transmission oil Ram ProMaster City 2017 Owner's Manual

Red Telltale Indicator Lights
Engine Oil Level Warning Light
Red TelltaleLight What It Means
Engine Oil Level Warning Light
This warning light appears on the panel when the engine oil level falls below the minimum recom-
mended value. Restore the correct engine oil level or contact your authorized dealer for service.
Engine Temperature Warning Light
Red Warning
Light What It Means
Engine Temperature Warning Light
This light warns of an overheated engine condition. As engine coolant temperatures rise and the
gauge approaches
H, this indicator will illuminate and a single chime will sound after reaching a
set threshold. Further overheating will cause the temperature gauge to pass H, a continuous
chime will occur until the engine is allowed to cool or the 4 minutes duration is expired, which-
ever come first.
If the light turns on while driving, safely pull over and stop the vehicle. If the A/C system is on,
turn it off. Also, shift the transmission into NEUTRAL and idle the vehicle. If the temperature
reading does not return to normal, turn the engine off immediately and call for service. Refer to
“If Your Engine Overheats” in “What To Do In Emergencies” for further information.
130 UNDERSTANDING YOUR INSTRUMENT PANEL

Door Open Indicator Light
Red TelltaleLight What It Means
Door Open Indicator Light
This indicator will illuminate when one or more door(s) are not fully closed.
NOTE:
If the vehicle is moving and a door is opened, there will also be a single chime.
Transmission Temperature Warning Light
Red Telltale
Light What It Means
Transmission Temperature Warning Light
This light indicates that the transmission fluid temperature is running hot. This may occur with se-
vere usage. If this light turns on, safely pull over and stop the vehicle. Then, place the transmission
into NEUTRAL and run the engine at idle speed or apply light foot pressure to increase the engine
speed RPM until the Transmission Temperature light turns off.
WARNING!
If you continue operating the vehicle when the Trans-
mission Temperature Warning Light is illuminated you
could cause the fluid to boil over, come in contact with
hot engine or exhaust components and cause a fire.
CAUTION!
Continuous driving with the Transmission Tempera-
ture Warning Light illuminated will eventually cause
severe transmission damage or transmission failure.
134 UNDERSTANDING YOUR INSTRUMENT PANEL

STARTING PROCEDURES
Before starting your vehicle, adjust your seat, adjust both
inside and outside mirrors, and fasten your seat belts.
WARNING!
•Never leave children alone in a vehicle, or with
access to an unlocked vehicle.
• Allowing children to be in a vehicle unattended is
dangerous for a number of reasons. A child or others
could be seriously or fatally injured. Children
should be warned not to touch the parking brake,
brake pedal or the transmission gear selector.
• Do not leave the key fob in or near the vehicle (or in
a location accessible to children). A child could
operate power windows, other controls, or move the
vehicle.
Automatic Transmission
The gear selector must be in the PARK or NEUTRAL
position before you can start the engine. Apply the brakes
before shifting to any driving gear.
NOTE: You must press the brake pedal before shifting out
of PARK.
Normal Starting
NOTE: Normal starting of either a cold or a warm engine
is obtained without pumping or pressing the accelerator
pedal.
Turn the ignition switch to the AVV/ACC (START) posi-
tion and release it when the engine starts. If the engine fails
to start within 10 seconds, turn the ignition switch to the
STOP (OFF/LOCK) position, wait 10 to 15 seconds, then
repeat the “Normal Starting” procedure.
Extreme Cold Weather (Below –20°F Or 29°C)
To ensure reliable starting at these temperatures, use of an
externally powered electric engine block heater (available
from your authorized dealer) is recommended.
To prevent possible engine damage while starting at low
temperatures, this vehicle will inhibit engine cranking
when the ambient temperature is less than -31°F (-35° C)
and the oil temperature sensor reading indicates an engine
block heater has not been used. The message “plug in
engine heater” will be displayed in the instrument cluster
when the ambient temperature is below -25°F (-32° C) at
the time the engine is shut off as a reminder.
178 STARTING AND OPERATING

MAINTAINING YOUR VEHICLE
CONTENTS
ENGINE COMPARTMENT — 2.4L ...........275
 ONBOARD DIAGNOSTIC SYSTEM — OBD II . . .276
▫ Onboard Diagnostic System (OBD II)
Cybersecurity ........................ .276
▫ Loose Fuel Filler Cap Message .............277
 EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS .......................... .277
 REPLACEMENT PARTS ...................278
 DEALER SERVICE ...................... .278
 MAINTENANCE PROCEDURES .............279
▫ Engine Oil .......................... .279
▫ Engine Oil Filter ...................... .282
▫ Engine Air Cleaner Filter .................282
▫ Maintenance-Free Battery .................282
▫ Air Conditioner Maintenance ..............283▫
Body Lubrication ..................... .285
▫ Windshield Wiper Blades .................285
▫ Adding Washer Fluid ...................286
▫ Exhaust System ....................... .286
▫ Cooling System ....................... .288
▫ Brake System ........................ .293
▫ Power Steering Fluid ....................294
▫ Automatic Transmission ..................294
▫ Appearance Care And Protection From
Corrosion ........................... .296
 FUSES ............................... .300
▫ Underhood Fuses ...................... .301
▫ Interior Fuses ......................... .303
▫ Central
Unit Fuse Panel ..................306
7

WARNING!
You can be badly injured working on or around a
motor vehicle. Only do service work for which you
have the knowledge and the proper equipment. If you
have any doubt about your ability to perform a service
job, take your vehicle to a competent mechanic.
MAINTENANCE PROCEDURES
The pages that follow contain therequiredmaintenance
services determined by the engineers who designed your
vehicle.
Besides those maintenance items specified in the fixed
“Maintenance Schedule”, there are other components
which may require servicing or replacement in the future.
CAUTION!
• Failure to properly maintain your vehicle or perform
repairs and service when necessary could result in
more costly repairs, damage to other components or
negatively impact vehicle performance. Immediately
(Continued)
CAUTION! (Continued)
have potential malfunctions examined by an autho-
rized dealer or qualified repair center.
• Your vehicle has been built with improved fluids
that protect the performance and durability of your
vehicle and also allow extended maintenance inter-
vals. Do not use chemical flushes in these compo-
nents as the chemicals can damage your engine,
transmission or air conditioning. Such damage is not
covered by the New Vehicle Limited Warranty. If a
flush is needed because of component malfunction,
use only the specified fluid for the flushing proce-
dure.
Engine Oil
Checking Oil Level
To assure proper engine lubrication, the engine oil must be
maintained at the correct level. Check the oil level at
regular intervals, such as every month. The best time to
check the engine oil level is about five minutes after a fully
warmed up engine is shut off.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings.
7
MAINTAINING YOUR VEHICLE 279

WARNING!(Continued)
•Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing the
brake fluid to catch fire. Brake fluid can also damage
painted and vinyl surfaces, care should be taken to
avoid its contact with these surfaces.
• Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Power Steering Fluid
Check the fluid level with the vehicle on flat ground and
engine cold. Fluid should be between MIN and MAX
references on the reservoir body.
The level may go over the MAX line when oil is hot.
If topping off is required, make sure the oil you use is
approved. Refer to “Fluids, Lubricants and Genuine Parts”
in the section for further information.
WARNING!
Because it is flammable, do not allow the power
steering fluid to come into contact with hot engine
parts
NOTE: Power steering fluid consumption is very low. If
you need to top off your fluid often and multiple times
have your system inspected by your authorized dealer.
Automatic Transmission
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
only the manufacturer’s specified transmission fluid. Refer
to “Fluids, Lubricants, And Genuine Parts” in this section
for fluid specifications. It is important to maintain the
transmission fluid at the correct level using the recom-
mended fluid.
NOTE: No chemical flushes should be used in any trans-
mission; only the approved lubricant should be used.
294 MAINTAINING YOUR VEHICLE

Brake Assist System........................ .195
Brake Fluid .............................. .316
Brake, Parking ............................ .192
Brake System ......................... .194, 293
Anti-Lock (ABS) ........................ .194
Fluid Check ........................ .293, 316
Master Cylinder ........................ .293
Parking .............................. .192
Warning Light .......................... .135
Brake/Transmission Interlock ..................182
Bulb Replacement ...................... .307, 308
Bulbs, Light ........................... .71, 307
Camera, Rear ............................ .103
Capacities, Fluid .......................... .313
Caps, Filler Fuel ................................. .229
Oil (Engine) ........................ .275, 281
Power Steering ......................... .191
Radiator (Coolant Pressure) .................291
Carbon Monoxide Warning .................68, 229
Cargo Tie-Downs .......................... .109
Car Washes .............................. .296
Cellular Phone ........................... .160
Certification Label ......................... .230Chains, Tire
............................. .219
Chart, Tire Sizing .......................... .202
Check Engine Light (Malfunction Indicator Light). . . .277
Checking Your Vehicle For Safety ................67
Checks, Safety .............................67
Child Restraint .............................48
Child Restraints Booster Seats ............................52
Child Restraints ..........................48
Child Seat Installation ......................61
How To Stow An Unused ALR Seat Belt .........58
Infants And Child Restraints .................50
Locating The LATCH Anchorages ..............56
Lower Anchors And Tethers For Children ........54
Older Children And Child Restraints ...........51
Seating Positions ..........................
53
Cigar Lighter ............................ .106
Clean Air Gasoline ........................ .226
Cleaning Wheels ............................... .297
Climate Control ........................... .161
Manual ............................... .161
Cold Weather Operation ..................... .178
Compact Spare Tire ........................ .214
Contract, Service .......................... .32610
INDEX 331

Automatic Transmission....................178
Cold Weather .......................... .178
Engine Fails To Start ..................... .179
Steering Power ............................... .191
Tilt Column .............................95
Wheel, Tilt ..............................95
Steering Wheel Audio Controls .................159
Steering Wheel Mounted Sound System Controls . . . .159
Storage ................................. .307
Storage, Vehicle ....................... .166, 307
Storing Your Vehicle ....................... .307
Supplemental Restraint System - Air Bag ...........38
Synthetic Engine Oil ....................... .281
Telescoping Steering Column ...................95
Tie Down Hooks, Cargo ..................... .109
Tilt Steering Column .........................95
Tire And Loading Information Placard ........206, 207
Tire Markings ............................ .200
Tires.......................... .71, 209, 214, 220
Aging (Life Of Tires) ..................... .218
Air Pressure ........................... .209
Chains ............................... .219
Compact Spare ......................... .214General Information
...................209, 214
High Speed .............................211
Inflation Pressures ........................211
Life Of Tires ........................... .218
Load Capacity ...................... .206, 207
Pressure Monitor System (TPMS) .............222
Pressure Warning Light ....................139
Quality Grading ........................ .220
Radial ............................... .212
Replacement ........................... .218
Rotation .............................. .220
Safety ............................ .200, 209
Sizes ................................ .202
Snow Tires ............................ .213
Spar

e Tire ......................... .214, 216
Spinning .............................. .216
Trailer Towing .......................... .237
Tread Wear Indicators .....................217
Tire Safety Information ...................... .200
Tire Service Kit ........................... .247
Tongue Weight/Trailer Weight .................235
Towing ................................. .232
Disabled Vehicle ........................ .268
Guide ................................ .235
Recreational ........................... .241
10
INDEX 339

Weight............................... .235
Towing Vehicle Behind A Motorhome ............241
Traction ................................ .189
Traction Control .......................... .196
Trailer Towing ............................ .232
Cooling System Tips ..................... .241
Hitches ............................... .234
Minimum Requirements ....................236
Tips ................................. .240
Trailer And Tongue Weight ..................235
Wiring ............................... .238
Trailer Towing Guide ....................... .235
Trailer Weight ............................ .235
Transaxle Automatic ...........................11,178
Transmission ............................. .182
Automatic ...................... .181, 182, 294
Maintenance ........................... .294
Transporting Pets ...........................66
Tread Wear Indicators ...................... .217
Turn Signals ............................. .144
Uconnect Voice Command ....................169
Uniform Tire Quality Grades ..................220
Unleaded Gasoline ........................ .226Untwisting Procedure, Seat Belt
.................32
Vehicle Certification Label ....................230
Vehicle Identification Number (VIN) ...............6
Vehicle Loading .....................207, 230, 232
Vehicle Modifications/Alterations .................7
Vehicle Storage ........................ .166, 307
Viscosity, Engine Oil ....................... .281
Voice Recognition System (VR) .................169
Warnings And Cautions .......................6
Warranty Information ...................... .327
Washers, Windshield ..................... .93, 286
Washing Vehicle .......................... .296
Water Driving Through ........................ .189
Wheel

And Wheel Trim ..................... .297
Wheel And Wheel Trim Care ..................297
Wind Buffeting .............................23
Window Fogging .......................... .167
Windows .................................21
Power .................................21
Windshield Defroster .........................69
Windshield Washers ..................... .93, 286
Fluid ................................ .286
340 INDEX