headlamp SAAB 9-5 2000 User Guide

197 Car care and technical information
Relays
# Function
1 Washer, front/rear
2 Low beam headlight
3 High beam headlight
4 Extra lights (accessory)
5.1 Horn
5.2 – –
6 Wiper, rear (9-5 Wagon)
7 Radiator fan, low speed
8 Radiator fan, high speed, left fan
9 A/C-compressor
10.1 Front fog lights
10.2 Headlamp wipers
11 Windshield wipers
12 Radiator fan, high speed, right fan
13 Autochecking of headlights
ProCarManuals.com

214 Car care and technical information
Headlamp aimingThe vehicle is equipped with vertical and
horizontal aim indicators. The aim has been
preset at the factory and should normally
not need further adjustments. This is true
even though your vertical and horizontal
aim indicators may not fall exactly on the "0"
(zero) marks on their scales.
If your headlamps are damaged in an acci-
dent, the headlamp aim may be affected. If
you believe your headlamps need to be
re-aimed, we recommend that you take it to
your Saab dealer for service, however, it is
possible for you to re-aim your headlamps
as described in the following procedure.
WARNING
Before checking/adjusting the headlamp
aiming, switch off the engine to avoid
danger of fingers and hands being injured
by moving parts.
The radiator fan can start up even when
the engine is switched off.
IB526
ABS Acrylonitrile-butadiene-styrene
ASA Acrylonitrile-styrene (acrylic
plastic)
EPDM Ethylene-propylene rubber
PA Polyamide (plastic)
PC Polycarbonate (plastic)
PE Polyethylene
PMMA Polymethyl methacrylate
POM Acetal plastic
PPO Polyphenylene oxide (plastic)
PP Polypropylene
PUR Polyurethane
PVC Polyvinyl chloride 1234
5
6
7
98
10
11
12
13 14 15 16 19
18 20 21
1722
ProCarManuals.com

215 Car care and technical information
To check the aim, the vehicle should be
properly prepared as follows:
 Place the vehicle on a level pad or sur-
face.
 The vehicle should be unladen and fuel
tank full, and one person or 160 lbs.
(75 kg) on the drivers seat.
 The vehicle should not have any snow, ice
or mud attached to it.
 Tires should be inflated to the prescribed
pressure.
 Rock the vehicle to stabilize the suspen-
sion.Open the hood and locate the vertical aim
level (B) that you can see through the top of
the headlamp lens.
If you find that the headlamp needs adjust-
ment follow these steps:
1 Locate the vertical aiming device (A).
2 Turn the vertical aiming screw with a
0.24 in. (6 mm) Hexagonal Allen socket
until the bubble inside the level is cen-
tered between the two red lines (zero).3 Check the horizontal aim (1) and adjust
as necessary with a 0.24 in. (6 mm)
Hexagonal Allen socket. Turn the hori-
zontal aiming device (2) until the arrow
aligns with the zero (0) mark.
4 Recheck the vertical aim to make sure it
is still correct after the horizontal aim
adjustment. Readjust as necessary.NOTETo make sure that your headlamps are
aimed properly read all instructions
before beginning. Failure to follow these
instructions could cause damage to
headlamp parts or a not correctly aimed
headlamp.
IB1168
A
B
Vertical adjustmentA Vertical aiming device
B Vertical aim level
IB1167
1
2
Horizontal adjustment1 Horizontal aim
2 Horizontal aiming device
ProCarManuals.com

244 IndexStarting in cold weather, ACC _______ 73
Starting in hot weather, ACC ________ 73
Steering wheel adjustment ________ 107
Steering, technical data ___________ 232
Stone-chip damage, repairing ______ 210
Storage compartments ___________ 113
Sun visors _____________________ 112
Sunroof _______________________ 111
Suspension ____________________ 232
Suspension, technical data ________ 232
Switches _______________________ 61
Systems, adjustment _____________ 237TTCS OFF _______________________ 51
Table of fuses __________________ 194
Tachometer _____________________ 52
Tailgate, opening _________________ 36
Tank gauge _____________________ 53
Technical data __________________ 225
Temperature control, ACC _________ 69
Temperature gauge, engine ________ 53
Temperature zones, ACC __________ 69
Textile carpeting ________________ 208
Through-load hatch ______________ 118
Tie Downs _____________________ 118
Tightening torque, wheel studs _____ 203
Tire markings ______________ 198, 199
Tire pressure _______________ 157, 198
Tires _____________________ 198, 233
Tools _________________________ 126Touching-in the paintwork _________ 210
Towbar attachment ______________ 152
Towbar load ____________________ 153
Towing the car __________________ 158
Towing, automatics ______________ 158
Traction _______________________ 147
Trailer weights __________________ 227
Trionic ________________________ 169
Trip computer ___________________ 54
Trip meter ______________________ 52
Trunk _________________________ 116
Trunk lid, opening ________________ 36
Turbo, points to note _____________ 132
UUnder the hood, 4-cyl ____________ 167
Under the hood, 6-cyl ____________ 168
Upholstery and trim ______________ 208
Upholstery and trim, care of _______ 208
Useful tips, ACC _________________ 75VVanity mirrors __________________ 112
Ventilated front seats _____________ 105
Viscosity, engine oil ______________ 228
WWarning labels ____________________ 8
Warning light, AIR BAG ____________ 26
Warning lights ___________________ 46
Washers ______________________ 180
Washers, windshield _____________ 181
Washing the car _________________ 209
Waxing and polishing ____________ 209
Wear indicators, tires _____________ 200
Wheels and tires ____________ 198, 233
Wheels and tires, sizes ___________ 233
Window-glass sensor, car alarm _____ 39
Windshield washers _______________ 65
Windshield wipers ________________ 65
Wiper blades, headlamp __________ 180
Wiper blades, replacing ___________ 180
Wipers and washers __________ 65, 180
ProCarManuals.com