battery Ram ProMaster City 2016 Owner's Guide

•The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn OFF
the ignition or start the engine. This means that your
vehicle’s OBD II system is not readyand you should
not proceed to the I/M station.
• The MIL will not flash at all and will remain fully
illuminated until you place the ignition in the off
position or start the engine. This means that your
vehicle’s OBD II system is readyand you can proceed
to the I/M station.
If your OBD II system is not ready,you should see your
authorized dealer or repair facility. If your vehicle was
recently serviced or had a battery failure or replacement,
you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD II
system to update. A recheck with the above test routine
may then indicate that the system is now ready.Regardless of whether your vehicle’s OBD II system is
ready or not, if the MIL is illuminated during normal
vehicle operation you should have your vehicle serviced
before going to the I/M station. The I/M station can fail
your vehicle because the MIL is on with the engine
running.
REPLACEMENT PARTS
Use of genuine MOPAR parts for normal/scheduled
maintenance and repairs is highly recommended to en-
sure the designed performance. Damage or failures
caused by the use of non-MOPAR parts for maintenance
and repairs will not be covered by the New Vehicle
Limited Warranty.
DEALER SERVICE
Your authorized dealer has the qualified service person-
nel, special tools, and equipment to perform all service
operations in an expert manner. Service Manuals are
7
MAINTAINING YOUR VEHICLE 353

WARNING!(Continued)
vehicle with the air induction system (air cleaner,
hoses, etc.) removed. Failure to do so can result in
serious personal injury.
Engine Air Cleaner Filter Selection
The quality of replacement engine air cleaner filters
varies considerably. Only high quality filters should be
used to assure most efficient service. MOPAR engine air
cleaner filters are a high quality filter and are recom-
mended.
Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic main-
tenance required.
WARNING!
•Battery fluid is a corrosive acid solution and can
burn or even blind you. Do not allow battery fluid
to contact your eyes, skin, or clothing. Do not lean
over a battery when attaching clamps. If acid
splashes in eyes or on skin, flush the area imme-
diately with large amounts of water. Refer to
“Jump-Starting Procedures” in “What To Do In
Emergencies” for further information.
• Battery gas is flammable and explosive. Keep
flame or sparks away from the battery. Do not use
a booster battery or any other booster source with
an output greater than 12 Volts. Do not allow cable
clamps to touch each other.
• Battery posts, terminals, and related accessories
contain lead and lead compounds. Wash hands
after handling.
7
MAINTAINING YOUR VEHICLE 359

CAUTION!
•It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to
the negative post. Battery posts are marked positive
(+) and negative (-) and are identified on the
battery case. Cable clamps should be tight on the
terminal posts and free of corrosion.
• If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables be-
fore connecting the charger to the battery. Do not
use a “fast charger” to provide starting voltage.
Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance test. Drive belt tension should also be checked at this
time.
WARNING!
•
Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause the
system to fail, requiring costly repairs. Refer to
Warranty Information Book, located on the DVD,
for further warranty information.
• The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
360 MAINTAINING YOUR VEHICLE

Underhood Fuses
The Front Distribution Unit is located on the right side of
the engine compartment, next to the battery. To access the
fuses, remove fasteners and remove the cover.The ID number of the electrical component correspond-
ing to each fuse can be found on the back of the cover.
Front Distribution Unit
384 MAINTAINING YOUR VEHICLE

CavityMini Fuse Description
F1 10 Amp Red Front Heated Seat Driver
F2 10 Amp Red Front Heated Seat Passenger
F3 20 Amp Yellow Rear Power Window Driver side
F4 20 Amp Yellow Rear Power Window Passenger side
F5 15 Amp Blue 2nd Instrument Panel Power Outlet 12V
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days, you may want to take these steps to protect your
battery.
•Disconnect the negative cable from the battery.
• Anytime you store your vehicle, or keep it out of
service (e.g., vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
ensure adequate system lubrication to minimize the possibility of compressor damage when the system is
started again.
7
MAINTAINING YOUR VEHICLE 391

Once A Month Or Before A Long Trip:
•Check engine oil level.
• Check windshield washer fluid level.
• Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before the oil indicator system turns
on.
• Check the fluid levels of the coolant reservoir and
brake master cylinder, fill as needed.
• Check function of all interior and exterior lights.
Required Maintenance Intervals
Refer to the maintenance schedules on the following
page for the required maintenance intervals.At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required
• Inspect brake pads, shoes, rotors, drums, hoses,
lines and park brake
• Inspect engine cooling system protection and
hoses
• Inspect exhaust system
• Inspect engine air cleaner if using in dusty or
off-road conditions 8
MAINTENANCE SCHEDULES 403

Fluid Change......................... .376
Fluid Level Check ...................375, 376
Fluid Type ........................ .375, 399
Special Additives ...................... .375
Auto Up Power Windows ....................27
Auxiliary Electrical Outlet (Power Outlet) ........130
Axle Lubrication ......................... .399
Battery ............................ .156, 359
Charging System Light ...................156
Keyless Transmitter Replacement (RKE) ........19
Belts, Seat ...............................88
Body Builders Guide ........................6
Body Mechanism Lubrication .................361
B-Pillar Location ......................... .260
Brake Assist System ...................... .246
Brake Fluid ............................ .399
Brake, Parking .......................... .241
Brake System ........................ .244, 372Anti-Lock (ABS)
....................... .244
Fluid Check ....................... .373, 399
Master Cylinder ....................... .373
Parking ............................. .241
Warning Light ........................ .159
Brake/Transmission Interlock .................228
Bulb Replacement ..................... .392, 393
Bulbs, Light .......................... .90, 392
Camera, Rear ........................... .128
Capacities, Fluid ......................... .396
Caps, Filler Fuel ................................ .289
Oil (Engine) ....................... .349, 357
Power Steering ........................ .240
Radiator (Coolant Pressure) ................370
Carbon Monoxide Warning ................87, 288
Cargo Tie-Downs ........................ .136
Car Washes ............................ .377
10
INDEX 421

Door.................................21
Lubrication, Body ........................ .361
Lug Nuts .............................. .312
Maintenance Free Battery ....................359
Maintenance Procedures ....................354
Maintenance Schedule ..................... .402
Malfunction Indicator Light (Check Engine) . . .168, 352
Manual, Service ......................... .414
Master Cylinder (Brakes) ....................373
Methanol .............................. .285
Mirrors .................................94
Electric Powered .........................96
Electric Remote .........................96
Exterior Folding .........................95
Outside ...............................94
Rearview ..............................94
Modifications/Alterations, Vehicle ...............7
Monitor, Tire Pressure System ................279MOPAR Parts
........................ .353, 413
MTBE/ETBE ........................... .285
Multi-Function Control Lever .................111
New Vehicle Break-In Period ..................85
Occupant Restraints ........................32
Octane Rating, Gasoline (Fuel) .............284, 397
Oil Change Indicator ...................... .186
Oil Change Indicator, Reset ..................186
Oil, Engine ......................... .355, 397
Capacity ............................ .396
Change Interval ....................... .356
Checking ............................ .355
Dipstick ............................. .355
Disposal ............................. .358
Filter ............................ .358, 397
Filter Disposal ........................ .358
Identification Logo ..................... .356
428 INDEX

Trailer Towing........................ .301
Tread Wear Indicators ....................274
Tire Safety Information .....................253
Tire Service Kit .......................... .314
Tongue Weight/Trailer Weight ................298
Towing ............................... .293
Disabled Vehicle ....................... .341
Guide .............................. .298
Recreational .......................... .307
Weight .............................. .298
Towing Vehicle Behind A Motorhome ...........307
Traction ............................... .237
Traction Control ......................... .246
Trailer Towing .......................... .293
Cooling System Tips .....................306
Hitches ............................. .297
Minimum Requirements ..................299
Tips................................ .305
Trailer And Tongue Weight ................298 Wiring
.............................. .302
Trailer Towing Guide ...................... .298
Trailer Weight ........................... .298
Transaxle Automatic ......................... .12, 223
Transmission ........................... .228
Automatic ..................... .226, 228, 375
Maintenance .......................... .375
Transmitter Battery Service (Remote Keyless Entry) . .19
Transporting Pets ..........................85
Tread Wear Indicators ..................... .274
Turn Signals ............................ .173
Uconnect Voice Command ...................210
Uniform Tire Quality Grades .................415
Unleaded Gasoline ....................... .284
Untwisting Procedure, Seat Belt ................40
Vehicle Certification Label ...................291
10
INDEX 433

INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).
Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.