service RENAULT ESPACE 2012 J81 / 4.G User Guide

maintenance:mechanical ...................................... (up to the end of the DU)
engine oil .............................................. (up to the end of the DU)
dipstick.................................................. (up to the end of the DU)
levels .................................................... (up to the end of the DU)
4.6
ENG_UD25551_2
Niveau huile moteur : appoint/remplissage (X81 - J81 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
Jaune NoirNoir texte
topping up/filling
The vehicle must be parked on level
ground and the engine should be cold
(for instance, before the engine is
started up for the first time in the day).
engine oil grade
Refer to the Maintenance Service
Booklet for your vehicle.
enGIne oIL LeVeL: topping up/filling (1/2)
1
Do not exceed the max level and
do not forget to refit cap 1 and dip-
stick 2.
– Unscrew cap 1;
– top up the level (as a guide, the ca-
pacity between the minimum and
maximum reading on the dipstick 2
is between 1.5 and 2 litres, depend-
ing on the engine);
– wait for approximately 10 minutes to
allow the oil to flow into the engine;
– check the level using dipstick 2 or
the dipstick integrated in cap 1 (as
explained previously).
Once the operation has been com -
pleted, ensure that the dipstick is
pushed in as far as it will go or that the
cap-type dipstick is completely screwed
in.
1
2

engine oil capacity ................................................. (current page)
filter oil filter ............................................................. (current page)
oil change .............................................................. (current page)
JauneNoirNoir texte
4.7
ENG_UD25551_2
Niveau huile moteur : appoint/remplissage (X81 - J81 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
oil change
Service intervals: please refer to your
vehicle’s maintenance document.
Average capacities for oil change oil
filter included.
(for information)
2.0 t engine : 5.40 litres
engine 2.0 dCi : 8.20 litres
engine oil grade
Refer to the Maintenance Service
Booklet for your vehicle.
enGIne oIL LeVeL: topping up/filling (2/2)
engine oil change: if you
are changing the oil when
the engine is hot, be careful
not to scald yourself if the
oil overflows.
Filling: take care when
topping up the oil that
no oil drips onto engine
components - risk of fire.
Remember to refit the cap securely
as there is a risk of fire if oil splashes
onto hot engine components.
Never run the engine in an
enclosed space as exhaust
gases are poisonous.
Consult your approved Dealer at
once if you notice an abnormal or
repeated drop in any of the fluid
levels.
The engine may be hot
when carrying out opera -
tions in close proximity. In
addition, the engine cooling
fan can come on at any moment.
Risk of injury.

maintenance:mechanical ...................................... (up to the end of the DU)
filter oil filter ............................................................. (current page)
coolant ................................................................... (current page)
levels .................................................... (up to the end of the DU)
tanks and reservoirs coolant ............................................................. (current page)
levels: coolant ............................................................. (current page)
4.8
ENG_UD24345_4
Niveaux/Filtres (X81 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
Jaune NoirNoir texte
Levels
coolant
LeVeLS (1/4)
Coolant
With the engine switched off and on
level ground, the level when cold must
be between the MINI and MAXI marks
on reservoir 1.
Top this level up when cold before it
reaches the MINI mark. Checking intervals
Check the coolant level regularly
(very severe damage is likely to be
caused to the engine if it runs out of
coolant).
If the level needs to be topped up, only
use products approved by our Technical
Department which ensure:
–
protection against freezing;
– anticorrosion protection of the cool -
ing system.
No operations should be
carried out on the cooling
circuit when the engine is
hot.
Risk of burns.
1
Consult your approved Dealer at
once if you notice an abnormal or
repeated drop in any of the fluid
levels.
Replacement intervals
Refer to the Maintenance Service
Booklet for your vehicle.

power-assisted steering......................................... (current page)
power-assisted steering pump ...............................(current page)
JauneNoirNoir texte
4.9
ENG_UD24345_4
Niveaux/Filtres (X81 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
power-assisted steering pump
LeVeLS (2/4)
Power-assisted steering
pump 2
Checking intervals:
Refer to the Maintenance Service
Booklet for your vehicle.
Level
With the engine switched off and cold,
and on level ground, the level must be
visible between the MInI and MAXI
levels on reservoir 2.
For topping up or refilling with oil, use
products approved by our Technical
Department.
The engine may be hot
during operations in close
proximity. In addition, the
engine cooling fan may
come on at any moment.
Risk of injury.
2

brake fluid .............................................................. (current page)
tanks and reservoirs brake fluid ........................................................ (current page)
levels: brake fluid ........................................................ (current page)
4.10
ENG_UD24345_4
Niveaux/Filtres (X81 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
Jaune NoirNoir texte
brake fluid
LeVeLS (3/4)
3
Brake fluid
This should be checked frequently,
and immediately if you notice even the
slightest loss in braking efficiency.
Top up with the engine switched off and
on level ground.
Level 3
It is normal for the level to drop as the
brake shoes become worn, but it must
never drop lower than the “MInI” warn-
ing line.
If you wish to check the disc and drum
wear yourself, you should obtain the
document explaining the checking pro-
cedure from our network or from the
manufacturer’s website.Filling
After any operation on the hydraulic cir-
cuit, a specialist must replace the fluid.
Only use fluids approved by our
Technical Department (and taken from
a sealed container).
Replacement intervals
Refer to the Maintenance Service
Booklet for your vehicle.
Consult your approved Dealer at
once if you notice an abnormal or
repeated drop in any of the fluid
levels.
The engine may be hot
during operations in close
proximity. In addition, the
engine cooling fan may
come on at any moment.
Risk of injury.

filterair filter ............................................................. (current page)
tanks and reservoirs: windscreen washer .......................................... (current page)
filter ........................................................................\
(current page)
filter oil filter ............................................................. (current page)
filter passenger compartment filter .......................... (current page)
JauneNoirNoir texte
4.11
ENG_UD24345_4
Niveaux/Filtres (X81 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
windscreen/headlight washer reservoir
Filters
LeVeLS (4/4)/FIL teRS
Windscreen/headlight washer
reservoir
Filling
Through cap 4.
Fluid
Water + special windscreen washer
fluid (antifreeze product in winter).
Jets
Use a flat-blade screwdriver to position
the windscreen washer jets.
Filters
The replacement of filter elements (air
filter, passenger compartment filter,
diesel filter, etc.) is scheduled in the
maintenance operations for your vehi -
cle.
Replacement intervals for filter el -
ements: refer to the Maintenance
Service Booklet for your vehicle.
4
The engine may be hot
during operations in close
proximity. In addition, the
engine cooling fan may
come on at any moment.
Risk of injury.

battery.................................................................... (current page)
maintenance: mechanical ...................................... (up to the end of the DU)
4.13
ENG_UD11564_2
Batterie (X81 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
Battery
BA tteR y
It does not need to be serviced: never
open battery cover 1.Access to the battery
Depending on the vehicle, remove
cover A by turning screw 2 a quarter
of a turn using the vehicle’s emergency
key or a coin.
Replacing the battery
As this operation is complex, we advise
you to contact an approved Dealer.
Refer to the information on the Battery:
repair in Section 5.
1
2A
2
Handle the battery with care
as it contains sulphuric acid,
which must not come into
contact with eyes or skin. If
it does, wash the affected area with
plenty of cold water. If necessary,
consult a doctor.
Ensure that naked flames, red hot
objects and sparks do not come into
contact with the battery as there is a
risk of explosion.
Label B
Observe the indications on the battery:
– 3 naked flames and smoking forbid-
den;
– 4 eye protection required;
– 5 keep away from children;
– 6 explosive materials;
– 7 refer to the handbook;
– 8 corrosive materials.
2
The battery is a specific
type , please ensure it is
replaced with the same
type. Consult an approved
dealer.
B345
678

JauneNoirNoir texte
4.15
ENG_UD25392_1
Entretien de la carrosserie (X95 - J95 - R95 - Renault)
ENG_NU_932-3_X81ph3_Renault_4
– bird droppings , which cause a
chemical reaction with the paint that
rapidly discolours paintwork and
may even cause the paint to peel
off;
Wash the vehicle immediately to
remove these marks since it is im -
possible to remove them by polish -
ing;
– salt, particularly in the wheel arches
and underneath the body after driv -
ing in areas where the roads have
been gritted.
Using a roller type car wash
Return the windscreen wiper stalk to
the Park position (refer to the informa-
tion on the “Windscreen washer, wiper”
in Section 1). Check the mounting of
external accessories, additional lights
and mirrors, and ensure that the wiper
blades are secured with adhesive tape.
Remove the radio aerial mast if your
vehicle is fitted with this equipment.
Remember to remove the tape and refit
the antenna after washing.y ou should
Observe the vehicle stopping distances
when driving on gravelled surfaces to
prevent paint damage.
Repair, or have repaired quickly, areas
where the paint has been damaged, to
prevent corrosion spreading.
Remember to visit the body shop pe -
riodically in order to maintain your
anti-corrosion warranty. Refer to the
Maintenance Service Booklet.
Respect local regulations about wash -
ing vehicles (e.g. do not wash your ve-
hicle on a public highway).
Wash your car frequently, with the
engine off, with cleaning products rec-
ommended by the manufacturer (never
use abrasive products). Rinse thor -
oughly beforehand with a jet:
– spots of tree resin and industrial
grime;
– mud in the wheel arches and under -
neath the body which forms damp
patches;
BoDyWoRk MAIntenAnCe (2/2)
If it is necessary to clean mechani -
cal components, hinges, etc., spray
them with products approved by our
Technical Department to protect them
after they have been cleaned.
Cleaning the headlights
As the headlights are made of plastic
“glass”, use a soft cloth or cotton wool
to clean them. If this does not clean
them properly, moisten the cloth with
soapy water, then wipe clean with a soft
damp cloth or cotton wool.
Finally, carefully dry off with a soft dry
cloth.
Cleaning products containing alco -
hol must not be used.
We have selected special products
to care for your vehicle and you can
obtain these from the manufactur -
er’s accessory outlets.

tyre inflation kit...................................... (up to the end of the DU)
5.4
ENG_UD24347_2
Add J81 kit de gonflage (X81 - J81 - Renault)
ENG_NU_932-3_X81ph3_Renault_5
Jaune NoirNoir texte
Tyre inflation kit
tYre InFLA tIOn KIt
Do not attempt to use the
inflation kit if the tyre has
been damaged as a result
of driving with a puncture.
You should therefore carefully check
the condition of the tyre sidewalls
before any operation.
Driving with underinflated, flat or
punctured tyres can be dangerous
and may make the tyre impossible
to repair.
this repair is temporary
A tyre which has been punctured
should always be inspected (and re-
paired, where possible) as soon as
possible by a specialist.
Contact an approved dealer to re -
place the inflation tube and repair
product bottle.
When taking a tyre which has been
repaired using this kit to be replaced,
you must inform the specialist.When driving, vibration may
be felt due to the presence
of the repair product in -
jected into the tyre.
The kit is only approved for inflat -
ing the tyres of the vehicle originally
equipped with the kit.
It must never be used to inflate
the tyres of another vehicle, or any
other inflatable object (rubber ring,
rubber boat, etc.).
Avoid spillage on skin when hand -
ling the repair liquid bottle. If drop -
lets do leak out, rinse them off with
plenty of water.
Keep the repair kit away from chil -
dren.
Do not dispose of the empty bottle
in the countryside. Return it to an
approved dealer or to a recycling or-
ganisation.
The bottle has a limited service
life which is indicated on its label.
Check the expiry date regularly.
The kit repairs tyres with
tread A damaged by ob -
jects smaller than 4 mm. It
cannot repair all types of
puncture, such as cuts more than
4 mm, or cuts in the tyre sidewall B
etc.
Ensure also that the wheel rim is in
good condition.
Do not pull out the foreign body
causing the puncture if it is still in
the tyre.
A
B

practical advice ...................................................... (current page)
RENAULT card battery ............................................. (up to the end of the DU)
5.28
ENG_UD20428_1
Cartes RENAULT : piles (X81 - J81 - Renault)
ENG_NU_932-3_X81ph3_Renault_5
RENAULT card: battery
renAuL t cArD: battery
replacing the battery
Pull firmly on emergency key 1.
Replace battery 2 in accordance with
the polarity denoted on the emergency
key (check that indicator light 3 lights
up properly by pressing a button on the
RENAULT card).
1
2
3
Do not throw away your
used batteries; give them to
an organisation responsible
for collecting and recycling
batteries.
The batteries are available from ap-
proved dealers. Their service life is
approximately two years. Check that
there is no dye on the battery: risk of
an incorrect electrical contact.