warning light RENAULT KANGOO VAN ZERO EMISSION 2012 X61 / 2.G Service Manual

3.6
Adjusting the ventilation
speed
Normal use
Turn control 3 to one of the four posi-
tions to start the ventilation system and
adjust the power.
Select position 1 for minimum ventila-
tion and position 4 for maximum ven-
tilation.
Position 0
In this position:
– the air conditioning or heating stops automatically even if button 6 is acti-
vated and the warning light remains
lit;
– the ventilation speed of air in the passenger compartment is zero;
– there is, however, a slight flow of air when the vehicle is moving.
This position should not normally be
used.
HEATING, AIR-CONDITIONING (3/3)
Air recirculation (isolation of
the passenger compartment)
Turn control 1 towards the air recircula-
tion symbol
K.
In these conditions air is taken from the
passenger compartment and is recircu-
lated, with no air being taken from out-
side the vehicle.
Air recirculation operates as
follows:
– isolating the passenger compart- ment from the outside air (driving in
polluted areas, unpleasant odours,
etc.);
– bringing the passenger compartment to the desired temperature as quickly
as possible.
Prolonged use of this position can
lead to condensation forming on the
side windows and windscreen and
problems due to the use of non-re-
newed air in the passenger com-
partment.
We therefore advise you to return to
normal mode (external air) as soon
as the air recirculation function is no
longer required, by turning control 1
again.
3
6
1

3.9
Conditions of use
– The engine must be running;
– switch 4 must be engaged;
– the ventilation control 2 should not
be at position 0;
– the temperature control 1 should not
be at the ”Stop heating” position 3.
– The fuel level should not be at mini- mum.
ADDITIONAL HEATING (1/2)
Depending on the vehicle, the addi-
tional heating is designed to heat the
passenger compartment. Powered
by a dedicated fuel tank (please see
“Additional heating tank” in Section 1),
this increases the comfort level without
reducing vehicle range.
Switching on this additional heating de-
activates other heating methods and
the air-conditioning.
2
When the fuel reaches the minimum
level, a warning light will come on
on the instrument panel. After a few
minutes of operation, a message on
the instrument panel will tell you that
the additional heating is switched
off.
3
1
4

4.5
Windscreen washer reservoir
Topping up
– Open cap 4;
– fill until you can see the fluid;
– close the cap.
Liquid
Screen wash product (product with
antifreeze in winter).
Jets
To adjust the height of the windscreen
washer jets, use a tool such as a flatb-
lade screwdriver.
4
Level 3
It is normal for the level to drop as
the linings become worn, but it should
never drop below the “ MINI” warning
line.
If you wish to check the disc and drum
wear yourself, you should obtain the
document explaining the checking pro-
cedure from our network or from the
manufacturer’s website.
Topping up
After any operation on the hydraulic cir-
cuit, a specialist must replace the fluid.
Only use fluids approved by our
Technical Department (and taken from
a sealed container).
Replacement intervals
Refer to the Maintenance Document for
your vehicle.
Consult your approved dealer at
once if you notice an abnormal or
repeated drop in any of the fluid
levels.
Brake fluid level
This should be checked frequently,
and immediately if you notice even the
slightest loss in braking efficiency.
The level should be read with the engine
switched off and on level ground.
3
LEVELS (2/2)

5.4
TYRE INFLATION KIT (2/3)
Depending on the vehicle, in the event
of a puncture, please use the kit located
in the glovebox.
Before using this kit, park
the vehicle at a sufficient
distance from traffic, switch
on the hazard warning
lights, apply the handbrake, ask all
passengers to leave the vehicle and
keep them away from traffic.
If the vehicle is parked on
the hard shoulder, you must
warn other road users of
your vehicle’s presence
with a warning triangle or with other
devices as per the legislation apply-
ing to the country you are in.
With the engine running and the
parking brake applied,
– unroll the hose from the container;
– connect the compressor hose 3 to
the container’s inlet 8;
– depending on the vehicle, connect the container 8 to the compressor
from the container recess 7;
– unscrew the valve cap on the rel- evant wheel and screw on the con-
tainer’s inflation adapter 1;
– adapter 2 must be connected to the
vehicle accessories socket;
– press switch 4 to inflate the tyre to
the recommended pressure (please
refer to the information in the section
on “Tyre pressure”);
45
18
– after a maximum of 15 minutes, stop inflating and read the pressure (on
pressure gauge 5).
Note: while the container is empty-
ing (approximately 30 seconds), the
pressure gauge 5 will briefly indicate
a pressure of up to 6 bar. The pres-
sure will then drop.
– adjust the pressure: to increase it, continue inflation with the kit; to
reduce it, press button 6.
If a minimum pressure of 1.8 bar is
not reached after 15 minutes, repair
is not possible; do not drive the ve-
hicle but contact an approved dealer.
2
3
7
6

5.8
2
4
1
3
If necessary, remove the wheel trim.
Use the wheelbrace 2 to slacken off the
wheel bolts. Position it so as to be able
to push from above.
Start extending jack 4 by hand, turning
the handle.
You must put the jack head on the jack-
ing point 1 nearest the affected wheel
and, depending on the vehicle, the
place marked with a triangle.
Switch on the hazard warn-
ing lights.
Keep the vehicle away from
traffic and on a level surface
where it will not slip.
Apply the handbrake and engage
position P.
Ask all the passengers to leave the
vehicle and keep them away from
traffic.
CHANGING A WHEEL (1/2)
Continue tightening to position the
baseplate on the ground correctly. Turn
handle 3 on the jack to lift the wheel off
the ground.
To prevent any risk of injury
or damage to the vehi-
cle, raise the jack until the
wheel you are replacing is
a maximum of 3 centimetres off the
ground.
If the vehicle is parked on
the hard shoulder, you must
warn other road users of
your vehicle’s presence
with a warning triangle or with other
devices as per the legislation apply-
ing to the country you are in.

5.25
FUSES (2/2)
Number Allocation
1 Traction battery charger
2 Electric motor control unit
3 Air conditioning, pedestrian
horn
4 heating, brake lights,
traction battery
5 Rear windscreen wiper
6 Horn, diagnostic socket
7 Heated seats
8 Traction battery
9 Passenger compartment
ECU
10 Windscreen washer
11 Brake lights
12 Passenger compartment
unit, ABS, ESP
13 Electric windows, child
safety, heating and air
conditioning system, ECO
mode
14 Not used
15 Starter
12
3456
78910
11121314
15161718
19202122
23242526
27
28
29
Allocation of fusesThe presence of certain fuses de-
pends on the vehicle equipment
level.
Number Allocation
16 Brake lights, additional
equipment, navigation, ABS,
ESP, boot light, interior
lights, rain and light sensor,
charging warning light
17 Radio, navigation system,
display, alarm
18 Additional equipment
19 Heated door mirrors
20 Hazard lights, rear fog lights
21 Central locking of opening
elements
22 Instrument panel
23 Not used
24 ESP, radio, heating and air
conditioning system, heated
seats, stop lights
25 Front accessories socket
26 Towbar
27 Electric front windows
28 Rear-view mirror control
29 Engine cooling fan

5.29
Bring lever to position N.
TOWING, BREAKDOWN (2/3)
In the event of an energy
fault: towing
In the event of a fully discharged trac-
tion battery:
– the warning light
 flashes;
– needle 1 is in the lower section of the
reserve zone.
It is possible to recover on a flatbed
truck or tow the vehicle using the tow
eye, following the instructions below.
When the engine is
stopped, steering and brak-
ing assistance are not op-
erational.
Before towing, insert the key in the
switch to unlock the steering column.
Turn it to position M.
The column is unlocked, the acces-
sory functions are supplied: the vehi-
cle lights can be used (hazard warn-
ing lights, brake lights etc.). The towed
vehicle’s lights must be switched on at
night.
The speed specified by current legis-
lation for towing must always be ob-
served.
4
1
2
If the lever is stuck in P ,
even though you are de-
pressing the brake pedal,
the lever can be released
manually.
To do this, unclip the cover at the
base of the lever.
Press simultaneously on mark 2 and
on the unlocking button on the lever.

7.2
ALPHABETICAL INDEX (2/5)
driving positionsettings ............................................................1.3\
4 → 1.37
E
»ECO» mode function .................................................. 2.5, 2.9
ECO driving ........................................................................\
. 2.9
»400 volt» electrical circuit ........................................1.2 → 1.7
electric vehicle vehicle range ................................................................. 2.5
batteries ..............................................................\
........... 1.4
noise ..................................................................\
............ 1.6
charge ................................................................1.8 → 1.14
driving .............................................................. 1.6, 2.3, 2.5
»ECO» mode ................................................................. 2.9
important recommendations ................................. 1.7, 1.11
electric windows ..................................................... 3.15 – 3.16
electrical installation .......................................................... 1.11
electronic stability control: ESC .............................2.10 → 2.12
emergency brake assist.........................................2.10 → 2.12
emergency braking ................................................2.10 → 2.12
emergency spare wheel ...................................................... 5.2
energy recovery ...............................................................\
. 1.66, 2.8
»ECO» mode ................................................................. 2.9
saving ................................................................... 2.5 – 2.6
charge meter (function) .................................................. 2.8
consumption .............................................. 1.65 – 1.66, 2.8
charge ................................................................1.8 → 1.14
range ..................................................................\
............ 2.8
energy saving ............................................................. 2.5 – 2.6
energy consumption ............................................ 2.5 – 2.6, 2.8
energy recovery ................................................................... 2.8
engine specifications ........................................................... 6.3
environment ............................................................\
............. 2.7
ESC: electronic stability control .............................2.10 → 2.12
external temperature ......................................................... 1.77 F
faults
operating faults ................................................5.34 → 5.37
fitting a radio ...................................................................... 5.31
fittings ...............................................................\
.....3.18 → 3.20
fog lights ................................................................... 1.82, 5.15
front lights changing bulbs .................................................. 5.13 – 5.14
front passenger air bag deactivation .....................1.54 → 1.56
front seat adjustment .............................................. 1.29 – 1.30
front seats adjustment ........................................................ 1.29 – 1.30
fuel capacity ...............................................................\
......... 1.88
filling ................................................................\
............. 1.88
grade ..................................................................\
.......... 1.88
fuel filler cap ...................................................................... 1.88
fuses ....................................................................... 5.24 – 5.25
G
gear lever..............................................................\
...... 2.3 – 2.4
glove box ........................................................................\
... 3.18
H
handbrake...............................................................\
............. 2.4
hazard warning lights signal .............................................. 1.78
headlight beam adjustment .................................... 1.83 – 1.84
headrest........................................................1.26 → 1.28, 3.23
heated seats ........................................................... 1.29 – 1.30
heating and air conditioning system .................................. 3.11
heating, air conditioning: programming ............... 2.6, 3.7 – 3.8
heating system ........................................................ 3.4 → 3.11
horn ...................................................................\
................ 1.78
horn: flash ..................................................................\
........... 1.78
sounding the horn ........................................................ 1.78

7.3
ALPHABETICAL INDEX (3/5)
hubcap tool ........................................................................\
.. 5.6
I
indicators ......................................................... 1.78, 5.14, 5.19
indicators:direction indicators .............................................. 5.14, 5.19
instrument panel ..............................................1.62 → 1.67
instrument panel ....................................................1.62 → 1.76
instrument panel messages...................................1.68 → 1.76
interior lighting: changing bulbs .................................................. 5.20 – 5.21
interior trim maintenance ..................................................... 4.11 – 4.12
Isofix .................................................................\
.....1.47 → 1.53
J
jack ...................................................................\
............ 5.6, 5.8
L
levels: brake fluid ...................................................................... 4.5
coolant ................................................................\
........... 4.4
windscreen washer reservoir ......................................... 4.5
lifting the vehicle changing a wheel .................................................. 5.8 – 5.9
lighting: interior ............................................................... 3.12 – 3.13
lights adjustment ........................................................ 1.83 – 1.84
changing bulbs .................................................. 5.13 – 5.14
fog lights ...................................................................... 5.15
front ................................................................... 5.13 – 5.14
lights: brake lights .................................................................. 5.16
dipped beam headlights ............................. 1.62, 1.80, 5.13
direction indicators ..................................... 1.62, 1.78, 5.16 fog lights .................................................... 1.62, 1.82, 5.15
hazard warning ............................................................ 1.78
main beam headlights .............................. 1.62, 1.80 – 1.81
number plate lights ...................................................... 5.18
reversing lights ............................................................. 5.16
side lights ..................................................................... 1.80
lights-on warning buzzer........................................... 1.18, 1.81
locking the doors .................................................... 1.23 – 1.24
luggage retaining net ......................................................... 3.26
M
maintenance: bodywork ............................................................ 4.9 – 4.10
interior trim ........................................................ 4.11 – 4.12
mechanical .........................................4.2 – 4.3, 6.8 → 6.13
map reading lights .................................................. 3.12 – 3.13
methods of restraint in addition to the front seat belts ..............
1.38 → 1.40
methods of restraint in addition to the seat belts ...1.38 → 1.42
multimedia (equipment) ..................................................... 3.27
multimedia equipment .............................................. 3.27, 5.31
N
navigation .............................................................\
............. 3.27
navigation system .............................................................. 3.27
O
opening the doors ..................................................1.18 → 1.22
operating faults ................................ 1.62 → 1.64, 5.34 → 5.37
P
paintwork maintenance ....................................................... 4.9 – 4.10
reference ..............................................................\
.......... 6.2
parking distance control.......................................... 2.20 – 2.21
partition ..............................................................\
................ 1.33

7.4
ALPHABETICAL INDEX (4/5)
pedestrian warning system ................................................ 1.79
power-assisted steering.................................................\
.... 1.43
practical advice ........................................................... 2.5 – 2.6
presentation of the electric vehiclebatteries ..............................................................\
.1.2 → 1.6
pretensioners ..........................................................\
........... 1.38
puncture................................................................\
........ 5.6, 5.8
R
radio...................................................................\
....... 3.27, 5.31
radio frequency remote control/key use ....................................................................\
.. 1.15, 1.17
rear bench seat....................................................... 3.21 – 3.22
rear lights changing bulbs .................................................5.16 → 5.18
rear screen demisting ..............................................................\
......... 3.2
rear seats functions ........................................................... 3.21 – 3.22
rear view mirrors ................................................................ 1.57
remote control door locking batteries ..............................................................\
......... 5.33
remote control electric door locking .......................... 1.15, 1.17
RENAULT ANTI-INTRUDER DEVICE (RAID) ................... 1.25
replacement parts ................................................................ 6.7
reverse gear selecting ................................................................ 2.3 – 2.4
reversing sensor ..................................................... 2.20 – 2.21
S
seat belts ...............................................................1.34 → 1.42
see-me-home lighting ........................................................ 1.81
service sheets..........................................................\
6.8 → 6.13
side indicator lights changing bulbs ............................................................. 5.19
side protection devices ...................................................... 1.41 side windows ..................................................................... 3.16
signals and lights ...................................................1.80 → 1.82
speed control .............................................................. 2.3 – 2.4
speed limiter ..........................................................2.13 → 2.15
steering wheel adjustment .............................................................\
...... 1.43
storage compartment.............................................3.18 → 3.20
storage compartments ...........................................3.18 → 3.20
sun visor ................................................................... 3.14, 3.20
T
tailgate ...............................................1.20 → 1.22, 3.24 – 3.25
tanks and reservoirs brake fluid ...................................................................... 4.5
coolant ................................................................\
........... 4.4
tanks and reservoirs: windscreen washer ........................................................ 4.5
technical specifications .......................................6.2, 6.4 → 6.7
temperature regulation ...................................................... 3.11
tool kit ........................................................................\
.......... 5.6
towing in the event of energy failure ...........................5.28 → 5.30
breakdown .......................................................5.28 → 5.30
towing equipment fitting ................................................................\
............ 3.25
towing hitch...................................................... 5.6, 5.29 – 5.30
towing rings ............................................................ 1.47 – 1.48
traction battery charge .................................................................\
........... 1.8
traction battery ....................................................1.2 → 1.7, 2.8
traction battery charge ....................................1.8 → 1.14, 1.17
traction control .......................................................2.10 → 2.12
transporting children ..........................1.44 – 1.45, 1.47 → 1.56
transporting objects in the luggage compartment ............................. 3.24 – 3.25
trims ..................................................................\
................... 5.7