
indiscriminately discarded, can present a problem to the
environment. Contact your authorized dealer, service
station or governmental agency for advice on how and
where used oil and oil filters can be safely discarded in
your area. 7MAINTAINING YOUR VEHICLE 571

Engine Oil Filter
The engine oil filter should be replaced with a new filter
at every engine oil change.
Engine Oil Filter Selection
The manufacturer’s engines have a full-flow type oil
filter. Use a filter of this type for replacement. The quality
of replacement filters varies considerably. Only high-
quality filters should be used to assure most efficient
service. MOPAR engine oil filters are a high-quality oil
filter and are recommended.
Engine Air Cleaner Filter
Refer to the “Maintenance Schedule” in the “Mainte-
nance Schedules” section for the proper maintenance
intervals. WARNING!The air induction system (air cleaner, hoses, etc.) can
provide a measure of protection in the case of engine
backfire. Do not remove the air induction system (air
cleaner, hoses, etc.) unless such removal is necessary
for repair or maintenance. Make sure that no one is
near the engine compartment before starting the
vehicle with the air induction system (air cleaner,
hoses, etc.) removed. Failure to do so can result in
serious personal injury.
Engine Air Cleaner Filter Selection
The quality of replacement engine air cleaner filters
varies considerably. Only high quality filters should be
used to assure most efficient service. MOPAR engine air
cleaner filters are a high quality filter and are recom-
mended.572 MAINTAINING YOUR VEHICLE

FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)
Standard Rear Tank 52 Gallons 197 Liters
Optional Midship Tank 22 Gallons 83 Liters
Engine Oil With Filter
6.4L Engine (We recommend you use SAE 0W-40, Synthetic API
Certified) 7 Quarts 6.6 Liters
Cooling System
6.4L Engine (We recommend you use MOPAR Antifreeze/Coolant
10 Year/150,000 Mile Formula). 16.6 Quarts 15.7 Liters626 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
Component Fluid, Lubricant, or Genuine Part
Engine Coolant We recommend you use MOPAR Antifreeze/Coolant 10–Year/
150,000 Mile Formula OAT (Organic Additive Technology).
Engine Oil – 6.4L Engine For best performance and maximum protection under all
types of operating conditions, the manufacturer only recom-
mends full synthetic engine oils that meet the American Petro-
leum Institute (API) categories of SN. The manufacturer rec-
ommends the use of Pennzoil Ultra 0W-40 or equivalent
MOPAR engine oil meeting the requirements of FCA Material
Standard MS-12633 for use in all operating temperatures.
Engine Oil Filter – 6.4L Engine We recommend you use MOPAR Engine Oil Filters.
Spark Plugs – 6.4L Engine We recommend you use MOPAR Spark Plugs.
Fuel Selection – 6.4L Engine 89 Octane Recommended - 87 Octane Acceptable, 0-15% Etha-
nol. 7MAINTAINING YOUR VEHICLE 627

Once A Month Or Before A Long Trip:
• Check engine oil level
• Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and automatic trans-
mission and fill as needed.
• Check function of all interior and exterior lights
Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance. At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
• Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
• Lube the front drive shaft fitting. 8MAINTENANCE SCHEDULES 633

Emission Control System Maintenance ......... .566
Engine ................................ .563
Air Cleaner .......................... .572
Break-In Recommendations ................115
Compartment Identification ............... .563
Coolant (Antifreeze) .................... .627
Exhaust Gas Caution .................117,502
Flooded, Starting ...................... .403
Fuel Requirements ..................... .498
Jump Starting ......................... .548
Oil ............................. .569, 627
Oil Filler Cap ......................... .571
Oil Filter ............................ .572
Oil Selection .......................... .570
Oil Synthetic ......................... .571
Overheating .......................... .536
Engine Oil Viscosity ...................... .571
Enhanced Accident Response Feature ............79
Entry System, Illuminated ....................24 Ethanol ............................... .499
Event Data Recorder ........................82
Exhaust Gas Caution ....................117,502
Exhaust System .......................117,585
Exterior Lighting ......................... .163
Exterior Lights .......................... .120
Filters
Air Cleaner .......................... .572
Engine Fuel .......................... .627
Engine Oil ........................ .572, 627
Engine Oil Disposal .................... .571
Flashers
Turn Signal .................... .120, 173, 265
Flat Tire Stowage ........................ .548
Flooded Engine Starting ................... .403
Fluid, Brake ............................ .629
Fluid Capacities ......................... .626
Fluid Leaks ............................ .12110 INDEX 657

Lug Nuts .................... .537, 538, 545, 547
Maintenance Free Battery ................... .577
Maintenance Procedures ................... .568
Maintenance Schedule ..................... .632
Malfunction Indicator Light (Check Engine) . . .250, 566
Manual, Service ......................... .646
Manual Transmission
Fluid Level Check ...................... .596
Memory Seat ........................... .156
Methanol .............................. .499
Mirrors ............................... .128
Electric Powered ....................... .138
Heated .............................. .140
Memory ............................. .156
Outside ............................. .136
Rearview ..................... .128, 129, 136
Trailer Towing ........................ .141
Modifications/Alterations, Vehicle ...............7 Monitor, Tire Pressure System ............... .488
MOPAR Parts ........................ .567, 645
MTBE/ETBE ........................... .499
Multi-Function Control Lever ................ .173
Navigation System (Uconnect GPS) ............ .205
New Vehicle Break-In Period .................115
Occupant Restraints ........................50
Octane Rating, Gasoline (Fuel) ............... .498
Oil, Engine ......................... .569, 627
Capacity ............................ .626
Change Interval ....................... .570
Dipstick ............................. .569
Disposal ............................. .571
Filter ............................ .572, 627
Filter Disposal ........................ .571
Identification Logo ..................... .570
Pressure Warning Light .................. .246662 INDEX

Recommendation ...................... .570
Synthetic ............................ .571
Viscosity ............................ .571
Oil Filter, Change ........................ .572
Oil Pressure Light ........................ .246
Onboard Diagnostic System ................. .564
Operating Precautions ..................... .564
Operator Manual (Owner’s Manual) .............4
Outside Rearview Mirrors .................. .136
Overdrive .............................. .417
Overdrive OFF Switch ..................... .417
Overhead Console ........................ .208
Overheating, Engine ...................... .536
Owner’s Manual (Operator Manual) ..........4,646
Paint Care ............................. .600
Panic Alarm ..............................29
Parking Brake ........................... .439
ParkSense System, Rear ................. .187, 196 Passing Light ........................... .174
Passive Entry .............................42
Pedals, Adjustable ........................ .179
Personalized Menu Bar .................... .373
Personal Settings ..................... .282, 305
Pets ...................................114
Placard, Tire And Loading Information ......... .467
Power
Distribution Center (Fuses) ............... .608
Door Locks ............................39
Mirrors ............................. .138
Outlet (Auxiliary Electrical Outlet) ....... .210, 216
Seats ............................... .143
Sliding Rear Window ................... .227
Steering .......................... .437, 438
Take-Off Adapter ...................... .420
Take-Off Operation ..................... .420
Windows ..............................46 10 INDEX 663