check engine Ram ProMaster City 2015 Owner's Guide

engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant expansion bottle provides a quick visual
method for determining that the coolant level is ad-
equate. With the engine OFF and cold, the level of the
engine coolant (antifreeze) in the bottle should be be-
tween the “MIN” and “MAX” marks.
The radiator normally remains completely full, so there is
no need to remove the radiator/coolant pressure cap
unless checking for engine coolant (antifreeze) freeze
point or replacing coolant. Advise your service attendant
of this. As long as the engine operating temperature is
satisfactory, the coolant bottle need only be checked once
a month.When additional engine coolant (antifreeze) is needed to
maintain the proper level, only OAT coolant that meets
the requirements of FCA Material Standard MS.90032
should be added to the coolant bottle. Do not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle.
348 MAINTAINING YOUR VEHICLE

•Check the coolant freeze point in the radiator and in
the coolant expansion bottle. If engine coolant (anti-
freeze) needs to be added, the contents of the coolant
expansion bottle must also be protected against freez-
ing.
• If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
• Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to
MS.90032) and distilled water for proper corrosion
protection of your engine which contains aluminum
components.
• Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean. •
Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine coolant (antifreeze)
performance, poor gas mileage, and increased emis-
sions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting or
riding on the brake pedal can result in abnormally
(Continued)
7
MAINTAINING YOUR VEHICLE 349

WARNING!(Continued)
cylinder reservoir cap secured at all times. Brake
fluid in a open container absorbs moisture from the
air resulting in a lower boiling point. This may
cause it to boil unexpectedly during hard or pro-
longed braking, resulting in sudden brake failure.
This could result in a collision.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.
• Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Power Steering Fluid
Check the fluid level with the vehicle on flat ground and
engine cold. Fluid should be between MIN and MAX
references on the reservoir body.
The level may go over the MAX line when oil is hot.
If topping off is required, make sure the oil you use is
approved. Refer to “Fluids, Lubricants and Genuine
Parts” in the section for further information.
WARNING!
Because it is flammable, do not allow the power
steering fluid to come into contact with hot engine
parts
NOTE: Power steering fluid consumption is very low. If
you need to top off your fluid often and multiple times
have your system inspected by your authorized dealer.
7
MAINTAINING YOUR VEHICLE 351

MAINTENANCE SCHEDULE
Your vehicle is equipped with an automatic oil change
indicator system. The oil change indicator system will
remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change
indicator message will illuminate. This means that ser-
vice is required for your vehicle. Operating conditions
such as frequent short-trips, trailer tow, extended engine
idle time, extremely hot or cold ambient temperatures
will influence when the “Oil Change Required” message
is displayed. Severe Operating Conditions can cause the
change oil message to illuminate as early as 3,500 miles
(5,600 km) since last reset. Have your vehicle serviced as
soon as possible, within the next 500 miles (805 km).
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone otherthan your authorized dealer, the message can be reset by
referring to the steps described under “Oil Change Reset”
in “Electronic Vehicle Information Center (EVIC)” in
“Understanding Your Instrument Panel” for further in-
formation.
NOTE:
Under no circumstances should oil change inter-
vals exceed 10,000 miles (16,000 km), 350 hours of engine
run time or twelve months, whichever comes first.
Severe Duty All Models
Change Engine Oil at 4000 miles (6,500 km) if the vehicle
is operated in a dusty and off road environment. This
type of vehicle use is considered Severe Duty.
Once A Month Or Before A Long Trip:
• Check engine oil level.
• Check windshield washer fluid level.
380 MAINTENANCE SCHEDULES

•Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before the oil indicator system turns
on.
• Check the fluid levels of the coolant reservoir and
brake master cylinder, fill as needed.
• Check function of all interior and exterior lights.
Required Maintenance Intervals
Refer to the maintenance schedules on the following
page for the required maintenance intervals.At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required
• Inspect brake pads, shoes, rotors, drums, hoses,
lines and park brake
• Inspect engine cooling system protection and
hoses
• Inspect exhaust system
• Inspect engine air cleaner if using in dusty or
off-road conditions 8
MAINTENANCE SCHEDULES 381

Adding Fluid...................... .353, 377
Fluid and Filter Changes ..................353
Fluid Change ......................... .353
Fluid Level Check ...................352, 353
Fluid Type ........................ .352, 377
Special Additives ...................... .352
Auto Up Power Windows ....................27
Auxiliary Electrical Outlet (Power Outlet) ........131
Axle Lubrication ......................... .377
Battery ................................ .336
Keyless Transmitter Replacement (RKE) ........19
Belts, Seat ...............................88
Body Builders Guide ........................6
Body Mechanism Lubrication .................338
B-Pillar Location ......................... .236
Brake Assist System ...................... .222
Brake Fluid ............................ .377
Brake, Parking .......................... .218Brake System
........................ .220, 349
Anti-Lock (ABS) ....................... .221
Fluid Check ....................... .350, 377
Master Cylinder ....................... .350
Parking ............................. .218
Warning Light ........................ .147
Brake/Transmission Interlock .................204
Bulb Replacement ..................... .370, 371
Bulbs, Light .......................... .90, 370
Camera, Rear ........................... .129
Capacities, Fluid ......................... .374
Caps, Filler Fuel ................................ .265
Oil (Engine) ....................... .327, 334
Power Steering ........................ .217
Radiator (Coolant Pressure) ................347
Carbon Monoxide Warning ................87, 264
Cargo Tie-Downs ........................ .137
10
INDEX 397

Car Washes............................ .354
Cellular Phone .......................... .180
Certification Label ........................ .267
Chains, Tire ............................ .253
Chart, Tire Sizing ........................ .231
Check Engine Light (Malfunction Indicator Light) ............147, 329
Checking Your Vehicle For Safety ...............86
Checks, Safety ............................86
Child Restraint ............................61
Child Restraints Booster Seats ...........................66
Child Restraints .........................61
How To Stow An Unused ALR Seat Belt ........75
Infants And Child Restraints ................64
Older Children And Child Restraints ..........64
Cigar Lighter ........................... .134
Clean Air Gasoline ....................... .261Cleaning
Wheels .............................. .356
Climate Control ......................... .181
Manual ............................. .181
Cold Weather Operation ....................200
Compact Spare Tire ....................... .248
Contract, Service ......................... .389
Coolant Pressure Cap (Radiator Cap) ...........347
Cooling System .......................... .343
Adding Coolant (Antifreeze) ...............345
Coolant Capacity ...................... .374
Coolant Level ......................... .348
Disposal of Used Coolant .................347
Drain, Flush, and Refill ...................344
Inspection ........................ .343, 348
Points to Remember .....................348
Pressure Cap ......................... .347
Radiator Cap ......................... .347
Selection of Coolant (Antifreeze) ......344, 374, 375
398 INDEX

Trip Functions........................ .165
Emergency, In Case of Freeing Vehicle When Stuck ................315
Jump Starting ..........................311
Towing ............................. .320
Emission Control System Maintenance ..........329
Engine ................................ .327
Air Cleaner .......................... .335
Block Heater ......................... .201
Break-In Recommendations .................85
Checking Oil Level ..................... .332
Coolant (Antifreeze) .....................375
Cooling ............................. .343
Exhaust Gas Caution ..................87, 264
Fails to Start .......................... .201
Flooded, Starting ...................... .201
Fuel Requirements ..................... .260
Jump Starting ..........................311
Oil .......................... .332, 374, 375Oil Filler Cap
...................... .327, 334
Oil Filter ............................ .335
Oil Selection ...................... .333, 374
Oil Synthetic ......................... .334
Overheating .......................... .287
Starting ............................. .199
Engine Oil Viscosity ...................... .334
Engine Oil Viscosity Chart ...................334
Enhanced Accident Response Feature ............57
Ethanol ............................... .261
Event Data Recorder ........................60
Exhaust Gas Caution ....................87, 264
Exhaust System ....................... .87, 341
Exterior Lights ............................90
Fabric Care ............................. .357
Filters Air Cleaner .......................... .335
Engine Oil ........................ .335, 375
400 INDEX

Engine Oil Disposal.....................334
Flashers Hazard Warning ....................... .287
Turn Signal ........................ .90, 147
Flash-To-Pass ............................111
Flooded Engine Starting ....................201
Fluid, Brake ............................ .377
Fluid Capacities ......................... .374
Fluid Leaks ..............................90
Fluid Level Checks Brake ............................... .350
Engine Oil ........................... .332
Power Steering ........................ .217
Fluids, Lubricants and Genuine Parts ...........375
Fog Lights ...........................113,147
Four-Way Hazard Flasher ...................287
Freeing A Stuck Vehicle .....................315
Fuel .................................. .260
Additives ............................ .263Clean Air
............................ .261
Ethanol ............................. .261
Filler Cap (Gas Cap) .....................265
Gasoline ............................. .260
Gauge .............................. .147
Materials Added ....................... .263
Methanol ............................ .261
Octane Rating ..................... .260, 375
Requirements ......................... .260
Specifications ......................... .375
Tank Capacity ......................... .374
Fuses ................................. .360
Gas Cap (Fuel Filler Cap) ................265, 328
Gasoline, Clean Air ....................... .261
Gasoline (Fuel) .......................... .260
Gasoline, Reformulated .....................261
Gauges Fuel ................................ .147
10
INDEX 401

Introduction..............................4
iPod® Control .......................... .177
iPod®/USB/MP3 Control ...................177
Bluetooth® Streaming Audio ...............177
Jump Starting ............................311
Key-In Reminder ..........................14
Key, Replacement ..........................15
Keys ...................................12
Key, Sentry (Immobilizer) ....................14
Lane Change Assist ........................112
Lap/Shoulder Belts .........................35
Latches .................................90
Lead Free Gasoline ....................... .260
Leaks, Fluid ..............................90
Life of Tires ............................ .251
Light Bulbs .......................... .90, 370Lights
.............................. .90, 110
Airbag ......................... .57, 88, 147
Anti-Lock ............................ .147
Brake Assist Warning ....................226
Brake Warning ........................ .147
Bulb Replacement ...................... .371
Check Engine (Malfunction Indicator) .........147
Cruise .............................. .147
Exterior ...............................90
Fog ................................ .147
Hazard Warning Flasher ..................287
High Beam ........................... .147
High Beam Indicator .....................147
Instrument Cluster ..................... .147
Oil Pressure .......................... .147
Park .................................112
Passing ..............................111
Seat Belt Reminder ..................... .147
Service .............................. .371
10
INDEX 403