service reset RAM CHASSIS CAB 2023 User Guide

342
SERVICING AND MAINTENANCE
SCHEDULED SERVICING
Your vehicle is equipped with an engine oil change
indicator system. This system will alert you when it
is time to change your engine oil by displaying the
words “Oil Change Due” in your instrument cluster
display. The engine oil change indicator system is
duty cycle based, which means the engine oil
change interval may fluctuate depending on your
personal driving style. Failure to change the engine
oil per the maintenance schedule can result in
internal engine damage.
An authorized dealer will reset the oil change
indicator message after completing the scheduled
oil change. If a scheduled oil change is performed
by someone other than an authorized dealer, the
message can be reset by referring to the steps
described under instrument cluster display
Úpage 89. For Gasoline Engines, under no circumstances
should oil change intervals exceed 8,000 miles
(13,000 km), 12 months or 350 hours of engine
run time, whichever comes first. The 350 hours of
engine run or idle time is generally only a concern
for fleet customers.
For Diesel Engines, under no circumstances
should oil change intervals exceed 15,000 miles
(24,000 km) or 12 months, whichever comes first
or sooner if prompted by the oil change indicator
system.
NOTE:
It is recommended that every 3,000 miles
(4,800 km), check the engine oil level at least
30 minutes after a fully warmed engine is shut
off. Checking the oil level while the vehicle is on
level ground will improve the accuracy of the oil
level reading. Add oil only when the level is at or
below the ADD or MIN mark.
Severe service (high ambient temperature,
short trips, heavy loading, trailer towing,
off-road, or law enforcement use) may reduce
oil change intervals.
For Diesel Engines, configured with optional B20
capability are operated with greater than 5% levels
of biodiesel, the oil change interval must not
exceed 12,500 miles (20,000 km) or 400 hours,
whichever comes first under any circumstances.
See the Fuel Requirements section for more
information regarding operation with biodiesel
blend (B6-B20) fuel meeting ASTM specification
D-7467.
Perform Service Indicator — Diesel Engine
Your vehicle will require emissions maintenance at
a set interval. To help remind you when this
maintenance is due, the instrument cluster will
display “Perform Service”. When the “Perform
Service” message is displayed on the instrument
cluster it is necessary to have the emissions
maintenance performed. Emissions maintenance
may include replacing the Closed Crankcase
Ventilation (CCV) filter element. The procedure for
clearing and resetting the “Perform Service”
indicator message is located in the appropriate
Service Information.
CAUTION!
Failure to perform the required maintenance
items may result in damage to the vehicle.

23_DPF_OM_EN_USC_t.book Page 342

372SERVICING AND MAINTENANCE
AUTOMATIC TRANSMISSION
Special Additives
The manufacturer strongly recommends against
using any special additives in the transmission.
Automatic Transmission Fluid (ATF) is an
engineered product and its performance may be
impaired by supplemental additives. Therefore, do
not add any fluid additives to the transmission. The
only exception to this policy is the use of special
dyes for diagnosing fluid leaks in 6-speed
transmissions. Avoid using transmission sealers as
they may adversely affect seals.
Fluid Level Check — 8-Speed Transmission
The fluid level is preset at the factory and does not
require adjustment under normal operating
conditions. Routine fluid level checks are not
required, therefore the transmission has no
dipstick. An authorized dealer can check your
transmission fluid level using special service tools. If you notice fluid leakage or transmission
malfunction, visit an authorized dealer
immediately to have the transmission fluid level
checked. Operating the vehicle with an improper
fluid level can cause severe transmission damage.
Fluid Level Check — 6-Speed Transmission
It is best to check the fluid level when the
transmission is at normal operating temperature
(158-176°F / 70-80°C). This normally occurs
after at least 15 miles (25 km) of driving. At normal
operating temperature the fluid cannot be held
comfortably between the fingertips. You can read
the transmission sump temperature in the
instrument cluster screen Ú page 89.
Use the following procedure to check the
transmission fluid level properly:

1. Monitor the transmission temperature using the instrument cluster display, and operate
the vehicle as required to reach the normal
operating temperature. If the transmission is
not functioning properly, or the vehicle cannot be driven, see the following Note and Caution
about checking the fluid level at colder
temperatures.

2. Park the vehicle on level ground.
3. Run the engine at normal idle speed for at least 60 seconds, and leave the engine
running for the rest of this procedure.
4. Fully apply the parking brake, and press the brake pedal.
5. Place the gear selector momentarily into each gear position (allowing time for the
transmission to fully engage in each position),
ending with the transmission in PARK.
6. Remove the dipstick, wipe it clean and reinsert it until seated.
7. Remove the dipstick again and note the fluid level on both sides. The fluid level reading is
only valid if there is a solid coating of oil on
both sides of the dipstick. Note that the holes
in the dipstick will be full of fluid if the actual
level is at or above the hole. The fluid level
should be between the “HOT” (upper)
reference holes on the dipstick at normal
operating temperature. If the fluid level is low,
add fluid through the dipstick tube to bring it to
the proper level. Do not overfill. Use ONLY the
specified fluid Ú page 421. After adding any
quantity of oil through the dipstick tube, wait a
CAUTION!
Do not use chemical flushes in your
transmission as the chemicals can damage your
transmission components. Such damage is not
covered by the New Vehicle Limited Warranty.
CAUTION!
If a transmission fluid leak occurs, visit an
authorized dealer immediately. Severe
transmission damage may occur. An authorized
dealer has the proper tools to adjust the fluid
level accurately.

23_DPF_OM_EN_USC_t.book Page 372

430 Cooling System
.............................................. 368Adding Coolant (Antifreeze)....................... 369Coolant Level.................................. 368, 370Cooling Capacity........................................ 418Disposal Of Used Coolant.......................... 370Drain, Flush, And Refill.............................. 368Inspection................................................. 370Points To Remember................................. 370Pressure Cap............................................. 369Radiator Cap............................................. 369Selection Of Coolant (Antifreeze)..... 368, 419Corrosion Protection...................................... 407Cruise Control (Speed Control)... 148, 149, 150Cruise Light................................................... 110Customer Assistance..................................... 422Cybersecurity................................................. 199
D
Daytime Running Lights................................... 52Dealer Service............................................... 353Defroster, Rear Window................................... 62Defroster, Windshield............................. 62, 322Delay (Intermittent) Wipers.............................. 57Deleting A Phone........................................... 238Diagnostic System, Onboard......................... 111Diesel Exhaust Brake.................................... 129Diesel Fuel..................................................... 415Diesel Fuel Requirements............................. 415Diesel Fuel System, Re-Priming..................... 363Differential, Limited Slip................................ 147
Dipsticks Power Steering......................................... 148Disabled Vehicle Towing............................... 339Disc Drive..................................................... 232Disconnecting............................................... 238DisposalAntifreeze (Engine Coolant)...................... 370Disturb.......................................................... 241Door Ajar....................................................... 105Door Ajar Light.............................................. 105Door LocksAutomatic.................................................... 27Doors............................................................... 24Draining Fuel/Water Separator Filter............ 360Driver Memory Presets................................. 230Driver’s Seat Back Tilt...................................... 31DrivingThrough Flowing, Rising, Or Shallow Standing Water
................................................... 198Dual Rear Wheels....................... 332, 406, 411
E
Electric Brake Control System....................... 271Anti-Lock Brake System............................ 270Electronic Roll Mitigation................. 272, 277Electrical Power Outlets................................... 71Electronic Range Select (ERS)............. 134, 137Electronic Stability Control (ESC).................. 272Electronic Throttle Control Warning Light...... 104Electronically Shifted Transfer Case.... 140, 143
Emergency Braking.............................. 128, 280Emergency, In Case OfFreeing Vehicle When Stuck..................... 338Hazard Warning Flasher........................... 325Jacking...................................................... 329Jump Starting........................................... 333Emission Control System Maintenance......... 112Engine.................................................. 350, 351Air Cleaner................................................ 355Block Heater............................................. 119Break-In Recommendations............ 127, 128Compartment........................................... 351Compartment Identification...................... 350Coolant (Antifreeze).................................. 419Exhaust Gas Caution................................ 324Fails To Start............................................. 116Flooded, Starting...................................... 116Fuel Requirements................................... 413Identification............................................. 351Idling......................................................... 124Jump Starting........................................... 333Oil.................................................... 353, 419Oil Filler Cap............................................. 350Oil Filter.................................................... 354Oil Reset......................................................92Oil Selection.............................................. 353Oil Synthetic.............................................. 354Overheating.............................................. 335Runaway................................................... 176Starting..................................................... 115

23_DPF_OM_EN_USC_t.book Page 430

432 HomeLink® (Garage Door Opener)
.................. 47Hood Prop........................................................ 77Hood Release.................................................. 77Hub Caps....................................................... 332
I
Idle-Up Feature.............................................. 124Ignition............................................................ 18Switch......................................................... 18Inside Rearview Mirror............................ 39, 326Instrument Cluster........ 83, 84, 85, 86, 87, 89Descriptions.............................................. 110Display........................................................ 89Engine Oil Reset.......................................... 92Instrument Panel Lens Cleaning.................... 410Integrated Trailer Brake Control.................... 188Interior Appearance Care............................... 409Interior Lights.................................................. 55Intermittent Wipers (Delay Wipers).................. 57Intervention Regeneration Strategy........ 98, 364Inverter Outlet (115V)...................................... 72
J
Jack Location................................................ 329Jack Operation.............................................. 329Jacking And Tire Changing............................ 329Jacking And Tire Changing
b
...................... 329Jump Starting............................................... 333
K
Key Fob Panic Alarm
................................................. 16Programming Additional Key Fobs............... 17Key Fob Battery Service
(Remote Keyless Entry).................................... 16
Key Fob Programming (Remote Keyless Entry).. 17
Keyless Enter 'n Go™.................... 25, 115, 117Passive Entry............................................... 25Keys................................................................. 15
L
Lane Change And Turn Signals........................ 54Lane Change Assist......................................... 54LaneSense.................................................... 163Latches......................................................... 324Hood............................................................ 77
Lead Free Gasoline....................................... 413Leaks, Fluid................................................... 324Life Of Tires................................................... 399Light Bulbs........................................... 324, 384LIghtsElectrinic Power Steering Pump................ 105Oil Temperature........................................ 104Lights............................................................ 324Air Bag.................................... 103, 297, 322Automatic High Beam..................................52Brake Assist Warning................................ 274Brake Warning.......................................... 103Bulb Replacement.................................... 384Cab Top Clearance................................... 388Cargo...........................................................54Center Mounted Stop............................... 388Courtesy/Reading........................................55Cruise....................................................... 110Daytime Running.........................................52
Electronic Stability Program (ESP) Indicator.... 104
Exterior.............................................. 51, 324Fog............................................................ 387Four Wheel Drive Indicator....................... 147

23_DPF_OM_EN_USC_t.book Page 432

436 Service Manuals
............................................ 426Settings, Audio.............................................. 230Shift Lever Override....................................... 336Shifting.......................................................... 130Automatic Transmission.................. 132, 135Transfer Case............................................ 146Transfer Case, Shifting Into Transfer Case Neutral (N)............................................ 196Transfer Case, Shifting Out Of Transfer Case Neutral (N)................................... 197Signals, Turn..................................54, 110, 324Sirius Satellite Radio..................................... 226Favorites................................................... 229Replay....................................................... 228SiriusXM Satellite RadioBrowse in SXM.......................................... 229Favorites................................................... 229Replay....................................................... 228Sliding Rear Window, Power............................ 76Smart Watch.................................................. 258Snow Chains (Tire Chains)............................. 404Snow Plow..................................................... 192Snow Tires..................................................... 401SOS Call............................................... 247, 259
Spare Tires.......................................... 401, 402Speed ControlAccel/Decel.............................................. 150Cancel...................................................... 150Resume.................................................... 150Speed Control (Cruise Control)............ 149, 150Starting....................................... 113, 115, 117Automatic Transmission.................. 113, 117Button......................................................... 18Cold Weather............................................ 117Engine Block Heater................................. 119Engine Fails To Start................................. 116Starting And Operating.................................. 115Starting Procedures............................. 115, 117Starting Procedures (Diesel Engines)........... 117Starting Procedures (Gas Engines)............... 113SteeringPower....................................................... 148Tilt Column.................................................. 27Wheel, Heated...................................... 27, 28Wheel, Tilt.................................................... 27
Steering Wheel Audio Controls...................... 224Steering Wheel Mounted Sound System....... 224Stolen Vehicle Assistance.................... 255, 260Storage............................................................65Storage Compartment, Center Seat.................66Storage, Vehicle..................................... 65, 407Store Radio Presets...................................... 230Storing Your Vehicle...................................... 407Sunglasses Storage.........................................68Sway Control, Trailer..................................... 277Synthetic Engine Oil...................................... 354
T
Telescoping Steering Column...........................27Temperature Control, Automatic (ATC).............64TiltDown...........................................................33Up................................................................33Tilt Steering Column.........................................27Tip Start............................................... 115, 117Tire And Loading Information Placard........... 394Tire Markings................................................ 389Tire Safety Information.................................. 389

23_DPF_OM_EN_USC_t.book Page 436