radiator RAM CHASSIS CAB 2017 User Guide

• Check the coolant freeze point in the radiator and in the
coolant expansion bottle. If engine coolant (antifreeze)
needs to be added, the contents of the coolant expansion
bottle must also be protected against freezing.
• If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
• Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to
MS.90032) and distilled water for proper corrosion pro-
tection of your engine which contains aluminum com-
ponents.
• Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
• Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install ONLY
the correct type thermostat. Other designs may result in
unsatisfactory engine coolant (antifreeze) performance,
poor gas mileage, and increased emissions. Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically. Refer
to the “Maintenance Schedule” for the proper maintenance
intervals.
WARNING!Riding the brakes can lead to brake failure and possi-
bly a collision. Driving with your foot resting or riding
on the brake pedal can result in abnormally high brake
temperatures, excessive lining wear, and possible
brake damage. You would not have your full braking
capacity in an emergency.
Brake Fluid Level Check
The fluid level of the master cylinder should be checked
when performing under the hood service or immediately if
the brake system warning lamp indicates system failure.
The brake master cylinder has a translucent plastic reser-
voir. On the outboard side of the reservoir, there is a
“MAX” mark and a “MIN” mark. The fluid level must be
kept within these two marks. Do not add fluid above the
MAX mark because leakage may occur at the cap. 7MAINTAINING YOUR VEHICLE 475

BULB REPLACEMENT
NOTE: Lens fogging can occur under certain atmospheric
conditions. This will usually clear as atmospheric condi-
tions change to allow the condensation to change back into
a vapor. Turning the lamps on will usually accelerate the
clearing process.
Base Quad / Premium Bi-Halogen: Low Beam
Headlamp, High Beam Headlamp, Front Park And
Turn — If Equipped
1. Open the hood.
2. Disconnect and isolate the negative battery cable.
3. Remove the six plastic push-in fasteners that secure the
upper radiator seal to the grille support and both fender
ledges.
4. Remove the two plastic push-in rivets that secure the
upper radiator seal to the radiator.
5. Remove the upper radiator seal from the vehicle. 6. Remove the two headlamp assembly attachment screws.
7. Reach into the front wheel house ahead of the front
wheel, remove the fastener, and lift the cover over the
access hole in the front of the wheel house splash shield.
Access to the rear of the lamp can be gained through this
access hole. Headlamp Assembly Attachment Screw Locations 7MAINTAINING YOUR VEHICLE 495

CAUTION!• Mixing of engine coolant (antifreeze) other than
specified Organic Additive Technology (OAT) en-
gine coolant (antifreeze), may result in engine dam-
age and may decrease corrosion protection. Organic
Additive Technology (OAT) engine coolant is differ-
ent and should not be mixed with Hybrid Organic
Additive Technology (HOAT) engine coolant (anti-
freeze) or any “globally compatible” coolant (anti-
freeze). If a non-OAT engine coolant (antifreeze) is
introduced into the cooling system in an emergency,
the cooling system will need to be drained, flushed, (Continued) CAUTION! (Continued)and refilled with fresh OAT coolant (conforming to
MS.90032), by an authorized dealer as soon as pos-
sible.
• Do not use water alone or alcohol-based engine
coolant (antifreeze) products. Do not use additional
rust inhibitors or antirust products, as they may not
be compatible with the radiator engine coolant and
may plug the radiator.
• This vehicle has not been designed for use with
propylene glycol-based engine coolant (antifreeze).
Use of propylene glycol-based engine coolant (anti-
freeze) is not recommended.502 MAINTAINING YOUR VEHICLE

Fluid Type ......................... .478, 503
Shifting .............................. .327
Special Additives ........................ .478
Axle Fluid ........................ .476, 477, 503
Axle Lubrication ....................... .476, 477
Back-Up Camera .......................... .156
Battery .............................. .200, 458
Charging System Light ................... .200
Keyless Key Fob Replacement ................26
Belts, Seat .................................92
Body Builders Guide ..........................6
Body Mechanism Lubrication ................. .466
B-Pillar Location .......................... .371
Brake Assist System ........................ .355
Brake Control System, Electronic ............... .353
Brake Fluid .......................... .475, 503
Brake System ......................... .352, 475
Fluid Check ........................... .475
Master Cylinder ........................ .475
Parking .............................. .350
Warning Light .......................... .198
Brake/Transmission Interlock ................. .327
Bulb Replacement ......................... .495 Bulbs, Light ........................... .94, 494
Cab Top Clearance Lights .................... .498
Camera, Rear ............................ .156
Capacities, Antifreeze (Engine Coolant) .......... .500
Capacities, Fluid .......................... .500
Caps, Filler
Oil (Engine) ........................... .453
Power Steering ......................... .350
Radiator (Coolant Pressure) ................ .473
Carbon Monoxide Warning ................ .91, 400
Cargo Light ............................. .131
Car Washes .............................. .481
Center High Mounted Stop Light .............. .497
Center Seat Storage Compartment .............. .178
Certification Label ......................... .401
Chart, Tire Sizing .......................... .367
Check Engine Light (Malfunction Indicator Light). . . .449
Checking Your Vehicle For Safety ................91
Checks, Safety .............................91
Child Restraint .............................66
Child Restraints
Booster Seats ............................71
Child Restraints ..........................66 10 INDEX 519

Child Seat Installation .................. .80, 81
How To Stow An Unused ALR Seat Belt .........78
Infants And Child Restraints .................68
Locating The LATCH Anchorages ..............76
Lower Anchors And Tethers For Children ........73
Older Children And Child Restraints ...........70
Seating Positions ..........................72
Cigar Lighter ............................ .173
Clean Air Gasoline ........................ .397
Cleaning
Wheels ............................... .482
Climate Control ........................... .277
Cold Weather Operation ..................... .323
Compact Disc (CD) Maintenance ............... .275
Compact Spare Tire ........................ .381
Console, Overhead ........................ .159
Contract, Service .......................... .514
Coolant Pressure Cap (Radiator Cap) ............ .473
Cooling System ........................... .471
Adding Coolant (Antifreeze) ................ .472
Coolant Capacity ........................ .500
Coolant Level ....................... .471, 474
Disposal Of Used Coolant ................. .474
Drain, Flush, And Refill ................... .472
Inspection ............................. .474 Points To Remember ..................... .474
Pressure Cap ........................... .473
Radiator Cap .......................... .473
Selection Of Coolant (Antifreeze) ......... .472, 501
Corrosion Protection ....................... .480
Cruise Light ....................... .216, 217, 218
Cupholders .............................. .174
Customer Assistance ....................... .512
Customer Programmable Features .............. .255
Daytime Running Lights .................... .126
Dealer Service ............................ .450
Defroster, Rear Window ..................... .182
Defr oster , Windshield ........................93
Delay (Intermittent) Wipers .................. .134
Differential, Limited-Slip .................... .346
Dipsticks
Automatic Transmission ................... .479
Power Steering ......................... .350
Disabled Vehicle Towing .................... .442
Disposal
Antifreeze (Engine Coolant) ................ .474
Do Not Disturb ........................... .314
Door Ajar ............................... .203
Door Ajar Light ........................... .203520 INDEX

Take-Off Adapter ........................ .336
Take-Off Operation ...................... .336
Windows ...............................38
Power Seats
Down ..............................111,112
Forward ............................110,111
Rearward ...........................110,111
Recline ................................111
Tilt...................................111
Up................................111,112
Power Steering Fluid ....................... .503
Pregnant Women And Seat Belts .................52
Pretensioners
Seat Belts ...............................52
Programmable Electronic Features .............. .226
Programming Key Fobs (Remote Keyless Entry) ......22
PTO (Power Take-Off) ...................... .336
Radial Ply Tires ........................... .378
Radiator Cap (Coolant Pressure Cap) ........ .472, 473
Radio Frequency
General Information ............ .17, 19, 28, 31, 38
Radio Operation .......................... .275
Radio (Sound Systems) ..................... .273
Rain Sensitive Wiper System .................. .135 Rear Axle (Differential) .................. .476, 477
Rear ParkSense System .................. .142, 150
Rear Window Features ...................... .182
Rear Window, Sliding ...................... .183
Reclining Rear Seats .........................116
Recreational Towing ........................ .419
Shifting Into Transfer Case Neutral (N) ........ .421
Shifting Out Of Transfer Case Neutral (N) ...... .423
Reformulated Gasoline ...................... .397
Refrigerant ........................... .459, 460
Reminder, Seat Belt ..........................42
Remote Control
Starting System ...........................28
Remote Keyless Entry ..................... .22, 23
Programming Additional Key Fobs .............19
Remote Sound System (Radio) Controls .......... .274
Remote Starting
Uconnect Customer Programmable Features . .246, 266
Uconnect Settings .................... .246, 266
Remote Starting System .......................28
Replacement Keys ........................... 1 9
Replacement Parts ......................... .450
Replacement Tires ......................... .384
Reporting Safety Defects .................... .515
Restraint, Head ............................116 10 INDEX 527