Transmission fluid Ram ProMaster 2020 User Guide

168SERVICING AND MAINTENANCE
Fluid Level Check
The fluid level is preset at the factory and does
not require adjustment under normal operating
conditions. Routine fluid level checks are not
required, therefore the transmission filler tube
is capped and no dipstick is provided. Your
authorized dealer can check your transmission
fluid level using a special service dipstick. If you
notice fluid leakage or transmission malfunc-
tion, visit your authorized dealer immediately to
have the transmission fluid level checked. Oper -
ating the vehicle with an improper fluid level can
cause severe transmission damage.
Fluid And Filter Changes
Refer to the “Maintenance Plan” in this section
for the proper maintenance intervals.
In addition, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if
the transmission is disassembled for any
reason.
RAISING THE VEHICLE
In the case where it is necessary to raise the
vehicle, go to an authorized dealer or service
station.
TIRES
Tire Safety Information
Tire safety information will cover aspects of the
following information: Tire Markings, Tire Identi -
fication Numbers, Tire Terminology and Defini -
tions, Tire Pressures, and Tire Loading.
Tire Markings
Tire Markings
CAUTION!
If a transmission fluid leak occurs, visit an
authorized dealer immediately. Severe
transmission damage may occur. An
authorized dealer has the proper tools to
adjust the fluid level accurately.
1 — US DOT Safety Standards Code (TIN)
2 — Size Designation
3 — Service Description
4 — Maximum Load
5 — Maximum Pressure
6 — Treadwear, Traction and Temperature Grades

20_VF_OM_EN_US_t.book Page 168

TECHNICAL SPECIFICATIONS197
Chassis
Component Fluid, Lubricant, Or Genuine Part

Automatic Transmission
Use Only ATF+4 Automatic Transmission Fluid. Failure to use ATF+4 fluid
may affect the function or performance of your transmission. We
recommend Mopar ATF+4 Fluid.

Brake Master Cylinder
We recommend you use Mopar DOT 4.
DOT 4 brake fluid must be changed every two years regardless of
mileage.

Power Steering Reservoir
Use Pentosin CHF 11S power steering fluid meeting FCA Material
Standard MS-11655.

8

20_VF_OM_EN_US_t.book Page 197

250

INDEX

A

Adding Engine Coolant (Antifreeze)
............... 164
Adding Washing Fluid
............................... 157
Additives, Fuel
....................................... 193
Air Bag
................................................. 74Air Bag Operation............................... 75Air Bag Warning Light.......................... 73Enhanced Accident Response.............. 151Event Data Recorder (EDR)................. 151If Deployment Occurs.......................... 80Maintaining Your Air Bag System............ 81Maintenance..................................... 81Side Air Bags..................................... 76Transporting Pets............................... 89
Air Bag Light
............................... 47, 73, 90
Air Cleaner, Engine (Engine Air Cleaner Filter)
... 159
Air Conditioner Maintenance
...................... 160
Air Conditioner Refrigerant
......................... 160
Air Conditioner System
............................. 160
Air Conditioning Filter
......................... 34, 160
Air Conditioning, Operating Tips
............... 33, 34
Air Filter
.............................................. 159
Air Pressure

Tires.............................................. 177
Alarm
Security Alarm............................. 13, 49

Alarm System
Security Alarm.................................... 13
Alterations/Modifications
Vehicle...............................................8
Antifreeze (Engine Coolant)
................ 164, 195Disposal......................................... 165
Anti-Lock Brake System (ABS)
.......................56
Anti-Lock Warning Light
.............................. 52
Assist, Hill Start
........................................ 60
Auto Down Power Windows
.......................... 35
Auto Up Power Windows
.............................. 35
Automatic Door Locks
................................15
Automatic Transmission
...................... 95, 168Adding Fluid.................................... 168Fluid And Filter Change...................... 168Fluid Change................................... 168Fluid Level Check...................... 167, 168Fluid Type............................... 167, 197Special Additives.............................. 167
AUX Cord
............................................. 238
Auxiliary Driving Systems
............................. 61
B

Battery
......................................... 47, 157Charging System Light......................... 47Keyless Key Fob Replacement............... 10
Belts, Seat
............................................. 90

Body Builders Guide
................................... 8
Body Mechanism Lubrication
..................... 161
B-Pillar Location
.................................... 173
Brake Assist System
................................. 57
Brake Control System, Electronic
................... 57
Brake Fluid
...................................166, 197
Brake System
................................166, 191Anti-Lock (ABS).................................. 56Fluid Check.................................... 166Master Cylinder............................... 166Parking............................................ 94Warning Light.................................... 48
Brake, Parking
........................................ 94
Brake/Transmission Interlock
...................... 96
Bulb Replacement
.................................. 123
Bulbs, Light
....................................91, 123
C

Camera, Rear
....................................... 109
Capacities, Fluid
.................................... 195
Caps, Filler
Fuel.............................................. 111Oil (Engine)..................................... 156Power Steering................................ 103Radiator (Coolant Pressure)................ 165
Car Washes
......................................... 187
Carbon Monoxide Warning
...................89, 194
20_VF_OM_EN_US_t.book Page 250

252

Engine

................................................ 156Air Cleaner...................................... 159Block Heater..................................... 93Break-In Recommendations.................. 93Compartment.................................. 156Compartment Identification................ 156Coolant (Antifreeze)................... 163, 195Cooling........................................... 163Exhaust Gas Caution................... 89, 194Fails To Start..................................... 92Flooded, Starting................................ 92Fuel Requirements................... 192, 195Jump Starting.................................. 145Oil......................................... 158, 195Oil Filler Cap.................................... 156Oil Filter......................................... 159Oil Selection............................ 158, 195Oil Synthetic.................................... 159Overheating.................................... 147Starting............................................ 92
Engine Oil Viscosity
................................. 159
Engine Oil Viscosity Chart
.......................... 159
Enhanced Accident Response Feature
........... 151
Entry System, Illuminated
............................ 27
Ethanol
............................................... 193
Exhaust Gas Cautions
........................ 89, 194
Exhaust System
............................... 89, 162
Exterior Lights
................................... 23, 91
F

Filters
Air Cleaner
...................................... 159Air Conditioning.......................... 34, 160Engine Oil............................... 159, 195Engine Oil Disposal........................... 159
Flashers
Hazard Warning................................ 123Turn Signals................................ 53, 91
Flat Tire Changing
........................... 168, 181
Flat Tire Stowage
............................ 168, 181
Flooded Engine Starting
.............................. 92
Fluid Capacities
.....................................195
Fluid Leaks
............................................. 91
Fluid Level Checks
Automatic Transmission..................... 168Brake............................................. 166Cooling System................................ 163Power Steering................................. 103
Fluids And Lubricants
............................... 195
Fog Lights
.............................................. 25
Fold-Flat Seats
........................................ 15
Four-Way Hazard Flasher
........................... 123
Freeing A Stuck Vehicle
............................ 149

Fuel
.................................................. 192Additives........................................ 193Clean Air........................................ 192Ethanol.......................................... 193Filler Cap (Gas Cap).......................... 111Gasoline........................................ 192Materials Added.............................. 193Methanol....................................... 193Octane Rating..........................192, 195Requirements..........................192, 195Tank Capacity................................. 195
Fuses
................................................ 128
G

Gas Cap (Fuel Filler Cap)
.......................... 111
Gasoline, Clean Air
................................. 192
Gasoline, Reformulated
........................... 192
Gear Ranges
.......................................... 97
Gear Selector Override
............................. 148
Glass Cleaning
...................................... 190
Gross Axle Weight Rating
...................112, 113
Gross Vehicle Weight Rating
...............112, 113
Guide
Body Builders...................................... 8
GVWR
................................................ 112
20_VF_OM_EN_US_t.book Page 252

257

Transmission
Automatic
................................. 95, 167Fluid.............................................. 197Maintenance................................... 167
Transporting Pets
..................................... 89
Tread Wear Indicators
.............................. 179
Turn Signals
........................................... 53
U

Uconnect
Uconnect Settings
............................... 10
Uconnect Settings
Customer Programmable Features....... 199
Uconnect Voice Command
......................... 241
Uniform Tire Quality Grades
........................ 185
Unleaded Gasoline
.................................. 192
Untwisting Procedure, Seat Belt
..................... 69
USB
................................................... 238
V

Vehicle Certification Label
......................... 112
Vehicle Identification Number (VIN)
............... 191
Vehicle Loading
..................... 112, 113, 174
Vehicle Modifications/Alterations
..................... 8
Vehicle Storage
................................ 33, 186
Viscosity, Engine Oil
................................. 159
Voice Command
.....................................241
W

Warning Lights
(Instrument Cluster Descriptions)

................... 51
Warnings And Cautions
.................................8
Warranty Information
............................... 248
Washer
Adding Fluid.................................... 157
Washing Vehicle
.....................................187
Water
Driving Through................................ 121
Wheel And Wheel Tire Care
........................ 183
Wheel And Wheel Tire Trim
........................ 183

Wind Buffeting
........................................ 36
Window Fogging
...................................... 33
Windows
............................................... 35Power.............................................. 35
Windshield Defroster
................................. 90
Windshield Washers
..........................27, 157Fluid............................................... 27
Windshield Wiper Blades
.......................... 162
Windshield Wipers
................................... 27
Wipers Blade Replacement
....................... 162
Wipers, Intermittent
.................................. 28
11
20_VF_OM_EN_US_t.book Page 257